Beruflich Dokumente
Kultur Dokumente
CIBSE Guide C
fg
CIBSE
Oxford
z E I N E M A N N
Auckland Boston Johannesburg Melbourne New Delhi
Butterworth-Heinemann
Linacre House, Jordan Hill, Oxford OX2 8DP
225 Wildwood Avenue, Woburn, MA 01 801-2041
A division of Reed Educational and Professional Publishing Ltd
All rights reserved. No part of this publication may be reproduced in any material form
(including photocopying or storing in any medium by electronic means and whether or not
transiently or incidentally t o some other use of this publication) without the written
permission of the copyright holder except in accordance with the provisions of the Copyright,
Designs and Patents Act 1988 or under the terms of a licence issued by the Copyright
Licensing Agency Ltd, 90 Tottenham Court Road, London, England W1 P OLP. Applications for
the copyright holder's written permission t o reproduce any part of this publication should be
addressed to the publishers
Whilst the advice and information in this book are believed t o be true and accurate at the
date of going t o press, neither the Chartered Institution of Building Services Engineers nor
the publisher can accept any legal responsibility or liability for any errors or omissions that
may be made.
CORRIGENDA
(1) Page 1-6: Figure 1.3: units for moisture content should read ‘kg.kg-’’, not ’k.J.kg-”
2 l p c2
Ap= -
2 dh
(3) Page 4-92: Table 4.47(c): heading for column 1 should read ‘dl Idc’,not ‘dbld,’
(4) Page 4-96: Table 4.60: heading for column 6 should read ‘1.5’, not ‘1.15’
(5) Page 4-96: Table 4.62: table caption should read ‘Values of C2, rand C3’
(6) Page 4-82: equation 4.24: numerical factor on top line should read ‘3.032’, not ‘30.32’
(7) ’
Pages 4-83 to 4-85: Table 4.43: units for A Z / l should read ‘kPa1.929.m-1
(8) Page 4-108: text following Table 4.109: first sentence should read ‘Idelchik ... as for sections
4.10.3.21 and 4.10.5.12.’
(9) Page 4-1 10: Table 4.122: table caption should read ‘Values of C2 for circular segmented
gooseneck bend’; text immediately above table caption should read ‘where 61is the factor for a
single segmented bend (4.10.5.2)’
(10) Page 4-1 10: section 4.10.5.5: text alongside diagram should read ‘where 41is the factor for a
single segmented bend, section 4.10.5.2, C2 is as for section 4.10.5.4 and C3 is given below.’
November 2002
CHARTERED INSTITUTION OF BUILDING SERVICES ENGINEERS
CORRIGENDA
(1) Page 1-6: Figure 1.3: units for moisture content should read ‘kg·kg–1’, not ‘kJ·kg–1’
(2) Page 4-2: equation 4.2: divisor on right hand side should be ‘ν ’ (kinematic viscosity),
not ‘υ ’ (specific volume)
(3) Page 4-4: foot of left hand column: third estimate should read ‘0.02073’, not ‘0.2073’.
λ l ρ c2
∆p = ——–
2 dh
(5) Page 4-92: Table 4.47(c): heading for column 1 should read ‘d1 / dc’, not ‘d b / dc’
(6) Page 4-96: Table 4.60: heading for column 6 should read ‘1.5’, not ‘1.15’
(7) Page 4-96: Table 4.62: table caption should read ‘Values of C2 , ζ and C3’
(8) Page 4-82: equation 4.24: numerical factor on top line should read ‘3.032’, not ‘30.32’
(9) Pages 4-83 to 4-85: Table 4.43: units for ∆Z / l should read ‘kPa1.929·m–1 ’
(10) Page 4-108: text following Table 4.109: first sentence should read ‘Idelchik ... as for sections
4.10.3.21 and 4.10.5.12.’
(11) Page 4-110: Table 4.122: table caption should read ‘Values of C 2 for circular segmented
gooseneck bend’; text immediately above table caption should read ‘where ζ 1 is the factor for a
single segmented bend (4.10.5.2)’
(12) Page 4-110: section 4.10.5.5: text alongside diagram should read ‘where ζ 1 is the factor for a
single segmented bend, section 4.10.5.2, C2 is as for section 4.10.5.4 and C3 is given below.’
(14) Page 4-120: equation 4.A2.4: inner bracket on right hand side should include ‘l / ∆p’,
not ‘1 / ∆p’.
February 2004
Foreword
This 2001 edition of CIBSE Guide C contains significant changes from the previous 1986
edition. Although basic physical data does not change with time, the refinement of meas-
urement and calculation techniques means that even this basic data needs to be reviewed at
intervals. Additionally, revisions to practice in calculation methods, product selection and
usage led to a requirement for changes in the presentation of the data. Much of the data in
the 1986 edition actually dates from 1970 and was therefore ripe for review.
The changes made for the 2001 edition are summarised below:
Section 1: Properties of humid air. The data tables remain unchanged but the intro-
duction has been updated. A critique of the data has been published in Building Services
Engineering Research and Technology, to which interested readers are referred (reference 11
to section 1).
Section 2: Properties of water and steam. This section has been reviewed and found to
need no amendment.
Section 3: Heat transfer. This section has been completely rewritten. The theoretical
basis has been reviewed in the light of current knowledge and the calculation procedures
updated. Reference tables have been updated to reflect current practice and needs.
Section 4: Flow of fluids in pipes and ducts. This section has been completely rewrit-
ten. Both calculation methods and reference tables have been updated. In particular, the
opportunity has been taken to replace the limited and oversimplified tables of resistance
coefficients with a more comprehensive and rigorous treatment.
Section 5: Fuels and combustion. This section has been reviewed and comprehensively
. .
updated to take account of changes to fuels and fuel characteristics.
Section 6: Units, standard and mathematical data. This section has been reviewed and
updated. Some obsolete data has been deleted and some extra data added.
These changes have taken a significant amount of time and effort to complete and I would
like to express my thanks to the volunteer authors, contributors, reviewers and CIBSE
staff for their valuable contributions.
Finally, we hope that all users will find this Guide a useful and authoritative source of ref-
erence and guidance.
Paul Compton
Chairman, CIBSE Guide C
Co-ordinating editors
K J Butcher (CIBSE)
A C Watson (CIBSE)
I Index 1-1
1-1
~ 1. I Psychrometric data
1.2 CIBSE psychrometric chart (- 10 to +6OoC)
1.3 CIBSE psychrornetric chart (10 to 120°C)
Psychrometric tables
Since the properties of dry air and saturated water vapour 1.I .2 Standards adopted
are accurately known, the properties of a mixture of the
two can be established for the saturated case. For the All data are tabulated for an internationally agreed stan-
enthalpy and specific volume of moist air, at a condition dard atmospheric pressure(I2)of 101.325 kPa.
other than saturated, the method is exemplified by the fol-
lowing equations: The zero datum adopted by the National Engineering
Laboratory@) for the expression of the thermodynamic
h = ha + p (h, - ha)/lOO (1.1) properties of steam is the triple point of water, +O.Ol"C.
v = va + p (v, - va) / 100 (1.2)
The zero datum for the specific enthalpies of both dry air
where and liquid water has been taken here as 273.15 K (OOC).
where
U =
(0.287 + 0.461g) (273.15 + t) (1.16)
h = specific enthalpy of moist air (kJ.kg-' dry Pa
air)
ha = specific enthalpy of dry air7 (kJ.kg-') Corrections to specific enthalpy may be taken from
= moisture content (kg.kg-' dry air) Table 1.1.
g
= specific enthalpy of water vapour at the Figure 1.1, which gives the relationship between height
h,
dry-bulb temperature(8)(kJ.kg-' dry air) above sea level and barometric pressure, is drawn from the
equation:
Equation (1.1) gives answers having the same accuracy as
those obtained from equation (1.14) and is simpler to use. pa = 101.325 exp[(-9.81 pu) / (101 325)]
(1.17)
1 .o diverging slightly on each side of the 30°C line, and the tra-
ditional appearance of the chart is preserved.
0.9 The wet-bulb values shown are those read from a sling or
.
n
E
m
mechanically aspirated psychrometer and lines of percent-
age saturation are plotted instead of relative humidity.
0.8 Within the comfort zone, there is no practical difference
EQ between percentage saturation and relative humidity. In
.-vL any case, the difference diminishes as saturated or dry con-
w
E 0.7 ditions are approached.
em
m The psychrometric data used were taken from the tables
0.6 of the properties of humid air in this section of CIBSE
Guide C.
0.5
0 1000 2000 3000 4000 5000
Altitude I m 1.3 CIBSE psychrometric
Figure 1.1 Variation of barometric pressure with altitude chart (10 to 120°C)
where The psychrometric chart for 10 to 120°C has been based
p , = the particular atmospheric (barometric) on the ideal gas laws. This does not give a significant dif-
pressure (kPa) ference when compared with a chart constructed using
more accurate data, based on the method of Goff and
p = density of air (kg.m-3) Gratch(1,2).The principles of calcuation and drawing are
a = altitude above sea level (m) detailed elsewhere(14).
AB
1-6 Reference data
*
b
m
5
Psychrometric tables 1-7
100 100.00 2.003 -2.560 0.7544 0.3238 -7.5 -7.5 -7.5 -7.5
96 96.01 1.922 -2.760 0.7543 0.3108 -8.0 -7.7 -7.6 -7.6
92 92.02 1.842 -2.959 0.7542 0.2979 -8.5 -7.8 -7.8 -7.8
88 88.03 1.762 -3.158 0.7541 0.2850 -9.0 -8.0 -7.9 -7.9
84 84.04 1.682 -3.357 0.7541 0.2721 -9.5 -8.1 -8.0 -8.1
80 80.05 1.602 -3.556 0.7540 0.2592 - 10.0 -8.3 -8.1 -8.2
76 76.06 1.522 -3.756 0.7539 0.2462 - 10.6 -8.4 -8.3 -8.4
72 72.06 1.442 -3.955 0.7538 0.2333 - 11.2 -8.6 -8.4 -8.5
70 70.07 1.402 -4.054 0.7537 0.2268 - 11.5 -8.7 -8.5 -8.6
68 68.07 1.362 -4.154 0.7537 0.2204 - 11.9 -8.7 -8.5 -8.7
66 66.07 1.322 -4.254 0.7536 0.2139 -12.2 -8.8 -8.6 -8.8
64 64.07 1.282 -4.353 0.7536 0.2074 -12.5 -8.9 -8.7 -8.8
62 62.08 1.242 -4.453 0.7535 0.2010 -12.9 -9.0 -8.7 - 8.9
60 60.08 1.202 -4.552 0.7535 0.1945 -13.2 -9.0 -8.8 -9.0
58 58.08 1.162 -4.652 0.7534 0.1880 - 13.6 -9.1 -8.9 -9.1
56 56.08 1.122 -4.752 0.7534 0.1816 - 14.0 -9.2 -8.9 -9.1
54 54.08 1.081 -4.851 0.7533 0.1751 - 14.4 -9.3 -9.0 -9.2
52 52.08 1.041 -4.95 1 0.7533 0.1686 - 14.8 -9.4 -9.1 -9.3
50 50.08 1.001 -5.051 0.7532 0.1621 -15.2 -9.4 -9.1 -9.4
48 48.08 0.961 -5.150 0.7532 0.1557 -15.7 -9.5 -9.2 -9.4
46 46.08 0.921 -5.250 0.7531 0.1492 -16.1 -9.6 -9.3 -9.5
44 44.08 0.881 -5.349 0.7531 0.1427 - 16.6 -9.7 -9.3 -9.6
42 42.08 0.841 -5.449 0.7530 0.1362 -17.1 -9.8 -9.4 -9.7
40 40.08 0.801 -5.549 0.7530 0.1298 -17.6 -9.8 -9.5 -9.8
38 38.08 0.761 -5.648 0.7529 0.1233 - 18.2 -9.9 -9.5 -9.8
36 36.07 0.721 -5.748 0.7529 0.1168 - 18.7 - 10.0 -9.6 -9.9
34 34.07 0.681 -5.848 0.7528 0.1103 - 19.3 -10.1 -9.7 - 10.0
32 32.07 0.641 -5.947 0.7528 0.1038 -20.0 - 10.2 -9.7 -10.1
30 30.07 0.601 -6.047 0.7528 0.0973 - 20.6 - 10.2 -9.8 -10.1
28 28.06 0.561 -6.146 0.7527 0.0909 -21.4 - 10.3 -9.9 - 10.2
24 24.06 0.481 -6.346 0.7526 0.0779 -22.9 - 10.5 - 10.0 - 10.4
20 20.05 0.400 -6.545 0.7525 0.0649 - 24.8 - 10.6 -10.1 -10.5
16 16.04 0.320 -6.744 0.7524 0.0519 -27.0 - 10.8 - 10.3 - 10.7
12 12.03 0.240 -6.943 0.7523 0.0390 -29.8 -11.0 - 10.4 - 10.9
8 8.02 0.160 -7.142 0.7522 0.0260 -33.7 -11.1 - 10.5 -11.0
4 4.01 0.080 -7.341 0.7521 0.0130 -40.0 -11.3 - 10.7 -11.2
0 0.00 0.000 -7.541 0.7520 0.0000 - -11.5 - 10.8 -11.3
1-10 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
pl% 41% Moisture Specific Specific pslkPa t,l”C temperature Screen Sling
content enthalpy volume t */oc t’JC t PC
glg.kg-’ hlk J. kg-I i/m3.kg-I
100 100.00 2.824 3.526 0.7668 0.4560 -3.5 -3.5 -3.5 -3.5
96 96.02 2.71 1 3.244 0.7667 0.4378 -4.0 -3.7 -3.7 -3.7
92 92.03 2.598 2.962 0.7666 0.4197 -4.5 -3.9 -3.8 -3.9
88 88.05 2.485 2.680 0.7664 0.4015 -5.0 -4.1 -4.0 -4.1
84 84.06 2.372 2.399 0.7663 0.3833 -5.5 -4.3 -4.2 -4.2
80 80.07 2.260 2.117 0.7662 0.3651 -6.1 -4.5 -4.3 -4.4
76 76.08 2.146
~. . 1.835 0.7660 0.3469 -6.7 -4.7 -4.5 -4.6
72 72.09 2.034 1.553 0.7659 0.3287 -7.3 -4.9 -4.7 -4.8
70 70.09 1.977 1.412 0.7658 0.3196 -7.6 -5.0 -4.7 -4.9
68 68.10 1.920 1.272 0.7657 0.3105 - 8.0 -5.1 -4.8 -5.0
66 66.10 1.864 1.131 0.7657 0.3014 -8.3 -5.2 -4.9 -5.1
64 64.10 1.808 0.990 0.7656 0.2923 -8.7 -5.3 -5.0 -5.2
62 62.1 1 1.751 0.849 0.7655 0.2832 -9.0 -5.4 -5.1 -5.3
60 60.11 1.695 0.708 0.7655 0.2741 -9.4 -5.5 -5.2 -5.4
58 58.11 1.638 0.567 0.7654 0.2650 -9.8 -5.6 -5.3 -5.5
56 56.1 1 1.582
..~ 0.426 0.7653 0.2559 - 10.2 -5.7 -5.3 -5.6
54 54.11 1.525 0.285 0.7653 0.2468 - 10.6 -5.8 -5.4 -5.7
52 52.11 1.469 0.144 0.7652 0.2376 -11.0 -5.9 -5.5 -5.8
50 50.11 1.412 0.003 0.7651 0.2285 -11.4 - 6.0 -5.6 -5.9
48 48.11 1.356 -0.138 0.7650 0.2194 -11.9 -6.1 -5.7 -6.0
46 46.11 1.299 -0.278 0.7650 0.2103 - 12.4 -6.2 -5.8 -6.1
44 44.11 1.243 -0.419 0.7649 0.201 1 - 12.9 -6.3 -5.9 -6.2
42 42.1 1 1.186 -0.560 0.7648 0.1920 -13.4 -6.4 -5.9 -6.3
40 40.11 1.130 -0.701 0.7648 0.1829 -13.9 -6.5 -6.0 -6.4
38 38.11 1.073 -0.842 0.7647 0.1738 - 14.5 -6.6 -6.1 -6.5
36 36.10 1.017 -0.983 0.7646 0.1646 -15.1 -6.7 -6.2 -6.6
34 34.10 0.960 -1.124 0.7646 0.1555 -15.7 -6.8 -6.3 -6.7
32 32.10 0.904 - 1.265 0.7645 0.1464 - 16.3 -6.9 -6.4 -6.8
30 30.09 0.847 - 1.406 0.7644 0.1372 - 17.0 -7.0 -6.5 -6.9
28 28.09 0.791 -1.546 0.7644 0.1281 - 17.8 -7.1 -6.5 -7.0
24 24.08 0.678 - 1.828 0.7642 0.1098 - 19.4 -7.3 -6.5 -7.2
20 20.07 0.565 -2.110 0.7641 0.0915 -21.3 -7.5 -6.5 -7.4
16 16.06 0.452 -2.392 0.7639 0.0732 -23.6 -7.7 -6.5 -7.6
12 12.05 0.339 -2.674 0.7638 0.0549 -26.5 - 8.0 -6.5 -7.8
8 8.03 0.226 -2.956 0.7637 0.0366 -30.4 -8.2 -6.5 - 8.0
4 4.02 0.113 -3.237 0.7635 0.0183 -36.9 -8.4 -6.5 -8.2
0 0.00 0.000 -3.519 0.7634 0.0000 - -8.6 -6.5 -8.5
1-14 Reference data
- 2 . W DRY BULB
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
,ll I% 41% Moisture Specific Specific pJkPa t,l”C temperature Screen Sling
content enthalpy volume l*l”C f‘JC PC
f Is,
de.ke-I hlkl.ke-1 dm3.ke-I
100 100.00 3.073 5.158 0.7700 0.4960 -2.5 -2.5 -2.5 -2.5
96 96.02 2.950 4.851 0.7698 0.4762 -3.0 -2.7 - 2.7 - 2.7
92 92.04 2.827 4.544 0.7697 0.4565 -3.5 -2.9 -2.8 -2.9
88 88.05 2.704 4.237 0.7695 0.4367 -4.0 -3.1 -3.0 -3.1
84 84.07 2.582 3.930 0.7694 0.4170 -4.6 -3.3 -3.2 -3.3
80 80.08 2.458 3.623 0.7692 0.3972 -5.1 -3.5 -3.4 -3.5
76 76.09 2.336 3.317 0.7691 0.3774 -5.7 -3.7 -3.6 -3.7
72 72.10 2.213 3.010 0.7689 0.3576 -6.4 -3.9 -3.7 -3.9
70 70.10 2.151 2.856 0.7689 0.3477 -6.7 -4.0 -3.8 -4.0
68 68.11 2.090 2.703 0.7688 0.3378 -7.0 -4.1 -3.9 -4.1
66 66.11 2.028 2.550 0.7687 0.3279 -7.4 -4.2 -4.0 -4.2
64 64.11 1.967 2.396 0.7686 0.3180 -7.7 -4.4 -4.1 -4.3
62 62.12 1.905 2.243 0.7686 0.3081 -8.1 -4.5 -4.2 -4.4
60 60.12 1.844 2.089 0.7685 0.2982 -8.4 -4.6 -4.3 -4.5
58 58.12 1.782 1.936 0.7684 0.2883 -8.8 -4.7 -4.4 -4.6
56 56.12 1.721 1.782 0.7683 0.2783 -9.2 -4.8 -4.5 -4.7
54 54.12 1.660 1.629 0.7683 0.2684 -9.6 -4.9 -4.5 -4.8
52 52.12 1.598 1.476 0.7682 0.2585 -10.1 -5.0 -4.6 -4.9
50 50.12 1.537 1.322 0.7681 0.2486 -10.5 -5.1 -4.7 -5.0
48 48.12 1.475 1.169 0.7680 0.2387 -11.0 -5.2 -4.8 -5.1
46 46.12 1.414 1.015 0.7680 0.2288 - 11.4 -5.3 -4.9 -5.2
44 44.12 1.352 0.862 0.7679 0.2188 -11.9 -5.4 -5.0 -5.3
42 42.12 1.291 0.708 0.7678 0.2089 - 12.4 -5.5 -5.1 -5.4
40 40.12 1.229 0.555 0.7677 0.1990 - 13.0 -5.7 -5.2 -5.6
38 38.12 1.168 0.402 0.7677 0.1890 -13.5 -5.8 -5.3 -5.7
36 36.11 1.106 0.248 0.7676 0.1791 -14.1 -5.9 -5.4 -5.8
34 34.11 1.045 0.095 0.7675 0.1692 -14.8 -6.0 -5.5 -5.9
32 32.11 0.983 -0.059 0.7674 0.1592 -15.4 -6.1 -5.6 -6.0
30 30.10 0.922 -0.212 0.7674 0.1493 -16.1 -6.2 -5.7 -6.1
28 28.10 0.860 -0.366 0.7673 0.1394 - 16.9 -6.3 -5.8 -6.2
24 24.09 0.738 -0.672 0.7671 0.1195 -18.5 -6.5 -5.9 -6.4
20 20.08 0.615 -0.979 0.7670 0.0996 -20.4 -6.8 -6.1 -6.6
16 16.07 0.492 - 1.286 0.7668 0.0797 -22.7 -7.0 -6.3 -6.9
12 12.05 0.369 -1.593 0.7667 0.0598 -25.6 -7.2 -6.5 -7.1
8 8.04 0.246 - 1.900 0.7665 0.0399 -29.6 -7.5 -6.7 -7.3
4 4.02 0.122 -2.207 0.7664 0.0199 -36.1 -7.7 -6.9 -7.5
0 0.00 0.000 -2.514 0.7662 0.0000 - -7 9 -7.1 -7.8
Psychrometric tables 1-15
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,PC temperature Screen Sling
content enthalpy volume t*/"C t'JC t'JC
g/g.kg-I hlkJkg-I vlm3.kg-'
100 100.00 3.342 6.840 0.7732 0.5391 -1.5 -1.5 -1.5 -1.5
96 96.02 3.208 6.506 0.7730 0.5177 -2.0 - 1.7 -1.7 - 1.7
92 92.04 3.075 6.172 0.7729 0.4962 -2.5 -1.9 -1.9 -1.9
88 88.06 2.941 5.838 0.7727 0.4747 -3.0 -2.1 -2.1 -2.1
84 84.07 2.807 5.504 0.7725 0.4533 -3.6 -2.4 -2.2 -2.3
80 80.09 2.674 5.171 0.7724 0.4318 -4.1 -2.6 -2.4 -2.5
76 76.10 2.540 4.837 0.7722 0.4103 -4.7 -2.8 -2.6 -2.8
72 72.1 1 2.406 4.503 0.7720 0.3888 -5.4 -3.0 -2.8 -3.0
70 70.11 2.339 4.336 0.7720 0.3780 -5.7 -3.1 -2.9 -3.1
68 68.12 2.272 4.169 0.7719 0.3672 -6.0 -3.2 -3.0 -3.2
66 66.12 2.206 4.002 0.7718 0.3565 -6.4 -3.3 -3.1 -3.3
64 64.12 2.139 3.835 0.7717 0.3457 -6.7 -3.5 -3.2 -3.4
62 62.13 2.072 3.668 0.7716 0.3349 -7.1 -3.6 -3.3 -3.5
60 60.13 2.005 3.501 0.7715 0.3242 - 7.5 -3.7 -3.4 -3.6
58 58.13 1.938 3.334 0.7715 0.3134 - 7.9 -3.8 -3.5 -3.7
56 56.13 1.872 3.167 0.7714 0.3026 -8.3 -3.9 -3.6 -3.8
54 54.13 1.805 3.000 0.7713 0.2918 -8.7 -4.0 -3.7 -3.9
52 52.13 1.738 2.833 0.7712 0.2810 -9.1 -4.1 -3.8 -4.1
50 50.13 1.671 2.666 0.7711 0.2703 -9.6 -4.3 -3.9 -4.2
48 48.13 1.604 2.499 0.7710 0.2595 - 10.0 -4.4 -4.0 -4.3
46 46.13 1.537 2.332 0.7710 0.2487 -10.5 -4.5 -4.1 -4.4
44 44.13 1.470 2.165 0.7709 0.2379 -11.0 -4.6 -4.2 -4.5
42 42.13 1.404 1.998 0.7708 0.2271 -11.5 -4.7 -4.3 -4.6
40 40.13 1.337 1.831 0.7707 0.2163 -12.1 -4.8 -4.4 -4.7
38 38.13 1.270 1.664 0.7706 0.2056 - 12.6 -5.0 -4.5 -4.8
36 36.12 1.203 1.497 0.7706 0.1948 - 13.2 -5.1 -4.5 -5.0
34 34.12 1.136 1.330 0.7705 0.1840 -13.8 -5.2 -4.6 -5.1
32 32.12 1.069 1.163 0.7704 0.1732 - 14.5 -5.3 -4.7 -5.2
30 30.11 1.003 0.996 0.7703 0.1623 -15.2 -5.4 -4.8 -5.3
28 28.11 0.936 0.829 0.7702 0.1515 - 16.0 -5.5 -5.0 -5.4
24 24.10 0.802 0.496 0.7701 0.1299 - 17.6 -5.8 -5.2 -5.7
20 20.09 0.668 0.162 0.7699 0.1083 - 19.5 -6.0 -5.4 -5.9
16 16.07 0.535 -0.172 0.7697 0.0866 -21.8 -6.3 -5.6 -6.1
12 12.06 0.401 -0.506 0.7696 0.0650 -24.8 -6.5 -5.8 -6.4
8 8.04 0.267 -0.840 0.7694 0.0433 -28.8 -6.8 -6.0 -6.6
4 4.02 0.134 -1.174 0.7692 0.021 7 -35.3 -7.0 -6.2 -6.8
0 0.00 0.000 - 1.508 0.7691 0.0000 - -7.3 -6.4 -7.1
1-16 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
/(I% 41% Moisture Specific Specific pJkPa t,l”C temperature Screen Sling
content enthalov volume l*l”C t‘ /”c t’ .PC
g/g.kg-l hlkJ.kg” vim'.kg-’
100 100.00 3.632 8.577 0.7764 0.5857 -0.5 -0.5 -0.5 -0.5
96 96.02 3.487 8.214 0.7762 0.5624 -1.0 -0.7 -0.7 -0.7
92 92.04 3.342 7.851 0.7760 0.5391 -1.5 -0.9 -0.9 -0.9
88 88.06 3.196 7.485 0.7759 0.5158 -2.0 - 1.2 -1.1 -1.2
84 84.08 3.051 7.124 0.7757 0.4924 -2.6 -1.4 - 1.3 -1.4
80 80.09 2.906 6.761 0.7755 0.4691 -3.2 -1.6 -1.5 -1.6
76 76.11 2.760 6.398 0.7753 0.4457 -3.8 -1.9 -1.7 -1.8
72 72.12 2.615 6.035 0.7751 0.4224 -4.4 -2.1 -1.9 -2.0
70 70.12 2.542 5.853 0.775 1 0.4107 -4.7 -2.2 -2.0 -2.2
68 68.13 2.470 5.672 0.7750 0.3990 -5.1 -2.3 -2.1 -2.3
66 66.13 2.397 5.490 0.7749 0.3873 -5.4 -2.4 -2.2 -2.4
64 64.13 2.325 5.309 0.7748 0.3756 -5.8 -2.6 -2.3 -2.5
62 62.14 2.252 5.127 0.7747 0.3639 -6.1 -2.7 -2.4 -2.6
60 60.14 2.179 4.945 0.7746 0.3522 -6.5 -2.8 -2.5 -2.7
58 58.14 2.107 4.764 0.7745 0.3405 -6.9 -2.9 -2.6 -2.8
56 56.14 2.034 4.582 0.7744 0.3288 -7.3 -3.0 -2.7 -3.0
54 54.14 1.961 4.400 0.7743 0.3171 -7.7 -3.2 -2.8 -3.1
52 52.14 1.889 4.219 0.7742 0.3054 -8.2 -3.3 -2.9 -3.2
50 50.14 1.816 4.037 0.7742 0.2937 -8.6 - 3.4 -3.0 -3.3
48 48.14 1.744 3.856 0.7741 0.2820 -9.1 - 3.5 -3.1 -3.4
46 46.14 1.671 3.674 0.7740 0.2702 -9.6 -3.6 -3.2 -3.6
44 44.14 1.598 3.492 0.7739 0.2585 - 10.1 -3.8 -3.3 - 3.7
42 42.14 1.526 3.31 1 0.7738 0.2468 - 10.6 -3.9 -3.4 -3.8
40 40.14 1.453 3.129 0.7737 0.235 1 -11.1 -4.0 -3.5 -3.9
38 38.14 1.380 2.948 0.7736 0.2234 -11.7 -4.1 -3.6 -4.0
36 36.13 1.308 2.766 0.7735 0.2116 -12.3 -4.3 -3.7 -4.2
34 34.13 1.235 2.584 0.7734 0.1999 - 12.9 -4.4 -3.8 -4.3
32 32.13 1.162 2.403 0.7734 0.1882 -13.6 -4.5 -3.9 -4.4
30 30.12 1.090 2.221 0.7733 0.1764 - 14.3 -4.6 -4.0 -4.5
28 28.12 1.017 2.040 0.7732 0.1647 -15.1 -4.8 -4.2 -4.6
24 24.11 0.872 1.676 0.7730 0.1412 -16.7 -5.0 -4.4 -4.9
20 20.09 0.726 1.313 0.7728 0.1177 -18.7 -5.3 -4.6 -5.1
16 16.08 0.581 0.950 0.7726 0.0942 -21.0 -5.5 -4.8 -5.4
12 12.06 0.436 0.587 0.7725 0.0706 -23.9 -5.8 -5.0 -5.6
8 8.04 0.291 0.224 0.7723 0.0471 -28.0 -6.1 -5.2 -5.9
4 4.02 0.145 -0.140 0.7721 0.0236 -34.6 -6.3 -5.5 -6.2
0 0.00 0.000 -0.503 0.7719 0.0000 - -6 h -5 I -6 4
Psychrometric tables 1-17
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,l”C temperature Screen Sling
content enthalpy volume t*JT t’JC t’JC
g/g.kg-’ hlkJ.kg-I vlm3.kg-‘
100 100.00 3.789 9.475 0.7780 0.6108 0.0 0.0 0.0 0.0
96 96.02 3.637 9.096 0.7778 0.5865 -0.5 -0.2 -0.2 -0.2
92 92.04 3.486 8.717 0.7776 0.5622 -1.0 -0.5 -0.4 -0.4
88 88.06 3.334 8.338 0.7775 0.5379 -1.5 -0.7 -0.6 -0.7
84 84.08 3.183 7.959 0.7773 0.5136 -2.1 -0.9 -0.8 -0.9
80 80.10 3.031 7.580 0.7771 0.4892 -2.7 -1.1 - 1.0 -1.1
76 76.11 2.880 7.201 0.7769 0.4649 -3.3 -1.4 -1.2 - 1.3
72 72.12 2.728 6.822 0.7767 0.4405 -3.9 -1.6 -1.4 -1.6
70 70.13 2.652 6.633 0.7766 0.4283 -4.2 -1.7 -1.5 -1.7
68 68.13 2.576 6.443 0.7765 0.4161 -4.6 - 1.9 -1.6 - 1.8
66 66.14 2.501 6.254 0.7764 0.4039 -4.9 -2.0 -1.7 - 1.9
64 64.14 2.425 6.064 0.7763 0.3918 -5.3 -2.1 -1.8 -2.0
62 62.14 2.349 5.875 0.7762 0.3796 -5.7 -2.2 -1.9 -2.2
60 60.14 2.273 5.685 0.7761 0.3674 -6.0 -2.4 -2.0 -2.3
58
~~ 58.15
.. ~~ 2.198 5.496 0.7761 0.3552 -6.4 -2.5 -2.1 -2.4
56 56.15 2.122 5.306 0.7760 0.3429 -6.8 -2.6 -2.2 -2.5
54 54.15 2.046 5.117 0.7759 0.3307 -7.3 -2.7 -2.4 -2.6
52 52.15 1.970 4.927 0.7758 0.3185 -7.7 -2.8 -2.5 -2.8
50 50.15 1.894 4.738 0.7757 0.3063 -8.1 -3.0 -2.6 -2.9
48 48.15 1.819 4.548 0.7756 0.2941 -8.6 -3.1 -2.7 -3.0
46 46.15 1.743 4.359 0.7755 0.2819 -9.1 -3.2 -2.8 -3.1
44 44.15 1.667 4.169 0.7754 0.2696 -9.6 -3.4 -2.9 -3.3
42 42.15 1.591 3.980 0.7753 0.2574 -10.1 -3.5 - 3.0 -3.4
40 40.14 1.516 3.790 0.7752 0.2452 - 10.7 -3.6 -3.1 -3.5
38 38.14 1.440 3.601 0.775 1 0.2330 - 11.2 -3.7 -3.2 -3.6
36 36.14 1.364 3.41 1 0.7750 0.2207 -11.8 -3.9 -3.3 -3.8
34 34.14 1.288 3.222 0.7749 0.2085 -12.5 -4.0 - 3.4 -3.9
32 32.13 1.212 3.032 0.7748 0.1962 -13.1 -4.1 -3.5 -4.0
30 30.13 1.137 2.843 0.7747 0.1840 -13.8 -4.3 -3.6 -4.1
28 28.12 1.061 2.653 0.7747 0.1718 - 14.6 -4.4 -3.8 -4.3
24 24.11 0.909 2.274 0.7745 0.1473 -16.3 -4.7 -4.0 -4.5
20 20.10 0.758 1.895 0.7743 0.1228 - 18.2 -4.9 -4.2 -4.8
16 16.08 0.606 1.516 0.7741 0.0982 -20.5 -5.2 -4.4 -5.0
12 12.06 0.455 1.137 0.7739 0.0737 -23.5 -5.5 -4.7 -5.3
8 8.04 0.303 0.758 0.7737 0.0491 -27.6 -5.7 -4.9 -5.5
4 4.02 0.152 0.379 0.7735 0.0246 -34.2 -h.O
.. -5.1 -5.8
0 0.00 0.000 0.000 0.7733 0.0000 - -6.3 -5.3 -6.1
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pslkPa t,l"C temperature Screen Sling
content enthalpy volume t*PC t'JC t'JC
glg.kg-' hlkJ.kg-l vlm3.kg-'
100 100.00 4.706 14.81 0.7877 0.7575 3.0 3.0 3.0 3.0
96 96.03 4.518 14.34 0.7875 0.7274 2.4 2.7 2.8 2.8
92 92.06 4.329 13.87 0.7873 0.6973 1.8 2.5 2.6 2.5
88 88.08 4.141 13.40 0.7870 0.6672 1.2 2.2 2.3 2.2
84 84.10 3.953 12.93 0.7868 0.6371 0.6 2.0 2.1 2.0
80 80.12 3.765 12.45 0.7866 0.6069 -0.1 1.7 1.9 1.7
76 76.14 3.576 11.98 0.7863 0.5768 -0.7 1.4 1.6 1.5
72 72.15 3.388 11.51 0.7861 0.5466 -1.3 1.2 1.4 1.2
70 70.16 3.294 11.27 0.7860 0.5314 -1.7 1.0 1.3 1.1
68 68.16 3.200 11.04 0.7859 0.5164 -2.0 0.9 1.2 1.o
66 66.17 3.106 10.80 0.7857 0.5012 -2.4 0.8 1.1 0.8
64 64.17 3.012 10.57 0.7856 0.4861 -2.7 0.6 0.9 0.7
62 62.18 2.918 10.33 0.7855 0.4710 -3.1 0.5 0.8 0.6
60 60.18 2.824 10.09 0.7854 0.4559 -3.5 0.4 0.7 0.4
58
~~ 58.18
~~ ~~ 2.729 9.859 0.7853 0.4407 -3.9 0.2 0.6 0.3
56 56.18 2.635 9.623 0.7852 0.4256 -4.3 0.1 0.5 0.2
54 54.19 2.541 9.387 0.7850 0.4105 -4.7 -0.3 0.3 -0.2
52 52.19 2.447 9.151 0.7849 0.3953 -5.2 -0.4 0.2 -0.3
50 50.19 2.353 8.915 0.7848 0.3802 -5.6 -0.5 0.1 -0.5
48 48.19 2.259 8.679 0.7847 0.3650 -6.1 -0.7 -0.2 -0.6
46 46.19 2.166 8.444 0.7846 0.3499 -6.6 -0.8 -0.3 -0.7
44 44.18 2.071 8.208 0.7844 0.3347 -7.1 -1.0 -0.5 -0.9
42 42.18 1.976 7.972 0.7843 0.3195 -7.7 -1.1 -0.6 - 1.0
40 40.18 1.882 7.736 0.7842 0.3044 -8.2 -1.3 -0.7 - 1.2
38 38.18 1.788 7.500 0.7841 0.2892 -8.8 -1.4 -0.8 - 1.3
1.694 7.264 0.7840 0.2740 -9.4 - 1.6 -1.0 - 1.4
1.600 7.028 0.7839 0.2588 - 10.1 -1.7 -1.1 - 1.6
1.506 6.792 0.7837 0.2436 - 10.7 -1.9 -1.2 - 1.7
1.412 6.556 0.7836 0.2284 -11.5 -2.0 -1.4 -1.9
28 28.15 1.318 6.320 0.7835 0.2132 - 12.2 -2.2 -1.5 -2.0
24 24.14 1.129 5.849 0.7833 0.1828 - 13.9 -2.5 -1.7 -2.3
20 20.12 0.941 5.377 0.7830 0.1524 - 15.9 -2.8 -2.0 -2.6
16 16.10 0.753 4.905 0.7828 0.1220 - 18.3 -3.1 -2.3 -2.9
12 12.08 0.565 4.433 0.7826 0.0915 -21.3 -3.4 -2.5 -3.2
8 8.06 0.376 3.962 0.7823 0.0610 -25.4 -3.7 -2.8 -3.5
4 4.03 0.188 3.490 0.7821 0.0305 -32.1 -4.1 -3.1 -3.8
0 0.00 0.000 3.018 0.7819 0.0000 - -4 4 -3.3 -4.2
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,PC temperature Screen Sling
content enthalpy volume t*l”C f‘JC t’,PC
g/g.kg-‘ hlkJ.kg-I vlm3.kg-’
100 100.00 6.235 22.72 0.801 1 1.001 7.0 7.0 7 .O 7.0
96 96.04 5.986 22.09 0.8008 0.9616 6.4 6.7 6.7 6.7
92 92.07 5.736 21.46 0.8005 0.9219 5.8 6.4 6.5 6.4
88 88.10 5.487 20.84 0.8002 0.8822 5.2 6.1 6.2 6.1
5.238 20.21 0.7999 0.8424 4.5 5.8 5.9 5.8
4.988 19.58 0.7995 0.8026 3.8 5.5 5.6 5.5
4.739 18.95 0.7992 0.7628 3.1 5.2 5.4 5.2
4.489 18.33 0.7989 0.7229 2.3 4.8 5.1 4.9
70 70.21 4.365 18.01 0.7988 0.7030 2.0 4.7 5.0 4.7
68 68.22 4.240 17.70 0.7986 0.6830 1.5 4.5 4.8 4.6
66 66.22 4.115 17.39 0.7984 0.6631 1.1 4.4 4.7 4.4
64 64.23 3.990 17.07 0.7983 0.6431 0.7 4.2 4.5 4.3
62 62.23 3.866 16.76 0.7981 0.6231 0.3 4.0 4.4 4.1
60 60.24 3.741 16.45 0.7980 0.6032 -0.1 3.9 4.2 3.9
3.616 16.13 0.7978 0.5832 -0.6 3.7 4.1 3.8
3.492 15.82 0.7977 0.5632 - 1.0 3.5 4.0 3.6
3.367 15.51 0.7975 0.5432 - 1.4 3.4 3.8 3.5
3.242 15.19 0.7973 0.5232 - 1.9 3.2 3.7 3.3
50 50.25 3.118 14.88 0.7972 0.5031 -2.3 3.0 3.5 3.1
48 48.25 2.993 14.57 0.7970 0.4831 -2.8 2.9 3.4 3.0
46 46.25 2.868 14.25 0.7969 0.4631 -3.3 2.7 3.2 2.8
44 44.24 2.744 13.94 0.7967 0.4430 -3.8 2.5 3.1 2.6
42 42.24 2.619 13.62 0.7965 0.4230 -4.4 2.4 2.9 2.5
40 40.24 2.494 13.31 0.7964 0.4029 -5.0 2.2 2.8 2.3
38 38.23 2.369 13.00 0.7962 0.3828 -5.6 2.0 2.6 2.1
36 36.23 2.245 12.68 0.7961 0.3628 -6.2 1.8 2.5 2.0
34 34.22 2.120 12.37 0.7959 0.3427 -6.8 1.7 2.3 1.8
32 32.22 1.995 12.06 0.7958 0.3226 -7.5 1.5 2.2 1.6
30 30.21 1.871 11.74 0.7956 0.3025 -8.3 1.3 2.0 1.4
28 28.20 1.746 11.43 0.7954 0.2824 -9.1 1.1 1.9 1.3
24 24.18
- . ~. 1.496 10.80 0.7951 0.2421 - 10.8 0.8 1.6 0.9
20 20.16 1.247 10.18 0.7948 0.2018 - 12.8 0.4 1.2 0.6
16 16.13 0.998 9.550 0.7945 0.1616 -15.3 -0.5 0.9 0.2
12 12.11 0.748 8.923 0.7942 0.1212 -18.3 -0.8 0.6 -0.6
8 8.07 0.499 8.296 0.7939 0.0808 -22.6 -1.2 0.3 -1.0
4 4.04 0.249 7.669 0.7935 0.0404 -29.5 -1.6 -0.5 -1.4
0 0.00 0.000 7.042 0.7932 0.0000 - -2.0 -0.8 -1.8
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
,U 1% +I% Moisture Specific Specific pJkPa t,lT temperature Screen Sling
content enthalpy volume t*PC t'JC t ' s PC
j
g/g.kg-I hlkJ.kg-l vlm'.kg-l
100 100.00 7.659 29.35 0.8116 1.227 10.0 10.0 10.0 10.0
96 96.05 7.352 28.58 0.8112 1.180 9.4 9.7 9.7 9.7
92 92.09 7.046 27.81 0.8108 1.130 8.8 9.3 9.4 9.3
88 88.13 6.740 27.04 0.8104 1.081 8.1 9.0 9.1 9.0
84 84.16 6.433 26.27 0.8100 1.034 7.5 8.7 8.8 8.7
80 80.19 6.127 25.50 0.8096 0.9841 6.7 8.3 8.5 8.3
76 76.22 5.821 24.72 0.8092 0.9354 6.0 8.0 8.2 8.0
72 72.24 5.514 23.95 0.8088 0.8866 5.2 7.6 7.8 7.6
70 70.26 5.361 23.57 0.8086 0.8622 4.8 7.4 7.7 7.5
68 68.26 5.208 23.18 0.8084 0.8377 4.4 7.2 7.5 7.3
66 66.27 5.055 22.79 0.8082 0.8133 4.0 7.1 7.4 7.1
64 64.28 4.902 22.41 0.8080 0.7888 3.6 6.9 7.2 6.9
62 62.29 4.748 22.02 0.8078 0.7644 3.1 6.7 7.0 6.7
60 60.29 4.595 2 1.64 0.8076 0.7398 2.7 6.5 6.9 6.6
58 58.30 4.442 _21.25
_ ~. 0.8074
. .. 0.7154 2.2 6.3 6.7 6.4
56 56.30 4.289 20.86 0.8072 0.6909 1.7 6.1 6.5 6.2
54 54.30 4.136 20.48 0.8070 0.6664 1.2 5.9 6.4 6.0
52 52.30 3.983 20.09 0.8069 0.6419 0.7 5.7 6.2 5.8
50 50.30 3.829 19.71 0.8067 0.6173 0.1 5.6 6.0 5.6
48 48.30 3.676 19.32 0.8065 0.5928 -0.4 5.4 5.9 5.5
46 46.30 3.523 18.94 0.8063 0.5682 -0.9 5.2 5.7 5.3
44 44.30 3.370 18.55 0.8061 0.5436 -1.4 5.0 5.5 5.1
42 42.30 3.217 18.16 0.8059 0.5190 -2.0 4.8 5.4 4.9
40 40.29 3.064 17.78 0.8057 0.4945 -2.5 4.6 5.2 4.7
38 38.29 2.910 17.39 0.8055 0.4698 -3.1 4.4 5.0 4.5
36 36.28 2.757 i7.00 0.8053 0.4452 -3.8 4.2 4.8 4.3
34 34.27 2.604 16.62 0.8051 0.4206 -4.5 4.0 4.7 4.1
32 32.27 2.451 16.23 0.8049 0.3960 -5.2 3.8 4.5 3.9
30 30.26 2.298 15.85 0.8047 0.3713 -5.9 3.6 4.3 3.7
28 28.25 2.144 15.46 0.8045 0.3466 -6.7 3.4 4.1 3.5
24 24.22 1.838 14.69 0.8041 0.2973 -8.5 3.0 3.8 3.1
20 20.20 1.532 13.92 0.8037 0.2478 - 10.5 2.5 3.4 2.7
16 16.16 1.225 i3.15 0.8033 0.1984 -13.0 2.1 3.1 2.3
12 12.13 0.919 12.38 0.8029 0.1488 -16.1 1.7 2.7 1.9
8 8.09 0.613 11.60 0.8025 0.0993 -20.4 1.2 2.3 1.4
4 4.05 0.306 10.83 0.8021 0.0497 -27.4 0.8 1.9 1.o
0 0.00 0.000 10.06 0.8018 0.0000 - 0.3 1.6 0.6
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
/I/% 41% Moisture Specific Specific pJkPa t,l”C temperature Screen Sling
content enthahv volume t*l”C t’ /“c t’ 1.PC
glg.kg-I h1kJ.kg-l vlm3.kg-‘
100 100.00 9.060 35.44 0.8205 1.449 12.5 12.5 12.5 12.5
96 96.06 8.698 34.53 0.8201 1.391 11.9 12.1 12.2 12.1
92 92.11 8.336 33.61 0.8196 1.334 11.3 11.8 11.8 11.8
88 88.15 7.973 32.70 0.8191 1.277 10.6 11.4 11.5 11.4
84 84.19 7.611 31.78 0.8187 1.220 9.9 11.0 11.2 11.1
80 80.23 7.248 30.87 0.8182 1.162 9.2 10.7 10.8 10.7
76 76.26 6.886 29.95 0.8177 1.105 8.4 10.3 10.5 10.3
72 72.29 6.524 29.04 0.8173 1.047 7.7 9.9 10.1 9.9
70 70.30 6.342 28.58 0.8170 1.018 7.2 9.7 10.0 9.7
68 68.31 6.161 28.12 0.8168 0.9895 6.8 9.5 9.8 9.5
66 66.32 5.980 27.67 0.8166 0.9607 6.4 9.3 9.6 9.3
64 64.33 5.799 27.21 0.8163 0.9319 6.0 9.1 9.4 9.1
62 62.34 5.618 26.75 0.8161 0.9030 5.5 8.9 9.2 8.9
60 60.35 5.436 26.30 0.8159 0.8741 5.0 8.7 9.1 8.7
58 58.35 5.255 25.84 0.8156 0.8452 4.6 8.5 8.9 8.5
56 56.36 5.074 25.38 0.8154 0.8163 4.1 8.3 8.7 8.3
54 54.36 4.893 24.92 0.8152 0.7874 3.5 8.1 8.5 8.1
52 52.36 4.711 24.47 0.8149 0.7584 3.0 7.8 8.3 7.9
50 50.36 4.530 24.01 0.8147 0.7295 2.5 7.6 8.1 7.7
48 48.36 4.349 23.55 0.8145 0.7005 1.9 7.4 8.0 7.5
46 46.36 4.168 23.09 0.8142 0.6715 1.3 7.2 7.8 7.3
44 44.36 3.987 22.64 0.8140 0.6425 0.7 7.0 7.6 7.1
42 42.35 3.805 22.18 0.8138 0.6135 0.1 6.8 7.4 6.9
40 40.35 3.624 21.72 0.8135 0.5844 -0.5 6.6 7.2 6.7
38 38.34 3.443 21.26 0.8133 0.5554 -1.1 6.3 7.0 6.4
36 36.33 3.262 20.81 0.8131 0.5263 -1.8 6.1 6.8 6.2
34 34.32 3.080 20.35 0.8128 0.4972 -2.5 5.9 6.6 6.0
32 32.31 2.899 19.89 0.8126 0.4681 -3.2 5.7 6.4 5.8
30 30.30 2.718 19.44 0.8124 0.4390 -4.0 5.4 6.2 5.6
28 28.29 2.537 18.98 0.8121 0.4098 -4.8 5.2 6.0 5.3
24 24.26 2.174 18.06 0.8117 0.3515 -6.6 4.7 5.6 4.9
20 20.23 1.812 17.15 0.8112 0.2931 -8.6 4.3 5.2 4.4
16 16.19 1.450 16.23 0.8107 0.2346 -11.2 3.8 4.8 4.0
12 12.15 1.087 15.32 0.8103 0.1760 -14.3 3.3 4.4 3.5
8 8.11 0.724 14.40 0.8098 0.1174 - 18.7 2.8 3.9 3.0
4 4.06 0.362 13.49 0.8093 0.0587 -25.8 2.3 3.5 2.5
0 0.00 0.000 12.58 0.8089 0.0000 - 1.8 3.1 2.0
1-30 Reference data
13.5"CDRY BULB
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
/I/% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C t',l"C PC
tts1
g/g.kg-I hlkJ.kg-l vlm3.kg-l
100 100.00 9.683 38.04 0.8242 1.546 13.5 13.5 13.5 13.5
96 96.06 9.295 37.06 0.8237 1.486 12.9 13.1 13.2 13.1
92 92.11 8.908 36.08 0.8232 1.424 12.2 12.8 12.8 12.8
88 88.16 8.521 35.10 0.8227 1.363 11.6 12.4 12.5 12.4
84 84.21 8.133 34.12 0.8222 1.302 10.8 12.0 12.1 12.0
80 80.25 7.746 33.14 0.8217 1.241 10.2 11.6 11.8 11.6
76 76.28 7.359 32.17 0.8212 1.180 9.4 11.2 11.4 11.2
72 72.31 6.972 31.19 0.8207 1.118 8.6 10.8 11.1 10.8
70 70.32 6.778 30.70 0.8205 1.088 8.2 10.6 10.9 10.6
68 68.34 6.584 30.21 0.8202 1.057 7.8 10.4 10.7 10.4
66 66.35 6.390 29.72 0.8200 1.026 7.4 10.2 10.5 10.2
64 64.36 6.197 29.23 0.8197 0.9952 6.9 10.0 10.3 10.0
62 62.36 6.003 28.74 0.8195 0.9644 6.5 9.8 10.1 9.8
60 60.37 5.810 28.25 0.8192 0.9336 6.0 9.6 9.9 9.6
58 58.38 5.616 27.76 0.8190 0.9028 5.5 9.3 9.7 9.4
56 56.38 5.422 27.28 0.8187 0.8719 5.0 9.1 9.6 9.2
54 54.38 5.229 26.79 0.8185 0.8410 4.5 8.9 9.4 9.0
52 52.39 5.036 26.30 0.8182 0.8101 4.0 8.7 9.2 8.8
50 50.39 4.841 25.81 0.8180 0.7792 3.4 8.5 9.0 8.6
48 48.39 4.648 25.32 0.8177 0.7482 2.8 8.2 8.8 8.3
46 46.38 4.454 24.83 0.8175 0.7173 2.2 8.0 8.6 8.1
44 44.38 4.260 24.34 0.8172 0.6863 1.6 7.8 8.4 7.9
42 42.38 4.067 23.85 0.8170 0.6553 1.o 7.6 8.2 7.7
40 40.37 3.873 23.36 0.8167 0.6243 0.3 7.3 8.0 7.4
38 38.36 3.679 22.87 0.8165 0.5933 -0.3 7.1 7.8 7.2
36 36.36 3.486 22.38 0.8162 0.5622 -1.0 6.9 7.6 7.0
34 34.35 3.292 21.90 0.8160 0.5312 -1.7 6.6 7.4 6.8
32 32.34 3.098 21.41 0.8157 0.5000 -2.4 6.4 7.2 6.5
30 30.33 2.905 20.92 0.8155 0.4690 -3.2 6.2 7.0 6.3
28 28.31 2.71 1 20.43 0.8152 0.4378 -4.0 5.9 6.8 6.1
24 24.28 2.324 19.45 0.8147 0.3755 -5.8 5.4 6.3 5.6
20 20.25 1.936 18.47 0.8142 0.3131 -7.9 4.9 5.9 5.1
16 16.21 1.549 17.49 0.8137 0.2506 - 10.4 4.4 5.5 4.6
12 12.16 1.162 16.52 0.8132 0.1881 -13.6 3.9 5.0 4.1
I 8 8.1 1 0.7746 15.54 0.8127 0.1255 - 18.0 3.4 4.6 3.6
I 4
0
4.06
0.00
0.3873
0.000
14.56
13.58
0.8122
0.8117
0.0628
0.0000
. ....
-25.1
-
2.9
2.4
4.1
3.7
3.1
2.6
I
14.5"CDRY BULB
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
p/% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C t'JC t'JC
g/g.kg-' h/kJ.kg-' v/m3.kg-'
100 100.00 10.340 40.73 0.8280 1.650 14.5 14.5 14.5 14.5
96 96.06 9.929 39.68 0.8274 1.585 13.9 14.1 14.2 14.1
92 92.12 9.515 38.64 0.8269 1.520 13.2 13.7 13.8 13.7
88 88.17 9.102 37.59 0.8264 1.455 12.6 13.3 13.4 13.4
84 84.22 8.688 36.55 0.8258 1.390 11.9 12.9 13.1 13.0
80 80.26 8.274 35.50 0.8253 1.324 11.1 12.5 12.7 12.6
76 76.30 7.860 34.45 0.8248 1.259 10.4 12.1 12.3 12.2
72 72.33 7.447 33.41 0.8242 1.194 9.6 11.7 12.0 11.8
70 70.35 7.240 32.89 0.8239 1.161 9.2 11.5 11.8 11.5
68 68.36 7.033 32.36 0.8237 1.128 8.7 11.3 11.6 11.3
66 66.37 6.826 31.84 0.8234 1.095 8.3 11.1 11.4 11.1
64 64.38 6.619 31.32 0.8231 1.062 7.9 10.9 11.2 10.9
62 62.39 6.412 30.79 0.8229 1.030 7.4 10.6 11.0 10.7
60 60.40 6.206 30.27 0.8226 0.9966 6.9 10.4 10.8 10.5
58 58.40 5.999 29.75 0.8223 0.9937 6.4 10.2 10.6 10.3
56 56.41 5.792 29.23 0.8221 0.9308 5.9 10.0 10.4 10.0
54 54.41 5.585 28.70 0.8218 0.8978 5.4 9.8 10.2 9.8
52 52.41 5.378 28.18 0.8215 0.8649 4.9 9.5 10.0 9.6
50 50.41 5.171 27.66 0.8213 0.8329 4.3 9.3 9.8 9.4
48 48.41 4.964 27.13 0.8210 0.7989 3.8 9.1 9.6 9.2
46 46.41 4.758 26.61 0.8207 0.7658 3.2 8.8 9.4 8.9
44 44.41 4.551 26.09 0.8204 0.7328 2.5 8.6 9.2 8.7
42 42.40 4.344 25.57 0.8202 0.6997 1.9 8.4 9.0 8.5
40 40.40 4.137 25.04 0.8199 0.6666 1.2 8.1 8.8 8.2
38 38.39 3.930 24.52 0.8196 0.6335 0.5 7.9 8.6 8.0
36 36.38 3.723 24.00 0.8194 0.6003 -0.2 7.6 8.4 7.8
34 34.37 3.516 23.47 0.8191 0.5672 -0.9 7.4 8.1 7.5
32 32.36 3.310 22.95 0.8188 0.5340 -1.6 7.2 7.9 7.3
30 30.35 3.103 22.43 0.8186 0.5008 -2.4 6.9 7.7 7.0
28 28.33 2.896 21.91 0.8183 0.4675 -3.2 6.7 7.5 6.8
24 24.30 2.482 20.86 0.8178 0.4010 -5.0 6.1 7.0 6.3
20 20.27 2.068 19.81 0.8172 0.3344 -7.1 5.6 6.6 5.8
16 16.22 1.655 18.77 0.8167 0.2677 -9.7 5.1 6.1 5.3
12 12.18 1.241 17.72 0.8161 0.2009 - 12.9 4.6 5.7 4.8
8 8.12 0.827 16.68 0.8156 0.1340 - 17.3 4.0 5.2 4.2
4 4.06 0.413 15.63 0.8151 0.0670 -24.5 3.5 4.7 3.7
0 0.00 0.000 14.59 0.8145 0.0000 - 2.9 4.3 3.2
1-32 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C t'JC t',PC
g/g.kg-' hlkJ.kg-' vlm3.kg-'
100 100.00 11.04 43.52 0.8318 1.760 15.5 15.5 15.5 15.5
96 96.07 10.60 42.41 0.8312 1.691 14.9 15.1 15.1 15.1
I 92 92.13 10.16 41.29 0.8306 1.621 14.2 14.7 14.8 14.7
I 88 88.19 9.718 40.17 0.8300 1.552 13.6 14.3 14.4 14.3
84 84.24 9.276 39.06 0.8295 1.482 12.9 13.9 14.0 13.9
80 80.28 8.834 37.94 0.8289 1.413 12.1 13.5 13.7 13.5
76 76.32 8.393 36.82 0.8283 1.343 11.4 13.1 13.3 13.1
72 72.36 7.95 1 35.70 0.8277 1.273 10.6 12.6 12.9 12.7
70 70.37 7.730 35.14 0.8275 1.238 10.1 12.4 12.7 12.5
68 68.38 7.509 34.59 0.8272 1.204 9.7 12.2 12.5 12.2
66 66.40 7.288 34.03 0.8269 1.168 9.3 12.0 12.3 12.0
64 64.41 7.068 33.47 0.8266 1.134 8.8 11.7 12.1 11.8
62 62.42 6.847 32.91 0.8263 1.098 8.4 11.5 11.9 11.6
60 60.42 6.626 32.35 0.8260 1.063 7.9 11.3 11.7 11.4
58 58.43 6.405 31.79 0.8257 1.028 7.4 11.1 11.5 11.1
56 56.44 6.184 31.24 0.8254 0.9932 6.9 10.8 11.3 10.9
54 54.44 5.963 30.68 0.8252 0.9581 6.4 10.6 11.1 10.7
52 52.44 5.742 30.12 0.8249 0.9229 5.8 10.4 10.9 10.4
50 50.44 5.522 29.56 0.8246 0.8877 5.3 10.1 10.6 10.2
48 48.44 5.301 29.00 0.8243 0.8525 4.7 9.9 10.4 10.0
46 46.44 5.080 28.44 0.8240 0.8173 4.1 9.6 10.2 9.7
44 44.44 4.859 27.88 0.8237 0.7820 3.4 9.4 10.0 9.5
42 42.43 4.638 27.32 0.8234 0.7467 2.8 9.2 9.8 9.3
40 40.42 4.417 26.77 0.8231 0.7114 2.1 8.9 9.6 9.0
38 38.42 4.196 26.21 0.8228 0.6761 1.4 8.7 9.3 8.8
36 36.41 3.976 25.65 0.8226 0.6407 0.7 8.4 9.1 8.5
34 34.40 3.755 25.09 0.8223 0.6053 -0.1 8.2 8.9 8.3
32 32.39 3.534 24.53 0.8220 0.5699 -0.8 7.9 8.7 8.0
30 30.37 3.313 23.97 0.8217 0.5345 -1.6 7.6 8.4 7.8
28 28.36 3.092 23.41 0.8214 0.4990 -2.4 7.4 8.2 7.5
24 24.32 2.650 22.30 0.8208 0.4280 -4.2 6.8 7.8 7.0
20 20.28 2.209 21.18 0.8203 0.3570 -6.4 6.3 7.3 6.5
16 16.24 1.767 20.06 0.8197 0.2858 -8.9 5.8 6.8 5.9
12 12.19 1.325 18.94 0.8191 0.2145 - 12.2 5.2 6.3 5.4
8 8.13 0.883 17.83 0.8185 0.1431 - 16.6 4.6 5.8 4.8
4 4.07 0.442 16.71 0.8179 0.0716 -23.8 4.0 5.3 4.3
0 0.00 0.000 15.59 0.8174 0.0000 - 3.5 4.8 3.7
Psychromet r ic tables 1-33
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
111% 41% Moisture Specific Specific pJkPa t,PC temperature Screen Sling
content enthalpy volume t*l"C t'JC t'JC
g/g.kg-I hlkJ.kg-' v/rn3.kg-l
100 100.00 11.79- 46.43 0.8356 1.876 16.5 16.5 16.5 16.5
96 96.07 11.31 45.24 0.8350 1.802 15.9 16.1 16.1 16.1
92 92.14 10.84 44.04 0.8344 1.728 15.2 15.7 15.8 15.7
88 88.20 10.37 42.85 0.8338 1.655 14.5 15.3 15.4 15.3
84 84.25 9.900 41.66 0.8332 1.581 13.8 14.9 15.0 14.9
80 80.30 9.428 40.46 0.8326 1.506 13.1 14.4 14.6 14.4
76 76.34 8.957 39.27 0.83I9 1.432 12.3 14.0 14.2 14.0
72 72.38 8.486 38.08 0.8313 1.358 11.5 13.5 13.8 13.6
70 70.40 8.250 37.48 0.8310 1.321 11.1 13.3 13.6 13.4
68 68.41 8.014 36.88 0.8307 1.283 10.7 13.1 13.4 13.1
66 66.42 7.778 36.29 0.8304 1.246 10.2 12.9 13.2 12.9
64 64.43 7.543 35.69 0.8301 1.209 9.8 12.6 13.0 12.7
62 62.44 7.307 35.09 0.8298 1.171 9.3 12.4 12.8 12.5
60 60.45 7.071 34.50 0.8295 1.134 8.8 12.2 12.6 12.2
58 58.46 6.836 33.90 0.8292 1.097 8.3 11.9 12.3 12.0
56 56.47 6.600 33.30 0.8289 1.059 7.8 11.7 12.1 11.8
54 54.47 6.364 32.71 0.8285 1.022 7.3 11.4 11.9 11.5
52 52.47 6.128 32.11 0.8282 0.9844 6.8 11.2 11.7 11.3
50 50.47 5.893 31.51 0.8279 0.9469 6.2 11.0 11.5 11.0
48 48.47 5.657 30.92 0.8276 0.9093 5.6 10.7 11.3 10.8
46 46.47 5.421 30.32 0.8273 0.8718 5.0 10.5 11.0 10.6
44 44.47 5.186 29.72 0.8270 0.8342 4.4 10.2 10.8 10.4
42 42.46 4.950 29.13 0.8267 0.7965 3.7 10.0 10.6 10.1
40 40.45 4.714 28.53 0.8264 0.7589 3.0 9.7 10.4 9.8
38 38.45 4.478 27.93 0.8261 0.7212 2.3 9.4 10.1 9.5
36 36.44 4.243 27.34 0.8258 0.6835 1.6 9.2 9.9 9.3
34 34.42 4.007 26.74 0.8255 0.6458 0.8 8.9 9.7 9.0
32 32.41 3.771 26.14 0.8251 0.6080 -0.1 8.6 9.4 8.8
30 30.40 3.536 25.55 0.8248 0.5702 -0.8 8.4 9.2 8.5
28 28.38 3.300 24.95 0.8245 0.5324 -1.7 8.1 9.0 8.2
24 24.35 2.828 23.76 0.8239 0.4567 -3.5 7.5 8.5 7.7
20 20.30 2.357 22.56 0.8233 0.3809 -5.6 7.0 8.0 7.2
16 16.25 1.886 21.37 0.8227 0.3049 -8.2 6.4 7.5 6.6
12 12.20 1.414 20.18 0.8221 0.2289 -11.4 5.8 7.0 6.0
8 8.14 0.943 18.98 0.8214 0.1527 -15.9 5.2 6.5 5.4
4 4.07 0.471 17.79 0.8208 0.0764 -23.1 4.6 5.9 4.8
0 0.00 0.000 16.60 0.8202 0.0000 - 4.0 5.4 4.2
1-34 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
pl% 41% Moisture Specific Specific p&Pa t,PC temperature Screen Sling
content enthalpy volume t*l"C t'JC t',PC
g/g.kg-l hlkJ.kg-' v/m3.kg-'
100 100.00 13.41 52.59 ' 0.8436 2.128 18.5 18.5 18.5 18.5
96 96.08 12.87 5 1.24 0.8429 2.045 17.9 18.1 18.1 18.1
92 92.16 12.33 49.88 0.8421 1.962 17.2 17.6 17.7 17.7
88 88.22 11.80 48.52 0.8414 1.878 16.5 17.2 17.3 17.2
84 84.29 11.26 47.16 0.8407 1.794 15.8 16.8 16.9 16.8
80 80.34 10.73 45.80 0.8400 1.710 15.1 16.3 16.5 16.3
76 76.39 10.19 44.44 0.8393 1.626 14.3 15.8 16.1 15.9
72 72.43 9.653 43.08 0.8386 1.542 13.5 15.4 15.6 15.4
70 70.45 9.384 42.40 0.8383 1.500 13.0 15.1 15.4 15.2
68 68.47 9.116 41.72 0.8379 1.457 12.6 14.9 15.2 14.9
66 66.48 8.848 41.04 0.8376 1.415 12.1 14.6 15.0 14.7
64 64.49 8.580 40.36 0.8372 1.373 11.7 14.4 14.7 14.5
62 62.50 8.312 39.68 0.8368 1.330 11.2 14.2 14.5 14.2
60 60.5 1 8.044 39.00 0.8365 1.288 10.7 13.9 14.3 14.0
58 58.52 7.776 38.32 0.8361 1.246 10.2 13.7 14.1 13.7
56 56.53 7.508 37.64 0.8358 1.203 9.7 13.4 13.8 13.5
54 54.53 7.240 36.96 0.8354 1.161 9.2 13.1 13.6 13.2
52 52.54 6.971 36.28 0.8351 1.118 8.6 12.9 13.4 13.0
50 50.54 6.703 35.60 0.8347 1.076 8.0 12.6 13.1 12.7
48 48.54 6.435 34.92 0.8344 1.033 7.5 12.3 12.9 12.4
46 46.53 6.167 34.24 0.8340 0.9904 6.8 12.1 12.7 12.2
44 44.53 5.899 33.56 0.8337 0.9478 6.2 11.8 12.4 11.9
42 42.52 5.631 32.88 0.8333 0.9051 5.5 11.5 12.2 11.6
40 40.52 5.363 32.20 0.8330 0.8624 4.8 11.3 11.9 11.4
38 38.51 5.094 31.52 0.8326 0.8196 4.1 11.0 11.7 11.1
36 36.50 4.826 30.84 0.8323 0.7278 3.4 10.7 11.4 10.8
34 34.48 4.558 30.16 0.8319 0.7340 2.6 10.4 11.2 10.5
32 32.47 4.290 29.49 0.8315 0.6911 1.7 10.1 10.9 10.2
30 30.45 4.022 28.81 0.8312 0.6482 0.8 9.8 10.7 10.0
28 28.43 3.754 28.13 0.8308 0.6052 -0.1 9.5 10.4 9.7
24 24.39 3.218 26.77 0.8301 0.5192 -2.0 8.9 9.9 9.1
20 20.34 2.681 25.41 0.8294 0.4330 -4.1 8.3 9.3 8.5
16 16.29 2.145 24.05 0.8287 0.3477 -6.7 7.7 8.8 7.9
12 12.23 1.609 22.69 0.8280 0.2603 - 10.0 7.1 8.2 7.3
8 8.16 1.072 21.33 0.8273 0.1747 -14.5 6.4 7.7 6.6
4 4.08 0.536 19.97 0.8266 0.0869 -21.8 5.7 7.1 6.0
0 0.00 0.000 18.61 0.8259 0.0000 - 5.0 6.5 5.3
Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,l”C temperature Screen Sling
content enthalpy volume t*/”C t’JC t f SPC
I
gig.kg-’ hlkJ.kg-l vlm3.kg-l
100 100.00 13.84 54.21 0.8456 2.196 19.0 19.0 19.0 19.0
96 96.08 13.29 52.81 0.8449 2.1 10 18.4 18.6 18.6 18.6
92 92.16 12.74 51.41 0.8441 2.024 17.7 18.1 18.2 18.1
88 88.23 12.18 50.00 0.8434 1.938 17.0 17.7 17.8 17.7
84 84.30 11.63 48.60 0.8427 1.851 16.3 17.2 17.4 17.3
80 80.35 11.07 47.19 0.8419 1.765 15.5 16.8 17.0 16.8
76 76.40 10.52 45.79 0.8412 1.678 14.8 16.3 16.5 16.3
72 72.44 9.966 44.39 0.8405 1.591 13.9 15.8 16.1 15.9
70 70.46 9.689 43.68 0.8401 1.547 13.5 15.6 15.9 15.6
68 68.48 9.412 42.98 0.8397 1.504 13.1 15.3 15.6 15.4
66 66.50 9.136 42.28 0.8394 1.460 12.6 15.1 15.4 15.1
64 64.51 8.859 41.58 0.8390 1.417 12.2 14.8 15.2 14.9
62 62.52 8.582 40.88 0.8386 1.373 11.7 14.6 15.0 14.7
60 60.53 8.305 40.17 0.8383 1.329 11.2 14.3 14.7 14.4
58 58.54 8.028 39.47 0.8379 1.286 10.7 14.1 14.5 14.1
56
~~ 56.55
~ ~ ~~ 7.751 38.77 0.8375
. ~. ~ 1.242 10.2 13.8 14.3 13.9
54 54.55 7.475 38.07 0.8372 1.198 9.6 13.6 14.0 13.6
52 52.55 7.198 37.37 0.8368 1.154 9.1 13.3 13.8 13.4
50 50.55 6.921 36.66 0.8365 1.110 8.5 13.0 13.5 13.1
48 48.55 6.644 35.96 0.8361 1.066 7.9 12.8 13.3 12.8
46 46.55 6.367 35.26 0.8357 1.022 7.3 12.5 13.1 12.6
44 44.55 6.090 34.56 0.8354 0.9782 6.7 12.2 12.8 12.3
42 42.54 5.814 33.86 0.8350 0.9342 6.0 11.9 12.6 12.0
40 40.53 5.537 33.15 0.8346 0.8902 5.3 11.6 12.3 11.8
38 38.52 5.260 32.45 0.8343 0.8460 4.6 11.4 12.1 11.5
36 36.51 4.983 31.75 0.8339 0.8018 3.8 11.1 11.8 11.2
34 34.50 4.706 31.05 0.8335 0.7576 3.0 10.8 11.6 10.9
32 32.48 4.429 30.35 0.8332 0.7134 2.2 10.5 11.3 10.6
30 30.47 4.153 29.64 0.8328 0.6691 1.3 10.2 11.0 10.3
28 28.45 3.876 28.94 0.8324 0.6248 0.3 9.9 10.8 10.0
24 24.41 3.322 27.54 0.8317 0.5360 -1.6 9.3 10.2 9.4
20
~~ 20.36
~~ .. 2.768 26.13
~. ~. 0.8310
. ..~. 0.4470 -3.7 8.7 9.7 8.8
16 16.30 2.215 24.73 0.8302 0.3580 -6.3 8.0 9.1 8.2
12 12.24 1.66 1 23.33 0.8295 0.2687 -9.6 7.4 8.6 7.6
8 8.16 1.107 21.92 0.8288 0.1792 - 14.1 6.7 8.0 6.9
4 4.09 0.554 20.52 0.8280 0.0897 -21.5 6.0 7.4 6.2
0 0.00 0.000 19.11 0.8273 0.0000 - 5.3 6.8 5.6
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,PC temperature Screen Sling
content enthalpy volume t*PC t'JC t',l"C
g/g.kg-' hlkJ.kg-' vlm3.kg-l
100 100.00 14.75 57.55 0.8497 2.337 20.0 20.0 20.0 20.0
96 96.09 14.16 56.05 0.8489 2.246 19.4 19.6 19.6 19.6
92 92.17 13.57 54.56 0.8481 2.154 18.7 19.1 19.2 19.1
88 88.25 12.98 53.06 0.8473 2.062 18.0 18.7 18.8 18.7
84 84.31 12.39 51.56 0.8466 1.970 17.3 18.2 18.3 18.2
80 80.37 11.80 50.06 0.8458 1.878 16.5 17.7 17.9 17.7
76 76.43 11.21 48.57 0.8450 1.786 15.7 17.2 17.5 17.3
72 72.47 10.62 47.07 0.8442 1.694 14.9 16.7 17.0 16.8
70 70.49 10.33 46.32 0.8438 1.647 14.5 16.5 16.8 16.5
68 68.51 10.03 45.57 0.8434 1.601 14.0 16.2 16.5 16.3
66 66.53 9.736 44.82 0.8431 1.555 13.6 16.0 16.3 16.0
64 64.54 9.441 44.08 0.8427 1.508 13.1 15.7 16.1 15.8
62 62.55 9.146 43.33 0.8423 1.462 12.6 15.5 15.8 15.5
60 60.56 8.851 42.58 0.8419 1.415 12.1 15.2 15.6 15.3
58 58.57 8.556 41.83 0.8415 1.369 11.6 14.9 15.4 15.0
56 56.58 8.260 41.08 0.841 1 1.322 11.1 14.7 15.1 14.7
54 54.59 7.966 40.33 0.8407 1.276 10.6 14.4 14.9 14.5
52 52.59 7.670 39.58 0.8403 1.229 10.0 14.1 14.6 14.2
50 50.59 7.376 38.84 0.8399 1.182 9.4 13.9 14.4 13.9
48 48.59 7.080 38.09 0.8395 1.136 8.8 13.6 14.1 13.7
46 46.59 6.785 37.34 0.8391 1.089 8.2 13.3 13.9 13.4
44 44.58 6.490 36.59 0.8388 1.042 7.6 13.0 13.6 13.1
42 42.58 6.195 35.84 0.8384 0.9945 6.9 12.7 13.4 12.8
40 40.57 5.900 35.09 0.8380 0.9480 6.2 12.4 13.1 12.5
38
~~ 38.56
~~~~ 5.605 34.34 0.8376 0.901 1 5.5 12.1 12.8 12.2
36 36.55 5.310 33.60 0.8372 0.8541 4.7 11.8 12.6 12.0
34 34.53 5.015 32.85 0.8368 0.8070 3.9 11.5 12.3 11.7
32 32.52 4.720 32.10 0.8364 0.7600 3.0 11.2 12.0 11.4
30 30.50 4.425 31.35 0.8360 0.7127 2.1 10.9 11.8 11.1
28 28.48 4.130 30.60 0.8356 0.6656 1.2 10.6 11.5 10.7
24 24.43 3.540 29.10 0.8348 0.5710 -0.8 10.0 10.9 10.1
20 20.38 2.950 27.61 0.8341 0.4763 -3.0 9.3 10.4 9.5
16 16.32 2.360 26.11 0.8333 0.3814 -5.6 8.6 9.8 8.8
12 12.25 1.770 24.61 0.8325 0.2863 -8.9 8.0 9.2 8.2
8 8.17 1.180 23.11 0.8317 0.1910 -13.4 7.3 8.6 7.5
4 4.09 0.590 2 1.62 0.8309 0.0956 -20.8 6.5 8.0 6.8
0 0.00 0.000 20.11 0.8301 0.0000 - 5.8 7.3
20.5"CDRY BULB
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
'U/% 41% Moisture Specific Specific pslkPa t,PC temperature Screen Sling
content enthalpy volume t*PC t'JC t'JC
P1e.ke-l hlkT.ke-l vlm3.ke-'
100 100.00 15.22 59.27 0.85 18 2.410 20.5 20.5 20.5 20.5
96 96.09 14.62 57.73 0.8510 2.316 19.9 20.1 20.1 20.1
92 92.18 14.01 56.18 0.8502 2.222 19.2 19.6 19.7 19.6
88 88.25 13.49 54.63 0.8493 2.127 18.5 19.1 19.2 19.2
84 84.32 12.79 53.09 0.8485 2.032 17.8 18.7 18.8 18.7
80 80.39 12.18 51.54 0.8477 1.938 17.0 18.2 18.4 18.2
76 76.44 11.57 50.00 0.8469 1.842 16.2 17.7 17.9 17.7
72 72.49 10.96 48.45 0.8461 1.747 15.4 17.2 17.5 17.2
70 70.5 1 10.66 47.68 0.8457 1.699 15.0 17.0 17.2 17.0
68 68.53 10.35 46.90 0.8453 1.652 14.5 16.7 17.0 16.7
66 66.54 10.05 46.13 0.8449 1.604 14.1 16.4 16.8 16.5
64 64.56 9.744 45.36 0.8445 1.556 13.6 16.2 16.5 16.2
62 62.57 9.440 44.59 0.8441 1.508 13.1 15.9 16.3 16.0
60 60.58 9.135 43.81 0.8437 1.460 12.6 15.6 16.0 15.7
58 58.59 8.831 43.04 0.8433 1.412 12.1 15.4 15.8 15.4
56 56.60 8.526 42.27 0.8429 1.364 11.6 15.1 15.5 15.2
54 54.60 8.222 4 1.49 0.8425 1.316 11.0 14.8 15.3 14.9
52 52.61 7.917 40.72 0.8421 1.268 10.5 14.6 15.0 14.6
50 50.61 7.613 39.95 0.8417 1.220 9.9 14.3 14.8 14.4
48 48.61 7.308 39.18 0.8413 1.172 9.3 14.0 14.5 14.1
46 46.61 7.004 38.40 0.8409 1.123 8.7 13.7 14.3 13.8
44 44.60 6.699 37.63 0.8405 1.075 8.0 13.4 14.0 13.5
42 42.59 6.395 36.86 0.8401 1.027 7.4 13.1 13.8 13.2
40 40.59 6.090 36.08 0.8397 0.9782 6.7 12.8 13.5 12.9
38 38.58 5.786 35.31 0.8393 0.9298 5.9 12.5 13.2 12.6
36 36.56 5.481 34.54 0.8388 0.8813 5.2 12.2 13.0 12.3
34 34.55 5.177 33.76 0.8384 0.8327 4.3 11.9 12.7 12.0
32 32.53 4.872 32.99 0.8380 0.7841 3.5 11.6 12.4 11.7
30 30.51 4.568 32.22 0.8376 0.7355 2.6 11.3 12.1 11.4
28 28.49 4.263 31.44 0.8372 0.6868 1.6 11.0 11.8 11.1
24 24.45 3.654 29.90 0.8364 0.5892 -0.4 10.3 11.3 10.5
20 20.39 3.045 28.35 0.8356 0.4915 -2.6 9.6 10.7 9.8
16 16.33 2.436 26.81 0.8348 0.3936 -5.2 9.0 10.1 9.2
12 12.26 1.827 25.26 0.8340 0.2955 -8.5 8.3 9.5 8.5
8 8.18 1.218 23.71 0.8332 0.1972 -13.1 7.5 8.9 7.8
4 4.09 0.609 22.17 0.8324 0.0986 -20.5 6.8 8.2 7.1
0 0.00 0.000 20.62 0.8316 0.0000 - 6.1 7.6 6.3
1-38 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific p,lkPa t,l”C temperature Screen Sling
content enthalpy volume t*l”C t’JC ttslPC
g/g.kg-l hlkJ.kg-’ v/m3.kg-l
100 100.00 17.26 66.52 0.8603 2.724 22.5 22.5 22.5 22.5
96 96.10 16.57 64.77 0.8594 2.618 21.8 22.0 22.1 22.0
92 92.20 15.88 63.01 0.8585 2.512 21.2 21.6 21.6 21.6
88 88.29 15.19 61.26 0.8575 2.405 20.5 21.1 21.2 21.1
84 84.37 14.50 59.50 0.8566 2.298 19.7 20.6 20.7 20.6
80 80.44 13.81 57.75 0.8557 2.191 19.0 20.1 20.3 20.1
76 76.50 13.12 55.99 0.8548 2.084 18.2 19.6 19.8 19.6
72 72.55 12.43 54.23 0.8539 1.976 17.3 19.0 19.3 19.1
70 70.58 12.08 53.36 0.8534 1.923 16.9 18.8 19.0 18.8
68 68.60 11.74 52.48 0.8529 1.869 16.4 18.5 18.8 18.6
66 66.62 11.39 5 1.60 0.8525 1.815 16.0 18.2 18.5 18.3
64 64.63 11.05 50.72 0.8520 1.761 15.5 18.0 18.3 18.0
62 62.65 10.70 49.85 0.8516 1.707 15.0 17.7 18.0 17.7
60 60.66 10.36 48.97 0.8511 1.653 14.5 17.4 17.8 17.5
58 58.67 10.01 48.09 0.8506 1.598 14.0 17.1 17.5 17.2
56 56.68 9.668 47.21 0.8502 1.544 13.5 16.8 17.3 16.9
54 54.68 9.322 46.33 0.8497 1.490 12.9 16.5 17.0 16.6
52 52.69 8.977 45.46 0.8492 1.435 12.4 16.2 16.7 16.3
50 50.69 8.632 44.58 0.8488 1.381 11.8 15.9 16.5 16.0
48 48.69 8.287 43.70 0.8483 1.326 11.2 15.6 16.2 15.7
46 46.69 7.941 42.82 0.8479 1.272 10.5 15.3 15.9 15.4
44 44.68 7.596 41.95 0.8474 1.217 9.9 15.0 15.6 15.1
42 42.67 7.251 41.07 0.8469 1.163 9.2 14.7 15.3 14.8
40 40.66 6.906 40.19 0.8465 1.108 8.5 14.4 15.1 14.5
38 38.65 6.560 39.31 0.8460 1.053 7.7 14.1 14.8 14.2
36 36.64 6.215 38.43 0.8456 0.9981 7.0 13.7 14.5 13.8
34 34.62 5.870 37.56 0.845 1 0.9432 6.1 13.4 14.2 13.5
32 32.60 5.524 36.68 0.8446 0.8882 5.3 13.1 13.9 13.2
30 30.58 5.179 35.80 0.8442 0.8331 4.3 12.7 13.6 12.9
28 28.56 4.834 34.92 0.8437 0.7780 3.4 12.4 13.3 12.5
24 24.51 4.143 33.17 0.8428 0.6676 1.2 11.7 12.7 11.8
20 20.44 3.453 31.41 0.8419 0.5570 -1.1 11.0 12.0 11.1
16 16.37 2.762 29.66 0.8409 0.4461 -3.8 10.2 11.4 10.4
12 12.29 2.072 27.90 0.8400 0.3349 -7.1 9.5 10.7 9.7
8 8.20 1.381 26.15 0.8391 0.2235 -11.7 8.7 10.1 8.9
4 4.11 0.690 24.39 0.8382 0.1119 -19.2 7.9 9.4 8.1
0 0.00 0.000 22.64 0.8372 0.0000 - 7.0 8.7 7.3
1-40 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
pl% 41% Moisture Specific Specific pJkPa t,PC temperature Screen Sling
content enthalpy volume t*l"C t'JC t'JC
g/g.kg-'
~
hlkJ.kg-l
~
vlm3.kg-'
100 100.00 22.78 85.29 0.8809 3.564 27.0 27.0 27.0 27.0
96 96.14 21.87 82.94 0.8797 3.426 26.3 26.5 26.5 26.5
92 92.26 20.96 80.62 0.8784 3.288 25.6 26.0 26.0 26.0
88 88.38 20.05 78.30 0.8772 3.150 24.9 25.4 25.5 25.5
84 84.48 19.14 75.97 0.8760 3.01 1 24.2 24.9 25.0 24.9
80 80.57 18.23 73.65 0.8747 2.872 23.4 24.3 24.5 24.4
76 76.66 17.32 71.32 0.8735 2.732 22.5 23.8 24.0 23.8
72 72.72 16.40 69.00 0.8723 2.592 21.7 23.2 23.4 23.2
70 70.76 15.95 67.84 0.8717 2.522 21.2 22.9 23.1 22.9
68 68.78 15.49 66.67 0.8710 2.452 20.8 22.6 22.9 22.6
66 66.81 15.04 65.51 0.8704 2.381 20.3 22.3 22.6 22.3
64 64.83 14.58 64.35 0.8698 2.31 1 19.8 22.0 22.3 22.0
62 62.85 14.13 63.19 0.8692 2.240 19.3 21.7 22.0 21.7
60 60.87 13.67 62.03 0.8686 2.169 18.8 21.3 21.7 21.4
58 58.88 13.21 60.86
.. . 0.8680 2.099 18.3 21.0 21.4 21.1
56 56.89 12.76 59.70 6.8673 2.028 17.7 20.7 21.1 20.8
54 54.90 12.30 58.54 0.8667 1.957 17.2 20.4 20.8 20.4
52 52.90 11.85 57.38 0.8661 1.886 16.6 20.0 20.5 20.1
50 50.91 11.39 56.22 0.8655 1.814 16.0 19.7 20.2 19.8
48 48.90 10.94 55.05 0.8649 1.743 15.3 19.3 19.9 19.4
46 46.90 10.48 53.89 0.8642 1.672 14.7 19.0 19.6 19.1
44 44.89 10.02 52.73 0.8636 1.600 14.0 18.6 19.2 18.7
42 42.88 9.569 51.57 0.8630 1.528 13.3 18.3 18.9 18.4
40 40.87 9.113 50.41 0.8624 1.459 12.6 17.9 18.6 18.0
38 38.86 8.658 49.24 0.8618 1.385 11.8 17.5 18.2 17.6
36 36.84 8.202 48.08 0.8612 1.313 11.0 17.2 17.9 17.3
34 34.82 7.746 46.92 0.8605 1.241 10.2 16.8 17.6 16.9
32 32.79 7.291 45.76 0.8599 1.169 9.3 16.4 17.2 16.5
30 30.77 6.835 44.60 0.8593 1.097 8.3 16.0 16.9 16.1
28 28.74 6.379 43.43 0.8587 1.024 7.3 15.6 16.5 15.7
24 24.67 5.468 41.11 0.8574 0.8792 5.1 14.8 15.8 14.9
20 20.59 4.557 38.78 0.8562 0.7337 2.6 13.9 15.0 14.1
16 16.49 3.645 36.46 0.8550 0.5878 -0.5 13.0 14.2 13.2
12 12.39 2.734 34.14 0.8537 0.4415 -3.9 12.1 13.4 12.3
8 8.27 1.823 31.81
. ~ . 0.8525 0.2948 -8.6 11.2 12.6 11.4
4 4.14 0.91 1 29.49 0.8513 o.im -16.2 10.2 11.8 10.4
0 0.00 0.000 27.16 0.8500 0.0000 - 9.2 10.9 9 .-
~
5
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
{I/% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C f'sE/oC t'J-C
g1g.W ' hlkJ.kg-' vlm3.kg-l
100 100.00 26.50 97.39 0.8933 4.122 29.5 29.5 29.5 29.5
96 96.16 25.44 94.68 0.8919 3.963 28.8 29.0 29.0 29.0
92 92.30 24.38 91.97 0.8905 3.805 28.1 28.4 28.5 28.4
88 88.44 23.32 89.27 0.8890 3.645 27.4 27.9 28.0 27.9
84 84.56 22.26 86.56 0.8876 3.485 26.6 27.3 27.4 27.3
80 80.67 21.20 83.85 0.8861 3.325 25.8 26.7 26.9 26.7
76 76.76 20.14 81.14 0.8847 3.164 25.0 26.1 26.3 26.1
72 72.84 19.08 78.43 0.8832 3.002 24.1 25.5 25.7 25.5
70 70.88 18.55 77.08 0.8825 2.922 23.7 25.2 25.4 25.2
68 68.91 18.02 75.72 0.8818 2.840 23.2 24.9 25.1 24.9
66 66.94 17.49 74.37 0.8810 2.759 22.7 24.5 24.8 24.6
64 64.97 16.96 73.01 0.8803 2.678 22.2 24.2 24.5 24.3
62 62.99 16.43 71.66 0.8796 2.596 21.7 23.9 24.2 23.9
60 61.01 15.90 70.31 0.8789 2.515 21.2 23.5 23.9 23.6
58 59.02 15.37 68.95 0.8782 2.433 20.7 23.2 23.6 23.3
56 57.04 14.84 67.60 0.8774 2.351 20.1 22.9 23.3 22.9
54 55.04 14.31 66.24 0.8767 2.269 19.5 22.5 22.9 22.6
52 53.05 13.78 64.89 0.8760 2.187 18.9 22.1 22.6 22.2
50 51.05 13.25 63.54 0.8753 2.104 18.3 21.8 22.3 21.9
48 49.05 12.72 62.18 0.8745 2.022 17.7 21.4 21.9 21.5
46 47.05 12.19 60.83 0.8738 1.939 17.0 21.0 21.6 21.1
44 45.04 11.66 59.47 0.8731 1.856 16.3 20.7 21.3 20.7
42 43.03 11.13 58.12 0.8724 1.774 15.6 20.3 20.9 20.4
40 41.01 10.60 56.76 0.8716 1.691 14.9 19.9 20.5 20.0
38 39.00 10.07 55.41 0.8709 1.607 14.1 19.5 20.2 19.6
36 36.98 9.541 54.06 0.8702 1.524 13.3 19.1 19.8 19.2
34 34.95 9.011 52.70 0.8695 1.441 12.4 18.6 19.4 18.8
32 32.92 8.481 51.35 0.8687 1.357 11.5 18.2 19.1 18.4
30 30.89 7.951 49.99 0.8680 1.273 10.6 17.8 18.7 17.9
28 28.86 7.421 48.64 0.8673 1.189 9.5 17.4 18.3 17.5
24 24.78 6.361 45.93 0.8658 1.021 7.3 16.5 17.5 16.6
20 20.68 5.301 43.22 0.8644 0.8524 4.7 15.5 16.6 15.7
16 16.57 4.240 40.51 0.8629 0.6831 1.6 14.6 15.8 14.8
12 12.45 3.180 37.80 0.8615 0.5132 -2.1 13.6 14.9 13.8
8 8.32 2.120 35.10 0.8600 0.3427 -6.8 12.5 14.0 12.8
4 4.16 1.060 32.39 0.8586 0.1717 - 14.6 11.4 13.1 11.7
0 0.00 0.000 29.68 0.8571 0.0000 - 10.3 12.1 10.6
Psychrometric tables 1-47
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
jd% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthaluv volume t*/"C t' 1°C t'. PC
1
g/g.kg-I hlkJ.k g ' vlm3.kg-'
100 100.00 32.65 116.8 0.9122 5.029 33.0 33.0 33.0 33.0
96 96.19 31.34 113.5 0.9104 4.838 32.3 32.4 32.5 32.4
92 92.37 30.04 110.1 0.9086 4.646 31.6 31.9 31.9 31.9
88 88.53 28.73 106.8 0.9068 4.453 30.8 31.3 31.4 31.3
84 84.68 27.43 103.4 0.9050 4.259 30.1 30.7 30.8 30.7
80 80.81 26.12 100.1 0.9032 4.064 29.3 30.1 30.2 30.1
76 76.93 24.81 96.76 0.9014 3.869 28.4 29.4 29.6 29.4
72 73.03 23.51 93.41 0.8996 3.673 27.5 28.8 29.0 28.8
70 71.08 22.85 91.74 0.8987 3.575 27.1 28.4 28.7 28.5
68 69.12 22.20 90.06 0.8978 3.476 26.6 28.1 28.3 28.1
66 67.15 21.55 88.39 0.8969 3.377 26.1 27.7 28.0 27.8
64 65.18 20.90 86.72 0.8960 3.278 25.6 27.4 27.7 27.4
62 63.21 20.24 85.05 0.8951 3.179 25.1 27.0 27.3 27.1
60 61.24 19.59 83.38 0.8942 3.080 24.5 26.7 27.0 26.7
58
.. 59.26 18.94 81.70 0.8933 2.980 24.0 26.3 26.7 26.3
56 57.27 18.28 80.03 0.8924 2.880 23.4 25.9 26.3 26.0
54 55.28 17.63 78.36 0.8915 2.780 22.8 25.5 26.0 25.6
52 53.29 16.98 76.69 0.8906 2.680 22.2 25.1 25.6 25.2
50 5 1.29 16.32 75.01 0.8896 2.580 21.6 24.7 25.2 24.8
48 49.29 15.67 73.34 0.8887 2.479 21.0 24.3 24.9 24.4
46 47.29 15.02 71.67 0.8878 2.378 20.3 23.9 24.5 24.0
44 45.28 14.37 70.00 0.8869 2.277 19.6 23.5 24.1 23.6
42 43.26 13.71 68.32 0.8860 2.176 18.9 23.1 23.7 23.2
40 41.25 13.06 66.65 0.8851 2.074 18.1 22.6 23.3 22.8
38 39.23 12.41 64.98
.... . 0.8842
~ 1.973 17.3 22.2 22.9 22.3
36 37.20 11.75 63.31 0.8833 1.871 16.5 21.8 22.5 21.9
34 35.17 11.10 61.63 0.8824 1.769 15.6 21.3 22.1 21.4
32 33.13 10.45 59.96 0.8815 1.666 14.7 20.8 21.6 21.0
30 31.10 9.795 58.29 0.8806 1.564 13.7 20.3 21.2 20.5
28 29.05 9.142 56.62 0.8797 1.461 12.6 19.9 20.8 20.0
24 24.95 7.836 53.27 0.8779 1.255 10.3 18.9 19.9 19.0
20 20.84 6.530 49.93 0.8761 1.048 7.7 17.8 18.9 18.0
16 16.71 5.224 46.58 0.8743 0.8402 4.5 16.7 18.0 16.9
12 12.56 3.918 43.24 0.8725 0.6315 0.5 15.6 17.0 15.8
8 8.39 2.612 39.89 0.8707 0.4219 -4.4 14.4 15.9 14.6
4 4.20 1.306 36.55 0.8689 0.2114 -12.3 i3.i 14.8 13.4
0 0.00 0.000 32.20 0.8671 0.0000 - 11.8 13.7 12.1
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
pl% 41% Moisture Specific Specific pJkPa t,/"C temperature Screen Sling
content enthahv volume t*/"C t' sc 1°C t' 91. PC
~
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
pl% 41% Moisture Specific Specific pslkPa t,l"C temperature Screen Sling
content enthalpy volume t*PC t'JC t', PC
d e .ke-I hlkl.kp-I vlm3.kp-l
100 100.00 37.82 132.8 0.9268 5.779 35.5 35.5 35.5 35.5
96 96.22 36.31 128.9 0.9247 5.561 34.8 34.9 34.9 34.9
92 92.43 34.79 125.0 0.9226 5.342 34.1 34.3 34.4 34.3
88 88.61 33.28 121.1 0.9205 5.121 33.3 33.7 33.8 33.7
84 84.78 31.77 117.2 0.9184 4.900 32.5 33.1 33.2 33.1
80 80.94 30.26 113.3 0.9163 4.678 31.7 32.4 32.6 32.5
76 77.07 28.74 109.5 0.9142 4.454 30.9 31.8 32.0 31.8
72 73.19 27.23 105.6 0.9121 4.230 29.9 31.1 31.3 31.1
70 71.24 26.47 103.6 0.91 11 4.117 29.5 30.7 31.0 30.8
68 69.28 25.72 101.7 0.9100 4.004 29.0 30.4 30.6 30.4
..
66 67.33 24.96 99.76 0.9090 3.891 28.5 30.0 30.3 30.1
64 65.36 24.20 97.82 0.9079 3.778 28.0 29.6 29.9 29.7
62 63.40 23.45 95.88 0.9068 3.664 27.5 29.3 29.6 29.3
60 61.42 22.69 93.94 0.9058 3.560 26.9 28.9 29.2 28.9
58 59.45 21.93 92.00 0.9047 3.436 26.4 28.5 28.9 28.6
56 57.47 21.18 90.06 0.9037 3.321 25.8 28.1 28.5 28.2
54 55.48 20.42 88.12 0.9026 3.206 25.2 27.7 28.1 27.8
52 53.49 19.67 86.18 0.9016 3.091 24.6 27.3 27.7 27.4
50 5 1.49 18.91 84.23 0.9005 2.976 24.0 26.9 27.3 26.9
48 49.49 18.15 82.29 0.8995 2.860 26.9 26.5
46 47.49 17.40 80.35 0.8984 2.744 26.5 26.1
44 45.48 16.64 78.41 0.8974 2.628 26.1 25.7
42 43.46 15.88 76.47 0.8963 2.512 25.7 25.2
40 4 1.44 15.13 74.53 0.8953 2.395 25.3 24.8
38 39.42 14.37 72.59 0.8942 2.278 19.6 24.2 24.9 24.3
36 37.39 13.62 70.65 0.8932 2.161 18.7 23.7 24.4 23.8
34 35.35 12.86 68.71 0.8921 2.043 17.8 23.2 24.0 23.3
32 33.31 12.10 66.77 0.8910 1.925 16.9 22.7 23.5 22.8
30 31.27 11.35 64.83 0.8900 1.807 15.9 22.2 23.0 22.3
28 29.22 10.59 62.89 0.8889 1.689 14.9 21.7 22.6 21.8
24 25.10 9.076 59.01 0.8868 1.451 12.5 20.6 21.6 20.7
20 20.97 7.564 55.13 0.8847 1.212 9.8 19.4 20.6 19.6
16 16.82 6.051 5 1.24 0.8826 0.9719 6.6 18.3 19.5 18.5
12 12.64 4.538 47.36 0.8805 0.7307 2.5 17.0 18.4 17.2
8 8.45 3.026 43.48 0.8784 0.4883 -2.7 15.7 17.2 15.9
4 4.24 1.513 39.60 0.8763 0.2448 - 10.7 14.3 16.0 14.6
0 0.00 0.000 35.72 0.8742 0.0000 - 12.8 14.8 13.1
Psychrometric tables 1-53
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C t'JC PC
ltSI
g/g.kg- hlkJ.kg-l vlm3.kg-'
100 100.00 38.94 136.2 0.9299 5.940 36.0 36.0 36.0 36.0
96 96.23 37.38 132.2 0.9277 5.716 35.3 35.4 35.4 35.4
92 92.44 35.82 128.2 0.9256 5.491 34.6 34.8 34.9 34.8
88 88.63 34.27 124.2 0.9234 5.265 33.8 34.2 34.3 34.2
84 84.81 32.71 120.2 0.9212 5.038 33.0 33.6 33.7 33.6
80 80.96 31.15 116.2 0.9191 4.810 32.2 32.9 33.1 33.0
76 77.10 29.59 112.2 0.9169 4.580 31.3 32.3
. ~ . 32.4 32.3
72 73.22 28.04 108.2 0.9147 4.350 30.4 31.6 31.8 31.6
70 71.27 27.26 106.2 0.9136 4.234 30.0 31.2 31.4 31.2
68 69.32 26.48 104.2 0.9125 4.118 29.5 30.8 31.1 30.9
66 67.36 25.70 102.2 0.9115 4.002 29.0 30.5 30.5 30.5
64 65.40 24.92 100.2 0.9104 3.885 28.5 30.1 30.4 30.2
62 63.44 24.14 98.19 0.9093 3.768 28.0 29.7 30.0 29.8
60 61.46 23.59 96.19 0.9082 3.651 27.4 29.3 29.7 29.4
58 59.49 22.36 94.19 0.9071 3.534 26.9 28.9 29.3 29.0
56 57.51 21.81 92.19 0.9060 3.416 26.3 28.5 28.9 28.6
54 55.52 21.03 90.19 0.9049 3.298 25.7 28.1 28.5 28.2
52 53.53 20.25 88.19 0.9039 3.180 25.1 27.7 28.2 27.8
50 51.54 19.47 86.19 0.9028 3.061 24.4 27.3 27.8 27.4
48 49.53 18.69 84.20 0.9017 2.943 23.8 26.9 27.4 26.9
46 47.53 17.91 82.20 0.9006 2.823 23.1 26.4 27.0 26.5
44 45.52 17.13 80.20 0.8995 2.704 22.4 26.0 26.5 26.1
42 43.50 16.35 78.20 0.8984 2.584 21.6 25.5 26.1 25.6
40 41.48 15.58 76.20 0.8973 2.464 20.9 25.1 25.7 25.2
38 39.46 14.80 74.20 0.8963 2.344 20.0 24.6 25.3 24.7
36 37.43 14.02 72.20 0.8952 2.223 19.2 24.1 24.8 24.2
34 35.39 13.24 70.20 0.8941 2.102 18.3 23.6 24.3 23.7
32 33.35 12.46 68.20 0.8930 1.981 17.4 23.1 23.9 23.2
30 31.30 11.68 66.21 0.8919 1.860 16.4 22.6 23.4 22.7
28 29.25 10.90 64.21 0.8908 1.738 15.3 22.0 22.9 22.2
24 25.14 9.346 60.21 0.8886 1.493 13.0 20.9 21.9 21.1
20 21.00 7.788 56.21 0.8865 1.248 10.2 19.8 20.9 20.0
16 16.84 6.230 52.21 0.8843 1.000 7.0 18.6 19.8 18.8
12 12.66 4.673 48.22 0.8821 0.7522 2.9 17.3 18.7 17.5
' 8 8.46 3.115 44.22 0.8799 0.5027 -2.3 15.9 17.5 16.2
4 4.24 1.558 40.22 0.8778 0.2520 - 10.4 14.5 16.3 14.8
0 0.00 0.000 36.22 0.8756 0.0000 - i3.0 15.0 13.3
36.5"CDRY BULB
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,PC temperature Screen Sling
content enthalpy volume t*PC t'JT t',,PC
d~ .
ka-' h/kLkp-' dm3.ka-'
100 100.00 40.09 139.7 0.9330 6.106 36.5 36.5 36.5 36.5
96 96.23 38.49 135.5 0.9308 5.876 35.8 35.9 35.9 35.9
92 92.45 36.88 131.4 0.9285 5.645 35.1 35.3 35.4 35.3
88 88.65 35.28 127.3 0.9263 5.412 34.3 34.7 34.8 34.7
84 84.83 33.68 123.2 0.9241 5.179 33.5 34.1 34.2 34.1
80 80.99 32.07 119.1 0.9218 4.945 32.7 33.4 33.5 33.4
76 77.13 30.47 115.0 0.9196 4.709 31.8 32.7 32.9 32.8
72 73.25 28.87 110.8 0.9174 4.472 30.9 32.0 32.2 32.1
70 71.31 28.06 108.8 0.9162 4.354 30.5 31.7 31.9 31.7
68 69.36 27.26 106.7 0.9151 4.235 30.0 31.3 31.6 31.4
66 67.40 26.46 104.7 0.9140 4.115 29.5 30.9 31.2 31.0
64 65.44 25.66 102.6 0.9129 3.996 29.0 30.6 30.8 30.6
62 63.48 24.86 100.6 0.9118 3.876 28.4 30.2 30.5 30.2
60 61.51 24.06 98.49 0.9106 3.755 27.9 29.8 30.1 29.8
58 59.53 23.25 96.43 0.9095 3.635 27.3 29.4 29.7 29.5
56 57.55 22.45 94.37 0.9084 3.514 26.8 29.0 29.4 29.1
54 55.56 21.65 92.31 0.9073 3.392 26.2 28.6 29.0 28.6
52 53.57 20.85 90.25 0.9062 3.271 25.5 28.2 28.6 28.2
50 51.58 20.05 88.19 0.9050 3.149 24.9 27.7 28.2 27.8
48 49.58 19.24 86.14 0.9039 3.027 24.2 27.3 27.8 27.4
46 47.57 18.44 84.08 0.9028 2.905 23.6 26.8 27.4 26.9
44 45.56 17.64 82.02 0.9017 2.782 22.8 26.4 27.0 26.5
42 43.55 16.84 79.96 0.9006 2.659 22.1 25.9 26.5 26.0
40 41.53 16.04 77.90 0.8994 2.535 21.3 25.5 26.1 25.6
38 39.50 15.24 75.84 0.8983 3.412 20.5 25.0 25.6 25.1
36 37.47 14.43 73.78 0.8972 2.288 19.7 24.5 25.2 24.6
34 35.43 13.63 71.72 0.8961 2.163 18.8 24.0 24.7 24.1
32 33.39 12.83 69.67 0.8950 2.039 17.8 23.5 24.3 23.6
30 31.34 12.03 67.61 0.8938 1.914 16.8 22.9 23.8 23.1
28 29.29 11.23 65.55 0.8927 1.788 15.8 22.4 23.3 22.5
24 25.17 9.622 61.43 0.8905 1.537 13.4 21.3 22.3 21.4
20 21.03 8.018 57.31 0.8882 1.284 10.7 20.1 21.2 20.3
16 16.87 6.415 53.20 0.8860 1.030 7.4 18.9 20.1 19.1
12 12.68 4.811 49.08 0.8837 0.7743 3.3 17.6 19.0 17.8
8 8.48 3.207 44.96 0.8815 0.5175 -2.0 16.2 17.8 16.5
4 4.25 1.604 40.84 0.8792 0.2594 -10.0 14.7 16.5 15.0
0 0.00 0.000 36.73 0.8770 0.0000 - 13.2 15.2 13.5
1-54 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
111% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t */oc t'JC t'JC
g/g.kg-' hlkJ.kg-I vlm'. kg-'
100 100.00 41.28 143.2 0.9362 6.274 37.0 37.0 37.0 37.0
96 96.24 39.62 139.0 0.9339 6.038 36.3 36.4 36.4 36.4
92 92.46 37.97 134.8 0.9316 5.802 35.6 35.8 35.9 35.8
88 88.67 36.32 130.5 0.9293 5.563 34.8 35.2 35.3 35.2
84 84.85 34.67 126.3 0.9270 5.324 34.0 34.5 34.6 34.6
33.02 122.0.
~~~ 0.9246 5.083 33.2 33.9 34.0 33.9
31.37 117.8 0.9223 4.842 32.3 33.2 33.4 33.2
29.72 113.6 0.9200 4.598 31.4 32.5 32.7 32.5
28.89 111.4 0.9189 4.476 30.9 32.1 32.4 32.2
68 69.40 28.07 109.3 0.9177 4.354 30.5 31.8 32.0 31.8
66 67.44 27.24 107.2 0.9166 4.232 30.0 31.4 31.7 31.4
64 65.48 26.42 105.1 0.9154 4.109 29.4 31.0 31.3 31.1
62 63.52 25.59 103.0 0.9143 3.985 28.9 30.6 30.9 30.7
60 61.55 24.77 100.8 0.9131 3.862 28.4 30.2 30.6 30.3
58 59.57 23.94 98.72 0.9120 3.738 27.8 29.8 30.2 29.9
56 57.59 23.11 96.60 0.9108 3.614 27.2 29.4 29.8 29.5
54 55.61 22.29 94.48 0.9096 3.489 26.6 29.0 29.4 29.1
52 53.62 21.46 92.36 0.9085 3.364 26.0 28.6 29.0 28.7
50 5 1.62 20.64 90.24 0.9073 3.239 25.4 28.2 28.6 28.2
48 49.62 19.81 88.12 0.9062 3.1 14 24.7 27.7 28.2 27.8
46 47.62 18.99 86.00 0.9050 2.988 24.0 27.3 27.8 27.4
44 45.61 18.16 83.88 0.9039 2.862 23.3 26.8 27.4 26.9
42 43.59 17.34 81.75 0.9027 2.735 22.6 26.3 26.9 26.4
40 41.57 16.51 79.63 0.9016 2.608 21.8 25.9 26.5 26.0
38 39.54 15.68 77.51 0.9004 2.481 21.0 25.4 26.0 25.5
36 37.51 14.86 75.39 0.8992 2.354 20.1 24.9 25.6 25.0
34 35.47 14.03 73.27 0.8981 2.226 19.2 24.4 25.1 24.5
32 33.43 13.21 71.15 0.8969 2.098 18.3 23.8 24.6 24.0
30 31.38 12.38 69.03 0.8958 1.969 17.3 23.3 24.1 23.4
28 29.33 11.56 66.91 0.8946 1.840 16.2 22.8 23.7 22.9
24 25.20 9.906 62.67 0.8923 1.581 13.8 21.6 22.6 21.8
20 2 1.06 8.255 58.43 0.8900 1.321 11.1 20.4 21.6 20.6
16 16.89 6.604 54.19 0.8877 1.060 7.8 19.2 20.4 19.4
12 12.70 4.953 49.95 0.8854 0.7970 3.7 17.9 19.3 18.1
8 8.49 3.302 45.71 0.8830 0.5327 -1.6 16.5 18.0 16.7
4 4.26 1.65 1 41.47 0.8807 0.2671 -9.7 15.0 16.8 15.3
0 0.00 0.000 37.23 0.8784 0.0000 - 13.4 15.4 13.7
38.5"CDRY BULB
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
/l/% 41% Moisture Specific Specific pJkPa t,/"C temperature Screen Sling
content enthalpy volume z*/"C t'JT tll,PC
d e .ke-' hlkI.ke-I vlm3.ke-'
100 100.00 45.03 154.5 0.9460 6.806 38.5 38.5 38.5 38.5
96 96.26 43.23 149.9 0.9434 6.551 37.8 37.9 37.9 37.9
92 92.50 4 1.42 145.2 0.9409 6.295 37.1 37.3 37.3 37.3
88 88.72 39.62 140.6 0.9384 6.038 36.3 36.7 36.7 36.7
84 84.92 37.82 136.0 0.9359 5.780 35.5 36.0 36.1 36.0
80 81.10 36.02 131.4 0.9333 5.520 34.7 35.3 35.5 35.4
76 77.26 34.22 126.7 0.9308 5.258 33.8 34.6 34.8 34.7
72 73.40 32.42 122.1 0.9283 4.995 32.9 33.9 34.1 33.9
70 71.46 31.52 119.8 0.9270 4.863 32.4 33.5 33.8 33.6
68 69.52 30.62 117.5 0.9258 4.731 31.9 33.2 33.4 33.2
66 67.57 29.72 ii5.2 0.9245 4.598 31.4 32.8 33.0 32.8
64 65.61 28.82 112.8 0.9232 4.465 30.9 32.4 32.7 32.4
62 63.65 27.92 110.5 0.9220 4.332 30.4 32.0 32.3 32.0
60 61.68 27.02 108.2 0.9207 4.198 29.8 31.6 31.9 31.6
58 59.71 26.12 105.9 0.9194 4.064 29.3 31.2 31.5 31.2
56 57.73 25.22 103.6 0.9182 3.929 28.7 30.8 31.1 30.8
54 55.75 24.31 101.3 0.9169 3.794 28.1 30.3 30.7 30.4
52 53.76 23.41 98.94 0.9156 3.659 27.4 29.9 30.3 30.0
50 51.76 22.51 96.62 0.9144 3.523 26.8 29.4 29.9 29.5
48 49.76 21.61 94.31 0.9131 3.387 26.1 29.0 29.5 29.1
46 47.76 20.71 91.99 0.9118 3.250 25.4 28.5 29.0 28.6
44 45.75 19.81 89.68 0.9106 3.113 24.7 28.1 28.6 28.1
42 43.73 18.91 87.36 0.9093 2.976 24.0 27.6 28.2 27.7
40 41.71 18.01 85.05 0.9080 2.838 23.2 27.1 27.7 27.2
38 39.68 17.11 82.73 0.9068 2.700 22.4 26.6 27.2 26.7
36 37.64 16.21 80.42 0.9055 2.562 21.5 26.1 26.8 26.2
34 35.60 15.31 78.10 0.9042 2.423 20.6 25.5 26.3 25.6
32 33.56 14.41 75.79 0.9030 2.284 19.6 25.0 25.8 25.1
30 31.50 13.51 73.47 0.9017 2.144 18.6 24.4 25.3 24.6
28 29.45 12.61 71.15 0.9004 2.004 17.5 23.9 24.7 24.0
24 25.31 10.81 66.52 0.8979 1.723 15.2 22.7 23.7 22.8
20 21.15 9.005 61.89 0.8954 1.440 12.4 21.4 22.5 21.6
16 16.97 7.204 57.26 0.8928 1.155 9.1 20.1 21.4 20.3
12 12.77 5.403 52.63 0.8903 0.8688 4.9 18.7 20.1 18.9
8 8.53 3.602 48.00 0.8878 0.5809 -0.6 17.2 18.8 17.5
4 4.28 1.801 43.37 0.8852 0.2913 -8.7 15.7 17.5 16.0
0 0.00 0.000 38.74 0.8827 0.0000 - 14.0 16.0 14.3
1-56 Reference data
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C t /"c t',PC
~
glg.kg-l hlkJ.kg-' vlm 3. kg-
100 100.00 61.73 203.6 0.9865 9.100 44.0 44.0 44.0 44.0
96 96.35 59.26 197.2 0.9830 8.768 43.3 43.3 43.4 43.4
92 92.67 56.79 190.9 0.9795 8.434 42.5 42.6 42.8 42.7
88 88.97 54.32 184.5 0.9760 8.097 41.8 41.9 42.1 42.1
84 85.24 51.85 178.1 0.9725 7.757 40.9 41.2 41.4 41.4
80 81.48 49.38 171.7 0.9689 7.415 40.1 40.4 40.8 40.7
76 77.69 46.91 165.4 0.9654 7.071 39.2 39.9 40.0 39.9
72 73.88 44.45 159.0 0.9619 6.723 38.3 39.1 39.3 39.2
70 71.96 43.21 155.8 0.9601 6.549 37.8 38.7 38.9 38.8
68 70.04 41.98 152.6 0.9584 6.374 37.3 38.3 38.5 38.4
66 68.11 40.74 149.4 0.9566 6.198 36.8 37.9 38.1 37.9
64 66.17 39.51 146.2 0.9548 6.022 36.2 37.5 37.7 37.5
62 64.22 38.27 143.1 0.9531 5.844 35.7 37.0 37.3 37.1
60 62.27 37.04 139.9 0.95 13 5.666 35.1 36.6 36.9 36.7
58 60.30 35.80 136.7 0.9495 5.488 34.6 36.2 36.5 36.2
56 58.34 34.57 133.5 0.9478 5.309 34.0 35.7 36.0 35.8
54 56.36 33.33 130.3 0.9460 5.129 33.3 35.2 35.6 35.3
52 54.38 32.10 127.1 0.9443 4.949 32.7 34.7 35.1 34.8
50 52.38 30.87 123.9 0.9425 4.767 32.0 34.3 34.7 34.3
48 50.38 29.63 120.8 0.9407 4.585 31.4 33.8 34.2 33.8
46 48.38 28.40 117.6 0.9390 4.403 30.6 33.2 33.7 33.3
44 46.36 27.16 114.4 0.9372 4.219 29.9 32.7 33.2 32.8
42 44.34 25.93 111.2 0.9354 4.035 29.1 32.2 32.7 32.3
40 42.31 24.69 108.0 0.9337 3.85 1 28.3 31.6 32.2 31.7
38 40.27 23.46 104.8 0.9319 3.665 27.5 31.0 31.7 31.2
22.22 101.6
~ . ~ .0.9301 3.479 26.6 30.5 31.1 30.6
20.99 98.45 0.9284 3.292 25.7 29.9 30.6 30.0
19.75 95.26 0.9266 3.104 24.7 29.2 30.0 29.4
18.52 92.07 0.9248 2.916 23.6 28.6 29.4 28.7
28 29.97 17.28 88.89 0.9231 2.727 22.5 28.0 28.8 28.1
24 25.78 14.82 82.51 0.9195 2.347 20.1 26.6 27.5 26.7
20 21.57 12.35 76.14 0.9160 1.963 17.2 25.1 26.2 25.3
16 17.33 9.877 69.77 0.9125 1.577 13.8 23.6 24.8 23.8
12 13.05 7.408 63.40 0.9089 1.187 9.5 21.9 23.3 22.1
8 8.73 4.938 57.02 0.9054 0.7946 3.7 20.1 21.7 20.4
4 4.38 2.469 50.65 0.9018 0.3989 -5.1 18.1 20.0 18.5
0 0.00 0.000 44.28 0.8983 0.0000 - 16.0
_. . 18.2
_. ~ 16.4
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C t'JC tIs,PC
g1g.kg-I hlkJ.kg-l vlrn3.kg-l
100 100.00 73.20 236.6 1.012 10.61 47.0 47.0 47.0 47.0
96 96.41 70.27 229.0 1.008 10.23 46.3 46.3 46.4 46.4
92 92.78 67.35 221.5 1.004 9.847 45.5 45.6 45.7 45.7
88 89.13 64.42 213.9 0.9998 9.459 44.7 44.9 45.1 45.0
84 85.45 6 1.49 206.3 0.9956 9.068 43.9 44.1 44.4 44.3
80 81.73 58.56 198.8 0.9913 ' 8.674 43.1 43.3 43.7 43.6
76 77.98 55.63 191.2 0.9871 8.276 42.2 42.5 42.9 42.8
72 74.20 52.71 183.6 0.9829 7.875 41.2 41.6 42.2 42.0
70 72.30 51.24 179.8 0.9808 7.673 40.7 41.2 41.8 41.6
68 70.39 49.78 176.0 0.9787 7.470 40.2 40.7 41.4 41.2
66 68.47 48.31 172.2 0.9766 7.266 39.7 40.3 40.9 40.8
64 66.54 46.85 168.5 0.9745 7.061 39.2 40.0 40.5 40.3
62 64.60 45.39 164.7 0.9724 6.856 38.6 39.8 40.1 39.9
60 62.66 43.92 160.9 0.9703 6.649 38.1 39.4 39.7 39.4
58 60.70 42.46 157.1 0.9681 6.442 37.5 38.9 39.2 39.0
56 58.74 40.99 153.3 0.9660 6.234 36.9 38.4 38.8 38.5
54 56.77 39.53 149.5 0.9639 6.025 36.3 37.9 38.3 38.0
52 54.79 38.07 145.7 0.9618 5.814 35.6 37.4 37.8 37.5
50 52.80 36.60 142.0 0.9597 5.603 34.9 36.9 37.3 37.0
48 50.80 35.14 138.2 0.9576 5.391 34.2 36.4 36.8 36.5
46 48.79 33.67 134.4 0.9555 5.178 33.5 35.9 36.3 35.9
44 46.78 32.21 130.6 0.9534 4.964 32.8 35.3 35.8 35.4
42 44.75 30.75 126.8 0.9513 4.749 32.0 34.7 35.3 34.8
40 42.72 29.28 123.0 0.9491 4.534 31.2 34.1 34.7 34.3
38 40.68 27.82 119.2 0.9470 4.317 30.3 33.5 34.1 33.7
36 38.62 26.35 115.4 0.9449 4.099 29.4 32.9 33.6 33.0
34 36.56 24.89 111.7 0.9428 3.880 28.5 32.3 33.0 32.4
32 34.49 23.43 107.9 0.9407 3.660 27.5 31.6 32.3 31.8
30 32.41 21.96 104.1 0.9386 3.439 26.4 30.9 31.7 31.1
28 30.32 20.50 100.3 0.9365 3.217 25.3 30.2 31.1 30.4
24 26.11 17.57 92.74 0.9322 2.770 22.8 28.8 29.7 28.9
20 21.86 14.64 85.16 0.9280 2.319 19.9 27.2 28.3 27.4
16 17.57 11.71 77.59 0.9238 1.864 16.4 25.5 26.7 25.7
12 13.24 8.784 70.02 0.9195 1.405 12.0 23.7 25.1 23.9
8 8.87 5.856 62.44 0.9153 0.9409 6.1 21.7 23.3 21.9
4 4.45 2.928 54.87 0.9110 0.4727 -3.1 19.5 21.4 19.8
0 0.00 0.000 47.30 0.9068 0.0000 - 17.1 19.3 17.5
Psychrometric tables 1-61
____ ~ ~
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
Saturation humidity pressure temperature saturation ~
,C/% 41% Moisture Specific Specific pJkPa t, /"C temperature Screen Sling
content enthalpy volume t*/"C t'JC t'JC
g1g.kg-I h/kJ.kg-' vim'.kg-
100 100.00 91.81 289.4 1.052 12.96 51.0 51.0 51.0 51.0
96 96.50 88.14 279.9 1.047 12.51 50.3 50.3 50.4 50.3
92 92.96 84.46 270.4 1.042 12.05 49.5 49.7 49.7 49.7
88 89.38 80.79 260.8 1.036 11.58 48.7 49.0 49.0 49.0
84 85.77 77.12 25 1.3 1.031 11.12 47.9 48.2 48.3 48.2
80 82.12 73.45 241.8 1.026 10.64 47.1 47.5 47.6 47.5
76 78.43 69.78 232.3 1.020 i0.k 46.2 46.7 46.8 46.7
72 74.70 66.10 222.8 1.015 9.682 45.2 45.8 46.0 45.9
70 72.83 64.27 218.0 1.012 9.439 44.7 45.4 45.6 45.5
68 70.94 62.43 213.2 1.009 9.194 44.2 45.0 45.2 45.0
66 69.04 60.59 208.5 1.007 8.948 43.7 44.5 44.7 44.6
64 67.13 58.76 203.7 1.004 8.700 43.1 44.1 44.3 44.1
62 65.20 56.92 198.9 1.001 8.451 42.6 43.6 43.8 43.7
60 63.27 55.09 194.2 0.9987 8.201 42.0 43.1 43.4 43.2
58 61.33 53.25 189.4 0.9960 7.949 41.4 42.6 42.9 42.7
56 59.38 51.41 184.7 0.9933 7.696 40.8 42.1 42.4 42.2
54 57.42 49.58
. .. 179.9 0.9907 7.442 40.2 41.6 41.9 41.7
52 55.44 47.74 i75.i 0.9880 7.186 39.5 41.1 41.4 41.2
50 53.46 45.90 170.4 0.9853 6.929 38.8 40.5 40.9 40.6
48 5 1.46 44.07 165.6 0.9826 6.670 38.1 40.0 40.4. 40.1
46 49.46 42.23 160.8 0.9799 6.410 37.4 39.4 39.8 39.5
44 47.44 40.40 156.1 0.9773 6.148 36.6 38.8 39.3 38.9
42 45.41 38.56 151.3 0.9746 5.885 35.8 38.2 38.7 38.3
40 43.37 36.72 146.6 0.9719 5.621 35.0 37.6 38.1 37.7
38 41.32 34.89 141.8 0.9692 5.355 34.1 36.9 37.5 37.1
36 39.25 33.05 137.0 0.9665 5.087 33.2 36.3 36.9 36.4
34 37.i8 31.22 132.3 0.9639 4.818 32.2 35.6 36.2 35.7
32 35.09 29.38 127.5 0.9612 4.548 31.2 34.9 35.6 35.0
30 32.99 27.54 122.8 0.9585 4.276 30.1 34.1 34.9 34.3
28 30.88 25.71 118.0 0.9558 4.002 29.0 33.4 34.2 33.5
24 26.62 22.03 108.5 0.9504 3.450 26.4 31.8 32.7 31.9
20 22.31 18.36 98.94 0.9451 2.892 23.5 30.0 31.1 30.2
16 17.95 14.69 89.42 0.9397 2.327 19.9 28.1 29.3 28.3
12 13.54 11.02 79.90 0.9343 1.755 15.5 26.1 27.5 26.3
8 9.08 7.345 70.37 0.9289 1.177 9.4 23.8 25.4 24.1
4 4.57 3.672 60.85 0.9235 0.5920 -0.4 21.3 23.2 21.6
0 0.00 0.000 51.33 0.9182 0.0000 - 18.4 20.8 18.8
Psvchrometric tables 1-63
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
p/% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthalpy volume t*l"C t'JC PC
tfSI
PIE.ka-I hlkT.ka-I v/m3.ka-l
100 100.00 108.8 337.1 1.0869 15.00 54.0 54.0 54.0 54.0
96 96.58 104.5 325.8 1.0805 14.49 53.3 53.3 53.4 53.3
92 93.11 100.1 314.5 1.0741 13.97 52.5 52.6 52.7 52.7
88 89.61 95.76 303.2 1.0678 13.44 51.7 51.9 52.0 52.0
84 86.06 91.40 291.9 1.0614 12.91 50.9 51.2 51.3 51.2
80 82.47 87.05 280.6 1.0550 12.37 50.1 50.4 50.5 50.4
76 78.83 82.70 269.2 1.0486 11.83 49.2 49.6 49.7 49.6
72 75.15 78.35 257.9 1.0422 11.27 48.2 48.8 48.9 48.8
70 73.29 76.17 252.3 1.0390 10.99 47.7 48.3 48.5 48.4
68 7 1.42 73.99 246.6 1.0358 10.71 47.2 47.9 48.1 47.9
66 69.54 71.82 241.0
- ~. 1.0326 10.43 46.7 47.4 47.6 47.5
64 67.64 69.64 235.3 i.0294 10.16 46.1 47.0 47.2 47.0
62 65.74 67.47 229.7 1.0262 9.862 45.6 46.5 46.7 46.5
60 63.82 65.29 224.0 1.0230 9.574 45.0 46.0 46.2 46.0
58 61.89 63.1 1 218.4 1.0198 9.285 44.4 45.5 45.7 45.5
56 59.95 60.94 212.7 1.0166 8.993 43.8 45.0 45.2 45.0
54 57.99 58.76 207.0 1.0134 8.700 43.1 44.4 44.7 44.5
52 56.02 56.58 201.4 1.0102 8.405 42.5 43.9 44.2 44.0
50 54.04 54.41 195.7 1.0070 8.108 41.8 43.3 43.7 43.4
48 52.05 52.23 190.1 1.0038 7.809 41.1 42.7 43.1 42.8
46 50.05 50.06 184.4 1.0006 7.508 40.3 42.1 42.5 42.2
44 48.03 47.88 178.8 0.9974 7.205 39.6 41.5 42.0 41.6
42 45.99 45.70 173.1 0.9942 6.900 38.8 40.9 41.4 41.0
40 43.95 43.53 167.5 0.9909 6.593 37.9 40.2 40.7 40.4
38 41.89 41.35 161.8 0.9877 6.284 37.0 39.6 40.1 39.7
36 39.82 39.17 156.1 0.9845 5.973 36.1 38.9 39.4 39.0
34 37.73 37.00 150.5 0.9813 5.660 35.1 38.1 38.7 38.3
32 35.63 34.82 144.8 0.9781 5.345 34.1 37.4 38.0 37.5
30 33.51 32.64 139.2 0.9749 5.028 33.0 36.6 37.3 36.8
30.47 133.5 0.9717 4.708 31.8 35.8 36.5 36.0
26.12 122.2
~ -- - 0.9653 4.063 29.3 34.1 34.9 34.3
21.76 110.9 0.9588 3.409 26.2 32.2 33.2 32.4
17.41 99.59 0.9524 2.746 22.6 30.2 31.3 30.4
13.06 88.28 0.9460 2.074 18.1 27.9 29.3 28.2
8 9.28 8.705 76.97 0.9396 1.392 11.9 25.4 27.0 25.7
4 4.67 4.353 65.66 0.9331 0.7009 1.9 22.6 24.6 22.9
0 0.00 0.000 54.35 0.9267 0.0000 - 19.4 21.8 19.8
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% 41% Moisture Specific Specific pJkPa t,l"C temperature Screen Sling
content enthaluv volume t*l"C f ' sc /"c t' I.PC
g/g.kg-' h/kJ.kg-'l vim3.kg-'
100 100.00 115.2 354.8 1.100 15.74 55.0 55.0 55.0 55.0
96 96.60 110.6 342.9 1.093 15.21 54.3 54.3 54.4 54.3
92 93.17 106.0 330.9 1.086 14.67 53.5 53.6 53.7 53.7
88 89.69 101.4 318.9 1.079 14.12 52.7 52.9 53.0 52.9
84 86.16 96.74 306.9 1.072 13.56 51.9 52.2 52.3 52.2
80 82.59 92.14 294.9 1.066 13.00 51.1 51.4 51.5 51.4
76 78.97 87.53 283.0 1.059 12.43 50.2 50.6 50.7 50.6
72 75.31 82.92 271.0 1.052 11.85 49.2 49.7 49.9 49.8
70 73.46 80.62 265.0 1.049 11.56 48.7 49.3 49.5 49.4
68 71.60 78.32 259.0 1.045 11.2 48.2 48.9 49.0 48.9
66 69.72 76.01 253.0 1.042 10.97 47.7 48.4 48.6 48.4
64 67.83 73.71 247.0 1.038 10.68 47.1 47.9 48.1 48.0
62 65.93 71.41 241.0 1.035 10.38 46.6 47.4 47.7 47.5
60 64.02 69.10 235.0 1.032 10.08 46.0 46.9 47.2 47.0
58 62.09 66.80 229.1 1.028 9.774 45.4 46.4 46.7 46.5
56 60.16 64.50 223.1 1.025 9.479 44.8 45.9 46.2 46.0
54 58.20 62.19 217.1 1.022 9.161 44.1 45.4 45.7 45.4
52 56.24 59.89 211.1 1.018 8.852 43.5 44.8 45.1 44.9
50 54.26 57.59 205.1 1.015 8.541 42.8 44.2 44.6 44.3
48 52.27 55.28 199.1 1.011 8.237 42.1 43.7 44.0 43.8
46 50.26 52.98 193.1 1.008 7.911 41.3 43.1 43.5 43.2
44 48.24 50.68 187.1 1.004 7.593 40.5 42.4 42.9 42.5
42 46.21 48.37 181.1 1.001 7.273 39.7 41.8 42.2 41.9
40 44.16 46.07 175.2 0.9977 6.951 38.9 41.1 41.6 41.2
38 42.10 43.76 169.2 0.9943 6.636 38.0 40.4 41.0 40.6
36 40.02 41.46 163.2 0.9909 6.300 37.1 39.7 40.3 39.9
34 37.93 39.16 157.2 0.9875 5.971 36.1 39.0 39.6 39.1
32 35.83 36.86 151.2 0.9841 5.640 35.1 38.2 38.9 38.4
30 33.71 34.55 145.2 0.9807 5.305 34.0 37.4 38.1 37.6
28 31.57 32.25 139.2 0.9773 4.979 32.8 36.6 37.4 36.8
24 27.25 27.64 127.2 0.9705 4.290 30.2 34.9 35.7 35.0
20 22.88 23.03 115.3 0.9637 3.600 27.2 33.0 34.0 33.2
16 18.43 18.43 103.3 0.9568 2.901 23.5 30.9 32.0 31.1
12 13.93 13.82 91.30 0.9500 2.192 19.0 28.6 29.9 28.8
8 9.35 9.214 79.32 0.9432 1.472 12.7 26.0 27.6 26.3
4 4.71 4.607 67.34 0.9363 0.7416 2.7 23.1 25.0 23.4
0 0.00 0.000 55.36 0.9295 0.0000 - 19.7 22.1 20.1
Psychrometr ic tables 1-65
Percentage Relative Value of stated parameter per kg dry air Vapour Dew point Adiabatic Wet bulb temperature
saturation humidity pressure temperature saturation
PI% +I% Moisture Specific Specific pJkPa t,PC temperature Screen Sling
content enthalpy volume r *PC r'JC t'JC
g/g.kg-I hlkJ.kg-I vlm3.kg-l
100 100.00 129.1 393.4 1.127 17.31 57.0 57.0 57.0 57.0
96 96.66 123.9 380.0 1.119 16.74 56.3 56.3 56.3 56.3
92 93.29 118.7 366.6 1.112 16.15 55.5 55.6 55.7 55.7
88 89.86 113.6 353.1 1.104 15.56 54.8 54.9 55.0 54.9
84 86.38 108.4 339.7 1.096 14.96 53.9 54.2 54.2 54.2
80 82.86 103.3 326.2 1.089 14.34 53.1 53.4 53.5 53.4
76 79.28 98.09 312.8 1.081 13.73 52.2 52.6 52.7 52.6
72 75.65 92.93 299.3 1.073 13.10 51.2 51.7 51.9 51.8
70 73.82 90.35 292.6 1.070 12.78 50.7 51.3 51.4 51.3
68 71.97 87.77 285.9 1.066 12.46 50.2 50.8 51.0 50.9
66 70.11 85.19 279.2 1.062 12.14 49.7 50.3 50.5 50.4
64 68.24 82.60 272.5 1.058 11.81 49.1 49.9 50.1 49.9
62 66.35 80.02 265.7 1.054 11.49 48.6 49.4 49.6 49.4
60 64.45 77.44 259.0 1.050 11.16 48.0 48.9 49.1 48.9
58 62.53 74.86 252.3 1.047 10.83 47.4 48.4 48.6 48.4
56 60.60 72.28 245.6 1.043 10.49 46.8 47.8 48.1 47.9
54 58.66 69.70 238.9 1.039 10.16 46.1 47.3 47.6 47.4
52 56.70 67.12 232.1 1.035 9.816 45.5 46.7 47.0 46.8
50 54.72 64.53 225.4 1.031 9.474 44.8 46.1 46.5 46.2
48 52.73 61.95 218.7 1.027 9.130 44.1 45.5 45.9 45.6
46 50.73 59.37 212.0 1.024 8.783 43.3 44.9 45.3 45.0
44 48.71 56.79 205.2 1.020 8.433 42.5 44.3 44.7 44.4
42 46.67 54.21 198.5 1.016 8.080 41.7 43.6 44.1 43.7
40 44.62 5 1.63 191.8 1.012 7.725 40.9 42.9 43.4 43.1
38 42.56 49.05 185.1 1.008 7.368 40.0 42.2 42.7 42.4
36 40.47 46.46 178.4 1.004 7.007 39.0 41.5 42.0 41.6
34 38.37 43.88 171.6 1.001 6.644 38.1 40.7 41.3 40.9
32 36.26 41.30 164.9 0.9967 6.277 37.0 40.0 40.6 40.1
30 34.13 38.72 158.2 0.9929 5.908 35.9 39.1 39.8 39.3
28 31.98 36.14 151.5 0.9891 5.536 34.7 38.3 39.0 38.5
24 27.63 30.98 138.0 0.9814 4.783 32.1 36.5 37.3 36.7
20 23.21 25.81 124.6 0.9737 4.018 29.1 34.5 35.4 34.7
16 18.72 20.65 111.1 0.9660 3.240 25.4 32.3 33.4 32.5
12 14.15 15.49 97.70 0.9583 2.450 20.8 29.9 31.2 30.1
8 9.51 10.33 84.26 0.9506 1.647 14.5 27.1 28.7 27.4
4 4.80 5.163 70.82 0.9429 0.8303 4.3 24.0 25.9 24.3
0 0.00 0.000 57.37 0.9352 0.0000 - 20.3 22.8 20.7
1-66 Reference data