Beruflich Dokumente
Kultur Dokumente
T0009739
Contents
• “MID 128 SID 42 Fuel control unit” page 2
• “MID 128 SID 42 Fuel control unit, check” page 3
20 071421
ENG22068 English
Printed in Sweden
Volvo Truck Corporation Date Group No. Release Page
Service Bulletin 6.06 284 50 01 2(4)
Malfunction
MID 128 SID 42 Fuel control unit
28321-3
MID 128 SID 42 Fuel control unit, check
Special tools: 9990014, 9990216, 9998699
Other special equipment: 9812519
Fault code information, see “MID 128 SID 42 Fuel
control unit” page 2.
NOTE!
• Active/inactive fault code
Certain fault codes become inactive when the engine is
shut off. Start the engine to see if the fault code is still
inactive or becomes active when the engine is running.
• Connector block
Always check that there is no oxidisation and that the
pins in the connector are not damaged. Also check the
grip of the pins. For more information, refer to Function
Group 3710, Information type Diagnostics, 37102-3
Electric wires and connections, check.
If the connector is free from faults, reconnect it.
Check if the fault code is still active. If the fault code
is still active, continue fault tracing according to
the instructions.
• After any corrective actions on the connector block
Refit the connector. Check if the fault code has
become inactive.
If the fault code is still active, continue fault tracing
according to the instructions.
Measurements
Note: If any of the following cable measurement values
are faulty, they may have caused the component to be
damaged. Check also if any of the component’s values
are faulty.
Component:
1
Conditions:
• Adapter connected towards component
• Starter key in stop position.
• Measure resistance using a multimeter.
Measurement points Expected value
1-2 R≈3
1 - Ground Circuit break
9990216
9812519
T2023306
Volvo Truck Corporation Date Group No. Release Page
Service Bulletin 6.06 284 50 01 4(4)
Cabling
2
T2023702 Conditions:
• Adapter connected towards cable harness.
• Break-out box and adapter connected towards
cable harness.
• Starter key in stop position.
• Measure resistance using a multimeter.
Measurement points Expected value
1 - EA12 R≈0
2 - EA16 R≈0