Beruflich Dokumente
Kultur Dokumente
S = Material Strength (psi) Ultimate Tensile strength or Yield strength can be used.
Ultimate should be used to determine the bursting pressure.
Yield can be used for estimating pressures at which permanent deformation begins.
Pipe Working Pressure Calculation
Note: Ultimate Tensile Strength value is taken from ASTM A312 & ASTM A789
Note: Yield Strength value is taken from ASTM A312 & ASTM A789
e Remark: The above value has been derived from Which we got Fro
S S
(Ultimate (Ultimate
Tensile Tensile Safety
Pressure Strength) Strength) Factor P= 2*S*T
Bar KSI psi - (2*OD*T)*(SF)
426 90 90000 1 25714 1773
570 90 90000 1 37895 2613
554 70 70000 1 36842 2541
800 70 70000 1 53232 3671
763 70 70000 1 66667 4598
954 70 70000 1 83333 5747
A = additional thickness
DO = pipe outside diameter (not nominal diameter)
P
SE= =internal
maximumdesign gage pressure
allowable stress in material from internal pressure and joint efficiency (or casting quality
factor, SF) at design temperature from Appendix A
tm = minimum required thickness including additional thickness, A
y = coefficient provided in Table 104.1.2(A) of the Code and Table 4.1 herein
P
180
cy (or casting quality