Beruflich Dokumente
Kultur Dokumente
i01929133
This diagnostic code is recorded when the ECM reads the system voltage as being greater
than 16 DCV.
System Response:
When this diagnostic code occurs, the action lamp and the action alarm is ON. The
diagnostic code will cause the transmission to shift to NEUTRAL until the diagnostic code
is corrected.
A. Turn the disconnect switch and the key start switch to the ON position.
B. Place CID 0168 FMI 03 on hold. See Troubleshooting, "Using the Diagnostic
Indicator to Determine Diagnostic Codes".
Expected Result:
Results:
Expected Result:
Results:
Repair: Check the charging system. See Special Instruction, REHS0354, "Charging
System Troubleshooting" for more information.
STOP
Expected Result:
Results:
YES - The voltage measures less than 16 DCV. The ECM must be recording this
diagnostic code incorrectly. The ECM may have failed.
Repair: It is unlikely that the ECM has failed. Exit this procedure and perform this
procedure again. If the cause of the diagnostic code is NOT found, replace the
ECM. SeeTesting and Adjusting, "Electronic Control Module (ECM) - Replace".
STOP
NO - The voltage measurement is greater than 16 DCV. The charging system is
charging at an excessive voltage.
STOP
1 1 -1