Beruflich Dokumente
Kultur Dokumente
Innovative
NEW
NEW ✓ All the benefits of the established Edjpro system with a
narrower anchor and recess for thin panels from 125mm
✓ Ideal for thin panels with step joints
EdjPro STRONGER
✓ Up to 10 tonnes WLL when used with a 20mm tension bar
Narrow SAFE
✓ Anchor code, WLL and batch number are clearly visible
when cast into concrete
✓ Complies with the requirements of AS3850.1:2015
EdjPro Narrow
Narrow Anchor
Ideal for lifting thin factory-cast panels. (EPNA10)
Suitable for a 125mm panel width. Narrow Recess
Former (EPNRF10)
System Performance
Working loads in tension
Recommended Total Spread WLL
Anchor Tension development cut width tension
CODE Bar length (mm) length (mm) tonnes
Colour 15Mpa Lsy.tb (mm) w
EPNA10 N16 625 1530 350 7
4db
Green N20 750 1820 400 10
EdjPro Narrow Anchors can be fitted with N16 or N20 tension bars.
Working loads in shear
Panel thickness Concrete compressive strength at the time of lift (f’c) MPa
(mm) 10 12 15 20 25 30 40
Maximum recommended shear load (tonnes) for EdjPro anchors with tension bars.
125 1.60 1.80 2.00 2.30 2.60 2.80 3.20
Lsy.tb
WITH an N16 150 1.90 2.00 2.30 2.60 2.90 3.20 3.50
or N20 tension 175 2.10 2.30 2.60 3.00 3.30 3.50 3.50
bar and N16 200 2.40 2.60 2.90 3.30 3.50 3.50 3.50
trimmer bar
250 2.90 3.10 3.50 3.50 3.50 3.50 3.50
300 3.30 3.50 3.50 3.50 3.50 3.50 3.50
Notes: Locate the N16 perimeter “trimmer” bar above the EdjPro anchor to control flexural cracking. Shear “omega” bars may help control shear w
cracking at higher loads. Panel cracking and shear spalling is possible if the recommended loads are exceeded.
Some anchor deflection is normal, particularly at high sling angles. Sling angles greater than 60º are not recommended.
Vertical rigging is the preferred method for edge lifting thin panels in shear to minimise forces on the panel edge.
30mm
125.5mm
275mm