Beruflich Dokumente
Kultur Dokumente
Circuit Diagram
The third stage is an FM transmitter circuit that will broadcast the melody signal of the Temperature Sensor
LED Meter
UM66 IC to an FM receiver at a distance of 50 meters. The 10K variable resistor in this
12V Water Pump Heat Sensor With LM741
stage is used to control the volume of the broadcasting melody. The oscillator stage of
Wireless Charger the circuit is built with the 2N3904 transistor. L1 is equal to 2 turns of # 24 enameled Moisture Sensor Alarm
wire wound on 5mm form. TR is equal to 1 to 30 PF trimmer capacitor. For antenna use Simple Water Level
a 12 inch piece of wire or for maximum range use 30 inch wire and keep it vertical. Sensor Or Liquid Level
Detector
Wireless Charger
After building the circuit first make the circuit ready to perform by adjusting the 200K
Relay Circuit
variable resistor on the place where it will activate the circuit on the room temperature.
Once the circuit is activated and broadcasting the melody then switch ON your FM
receiver and set it on a blank spot after 100 MHZ and place it 5 to 10 meters away from
the transmitter circuit. Now slightly adjust the trimmer of the transmitter until you hear
any melody signal on your FM radio. Once you have detected the signal on your FM
radio the circuit will ready to perform. Now adjust the 200K variable resistor again to
make the circuit activate on your desired level of heat.
Privacy Policy
Copyright 2013 © CircuitDiagram.Org. All rights reserved.