Beruflich Dokumente
Kultur Dokumente
+
BLAZE 12V LED Tape Light
®
™
-
a division of elemental LED
+
SPECIFICATION SHEET
-
+
-
+
ACTUAL SIZE
-
+
-
+
-
+
-
+
-
+
Our most popular tape light in our portfolio, BLAZE 12V LED Tape Light FEATURES
-
is perfect for accent and task lighting with its vast selection of color • Most popular lighting solution
temperatures and exceptional lumen output. BLAZE is field-cuttable • Closet-safe
+
-
every 1 inch and suitable for installation in a clothes-closet. • Wide CCT collection
+
-
DI-12V-BL28-80** 16.4 ft. (16.4 ft. spools) / 27 ft. (100 ft. &
2850K 82 250 Max. Run
400 ft. spools)
DI-12V-BL30-80** 3000K 81 286 Dimensions 0.31 x 0.1 in. (W x H)
DI-12V-BL33-80** 3300K 81 299 Field Cuttable ~ 1 in.
Item #
Project
1. Epistar 3528 SMD Chip binning ranges: (2400K 80+ CRI: 2300-2425K), (2700K 80+ CRI: 2580-2725K), (2850K 80+ CRI: 2725-2870K), (3000K 80+ CRI: 2870-3045K), (3300K 80+
CRI: 3220-3465K), (3500K 80+ CRI: 3465-3710K), (3800K 80+ CRI: 3710-3985K), (4200K 80+ CRI: 3985-4260K), (4400K 80+ CRI: 4260-4503K), (5000K 80+ CRI: 4745-5028K),
(6300K 80+ CRI: 6020-6530K).
2. LED chips have a luminous flux range with a tolerance of +/- 5%.
3. Actual efficacy value is dependent to specified LED driver (power supply). An estimated efficacy value can be calculated as follows: Lumen value divided by average power
consumption per foot.
4. Ideal tape application temperature range is 70°F to 100°F (21°C to38°C). Initial tape application to surfaces at temperatures below 50°F (10°C) is not recommended because the
adhesive becomes too firm to adhere readily. However, once properly applied, low temperature holding is generally satisfactory.
5. Each maximum run requires a dedicated power feed from the driver. Do not extend beyond the recommended maximum run length. 100 ft. spools have been redesigned to allow
for a longer maximum run. A marking of '1195C' on the product label will indicate that the product has a longer maximum run.
6. Wire leads and accessories are not rated for in-wall installation unless otherwise noted. Attached wire leads and connections are field-cuttable.
7. Do not install product in an environment outside the listed ambient temperature. Exceeding the maximum ambient temperature may damage LED chips, reduce the total lamp
life, lumen output, and/or adversely impact color consistency.
8. Operating temperature is measured according to the minimum and maximum ambient temperature environment.
9. Do not install in environment where LED chips are exposed to direct sunlight as damage to the phosphor will occur. NEC definition of damp location: Locations protected from
weather and not subject to saturation with water or other liquids but subject to moderate degrees of moisture. Examples of such locations include partially protected locations
under canopies, marquees, roofed open porches, and like locations, and interior locations subject to moderate degrees of moisture, such as some basements, some barns, and
some cold-storage warehouses.
+
−
-
BLAZE ™
E469769
~ 1 in.
(25mm)
.33 in. (8.3mm)
®
3 ft. (914mm) 20/2 AWG UL 2464 Wire
BLAZE ™
Ø .19 in. (5mm)
E469769
+
−
Leads:
Red (+) W .31 in. H .1 in.
Black (-) (8mm) (2.5mm)
POLAR CANDELA DISTRIBUTION GRAPH POLAR CANDELA DISTRIBUTION GRAPH POLAR CANDELA DISTRIBUTION GRAPH
180 150 120 180 150 120 180 150 120
ACROSS ACROSS
ACROSS
45 45
45
ALONG ALONG
ALONG
90 90 90
30 40 30
60 60 60
60 80 60
90 120 90
0 30 0 30 0 30
POLAR CANDELA DISTRIBUTION GRAPH POLAR CANDELA DISTRIBUTION GRAPH POLAR CANDELA DISTRIBUTION GRAPH
180 150 120 180 150 120 180 150 120
ACROSS ACROSS
ACROSS
45 45
45
ALONG ALONG
ALONG
90 90 90
40 30 40
60 60 60
80 60 80
120 90 120
0 30 0 30 0 30
90 90 90
40 30 4
60 60 60
80 60 8
120 90 12
0 30 0 30 0 30
ANGLE ALONG 22.5 45 67.5 ACROSS ANGLE ALONG 22.5 45 67.5 ACROSS ANGLE ALONG 22.5 45 67.5 ACROSS
0 106 106 106 106 106 0 91 91 91 91 91 0 13 13 13 13 13
5 103 106 107 106 107 5 88 92 92 92 92 5 13 13 13 13 13
10 101 104 105 105 105 10 87 90 91 91 91 10 13 13 13 13 13
15 100 103 104 103 103 15 85 89 90 89 89 15 12 13 13 13 13
20 97 100 101 100 101 20 83 87 87 87 87 20 12 12 12 12 12
25 94 97 97 97 97 25 80 84 84 84 84 25 12 12 12 12 12
30 89 92 93 92 92 30 77 80 80 80 80 30 11 11 12 11 11
35 84 87 88 87 87 35 73 76 76 76 76 35 11 11 11 11 11
40 78 81 81 81 81 40 68 71 71 71 71 40 10 10 10 10 10
45 72 74 75 74 74 45 62 65 65 65 65 45 10 10 10 10 10
50 65 67 67 67 67 50 56 59 59 59 59 50 9 9 9 9 9
55 57 59 59 59 59 55 49 52 52 52 52 55 8 8 8 8 8
60 49 50 50 50 50 60 42 44 44 44 44 60 7 7 7 7 7
65 40 41 41 41 41 65 35 36 36 36 36 65 6 6 6 6 6
70 31 31 31 31 31 70 26 28 28 28 28 70 4 4 4 4 4
75 21 22 22 22 21 75 18 19 19 19 19 75 3 3 3 3 3
80 12 13 13 13 12 80 10 11 11 11 11 80 2 2 2 2 2
85 5 6 5 5 5 85 4 4 4 4 4 85 1 1 1 1 1
90 0 0 0 0 0 90 0 0 0 0 0 90 0 0 0 0 0
ZONAL LUMENS AND PERCENTAGES ZONAL LUMENS AND PERCENTAGES ZONAL LUMENS AND PERCENTAGES
ZONE LUMENS % LUMINAIRE ZONE LUMENS % LUMINAIRE ZONE LUMENS % LUMINAIRE
0-30 84 26.36 0-30 72 26.22 0-30 10 24.90
0-40 138 43.48 0-40 119 43.33 0-40 17 41.45
0-60 247 78.07 0-60 215 78.10 0-60 31 76.45
0-90 317 100.00 0-90 276 100.00 0-90 41 100.00
40-90 179 56.52 40-90 156 56.67 40-90 24 58.55
60-90 69 21.93 60-90 60 21.90 60-90 10 23.55
90-180 0 0.00 90-180 0 0.00 90-180 0 0.00
0-180 317 100.00 0-180 276 100.00 0-180 41 100.00
Cone Of Light Tabulation Cone Of Light Tabulation Cone Of Light Tabulation
Mounting Height Footcandles at Mounting Height Footcandles at Mounting Height Footcandles at
Diameter (Feet) Diameter (Feet) Diameter (Feet)
(Feet) Nadir (Feet) Nadir (Feet) Nadir
4.00 6.66 5.14 4.00 5.74 5.17 4.00 0.799 5.28
6.00 2.96 7.71 6.00 2.55 7.76 6.00 0.355 7.93
8.00 1.66 10.3 8.00 1.43 10.3 8.00 0.200 10.6
10.0 1.07 12.9 10.0 0.918 12.9 10.0 0.128 13.2
12.0 0.740 15.4 12.0 0.637 15.5 12.0 0.0888 15.9
14.0 0.544 18.0 14.0 0.468 18.1 14.0 0.0652 18.5
16.0 0.416 20.6 16.0 0.359 20.7 16.0 0.0500 21.1
90 90
18 10
60 60
36 20
54 30
0 30 0 30
diode led
®