Beruflich Dokumente
Kultur Dokumente
4 doors/exits
5 doors/exits
6 doors/exits
7 doors/exits
2. Maximum takeoff weight
cabin air regulating system and cabin air pressure regulating system.
cabin air regulating system, cabin air pressure regulating system, fan.
cabin air regulating system, cabin air pressure regulating system, fan, and ventilation system.
Right,
15
17
20
22
8. The hot container is heated by __________ power onboard the aircraft.
220 V AC
115 V DC
220 V DC
In the air, it is not recommended for crew member to reset a tripped circuit breaker, but on ground
is ok.
Yes, we can but we have to wait to cool down 2 minutes, and can reset only one.
In the air, it is recommended for crew member to reset a tripped circuit breaker, but it is not
recommended on ground.
We can reset one time both in the air and on the ground.
10. The electric cup is place in the ________ part of the galley. It has a capacity of ___________.
Electric cup internal element damage, Repair or replace electric cup
12. What cause Water heater inoperative? How to troubleshoot it?
Repair or replace water heater, Connect the plug again properly
13. How many air vent in lavatory ventilation?
3 metres
2 decimetres
16. Above the aircraft entry door, over the galley entrance, on the lavatory ceiling are installed with three
___________, which are controlled by the entry lighting switches on the cabin attendant control panel.
1
2
3
4
19. Regarding Clean Water Tank, The clean water tank has a capacity of_______________.
1 emergency escape rope, in a stowage adjacent to the cabin emergency exit.
1 quick-donning oxygen masks, accessory to the fixed cockpit oxygen system, one in each mask
stowage beside LH or RH pilot seat.
2 flashlights, on the front panel of avionics rack behind RH pilot seat.
4 life vests, three in the life vest stowage on the avionics rack, one in the life vest stowage beneath
the observer seat behind RH pilot seat.
22. Regarding Cabin Emergency Equipment, choose a sentence which is not correct.
2 pairs of smoke goggles, in the seat pockets on the back of the left and right pilot seats.
2 flashlights, on the front panel of avionics rack behind LH pilot seat.
1 loudspeaker;
1 portable fire extinguisher, on the left avionics rack in the cockpit.
24. Cautions for Operating Portable Oxygen Cylinder (1) No smoking is allowed within ___________
when it is in use.
3 m
4 m
5 m
6 m
25. Regarding Smoke hood, it is equipped with a chemical oxygen generator which may provide oxygen
supply for at least____________minutes.
15
20
30
45
26. Regarding Smoke Hood, the oxygen capacity of smoke hood is________.
35 L
39 L
45 L
113 L
27. How many type of the Emergency?
1
2
3
4
28. All individuals designated as ABPs should receive the following briefing about their responsibilities.
General directives for ABPs, Directives for ABPs at door exits, To perform a final cabin check in a
planned emergency.
General directives for ABPs, Directives for ABPs at door exits, Evacuation command for land
emergency.
General directives for ABPs, Directives for ABPs at door exits, Directives for ABPs at window
exits.
General directives for ABPs, Directives for ABPs at door exits, To prepare yourself for a planned
emergency.
29. If it is not safe to open forward exit emergency door, what is standard command to be used:
1,2,6,7
2,3,4,5
2,5,6,7
1,2,5,7
2. exam 19/08/2020 vadsana keoduangkhamsouk