Beruflich Dokumente
Kultur Dokumente
html
2019 Latest certbus 300-101 PDF and VCE dumps Download
300-101Q&As
Implementing Cisco IP Routing
Free Download Real Questions & Answers PDF and VCE file from:
https://www.certbus.com/300-101.html
QUESTION 1
A network administrator notices that the BGP state drops and logs are generated for missing BGP hello keepalives.
What is the potential problem?
D. MTU mismatch
Correct Answer: D
BGP neighbors form; however, at the time of prefix exchange, the BGP state drops and the logs generate missing BGP
hello keepalives or the other peer terminates the session.
*The interface MTU on both routers match, but the Layer 2 domain over which the BGP session is formed does not
match.
*Path MTU discovery determined the incorrect max datasize for the TCP BGP session. *The BGP Path Maximum
Transmission Unit Discovery (PMTUD) could be failing due to PMTUD ICMP packets blocked (firewal or ACL) http://
www.cisco.com/c/en/us/support/docs/ip/border-gateway-protocol-bgp/116377-troubleshoot-bgp-mtu.html
QUESTION 2
What show command is used here? TCB Local Address Foreign Address (state) 6523A4FC 10.1.25.3.11000
10.1.25.3.23 ESTAB 65239A84 10.1.25.3.23 10.1.25.3.11000 ESTAB 653FCBBC *.1723 *.* LISTEN
Correct Answer: C
QUESTION 3
Refer to the exhibit, Which statement is correct regarding the operation of NAT-PT between the IPv4 and IPv6 networks
shown?
B. The source IPv6 host can use DNS to determine the IPv6-to-IPv4 address mapping.
Correct Answer: B
QUESTION 4
What does an Cisco router use as default username for CHAP authentication?
A. chap
B. Hostname
C. cisco
D. ppp
Correct Answer: B
QUESTION 5
Which two types of threshold can you configure for tracking objects? (Choose Two)
A. percentage
B. MTU
C. bandwidth
D. weight
E. delay
F. administrative distance
Correct Answer: AD
QUESTION 6
Which BGP option is required when load sharing over multiple equal-bandwidth parallel links from a single CE router to
a single ISP router over eBGP?
A. eBGP Multipath
B. eBGP Multihop
C. BGP Synchronization
D. Public AS numbers
Correct Answer: B
QUESTION 7
Which two commands must be configured on a DMVPN hub to enable phase 3? (Choose two)
A. ip nhrp interest
B. ip nhrp redirect
C. ip nhrp shortcut
D. ip nw id
E. ip nhrp map
F. ip redirects
Correct Answer: BC
QUESTION 8
Which two actions must you perform to enable and use window scaling on a router?(Choose two.)
Correct Answer: AB
The TCP Window Scaling feature adds support for the Window Scaling option in RFC 1323, TCP Extensions for High
Performance. A larger window size is recommended to improve TCP performance in network paths with large
bandwidth-delay product characteristics that are called Long Fat Networks (LFNs). The TCP Window Scaling
enhancement provides that support. The window scaling extension in Cisco IOS software expands the definition of the
TCP window to 32 bits and then uses a scale factor to carry this 32-bit value in the 16-bit window field of the TCP
header. The window size can increase to a scale factor of 14. Typical applications use a scale factor of 3 when
deployed in LFNs. The TCP Window Scaling feature complies with RFC 1323. The larger scalable window size will
allow TCP to perform better over LFNs. Use the ip tcp window-size command in global configuration mode to configure
the TCP window size. In order for this to work, the remote host must also support this feature and its window size must
be increased. Reference: http://www.cisco.com/c/en/us/td/docs/ios-xml/ios/ipapp/configuration/12-4t/iap-12-4t-book/
iaptcp. html#GUID-BD998AC6-F128-47DD-B5F7-B226546D4B08
QUESTION 9
A. Inside local, this list will be translated to this subnet (which is pool)
B. https://www.CertBus.com/300-101.html
C. https://www.CertBus.com/300-101.html
D. https://www.CertBus.com/300-101.html
Correct Answer: A
QUESTION 10
Choose best IP SLA deployment cycle that reduce deployment ( Choose Three)
D. Quality results.
QUESTION 11
Which two types of threshold are configured for tracking object? (Choose two)
A. delay
B. percentage
C. bandwidth
D. administrative distance
E. weight
Correct Answer: BE
QUESTION 12
After reviewing to EVN configuration, a network administrator notices that a predefined BVN, which is known as" vnet
global" was configured. What is the purpose of this EVM?
C. It refer to the global routing context and corresponds to the default RIB.
D. t safeguard the virtual network that is preconfigured to avoid mismatched routing instances.
Correct Answer: C
QUESTION 13
A. NAT64
B. 64 NAT
C. NAT-PT64
D. 64NAT-PT
Correct Answer: A
QUESTION 14
An engineer is asked to monitor the availability of the next-hop IP address of 172.16.201.25 every 3 seconds using an
ICMP echo packet via an ICMP echo probe. Which two commands accomplish this task? (Choose two.)
B. router(config-ip-sla-echo)#timeout 3
D. router(config-ip-sla-echo)#frequency 3
F. router(config-ip-sla-echo)#threshold 3
Correct Answer: AD
QUESTION 15
Which two routing protocols are supported by Easy Virtual Network? (Choose two.)
A. RIPv2
B. OSPFV2
C. BGP
D. EIGRP
E. IS-IS
Correct Answer: BD
QUESTION 16
Consider this scenario. TCP traffic is blocked on port 547 between a DHCPv6 relay agent and a DHCPv6 server that is
configured for prefix delegation.
Which two outcomes will result when the relay agent is rebooted? (Choose two)
Correct Answer: AE
The DHCPv6 use UDP protocol for distribution IPv6 addresses and prefixes. The routers dont need in the DHCPv6
prefixes from DHCPv6 server, its work for network administrator. DHCPv6 messages are exchanged over UDP port 546
and
547. Clients listen for DHCP messages on UDP port 546 while servers and relay agents listen for DHCP messages on
UDP port 547.
QUESTION 17
A. The device that sends the stream is forced to hold data in the buffer for a longer period of time.
C. The device that receives the stream is forced to hold data in the buffer for a longer period of time.
D. The devices at each end of the stream are forced to negotiate a smaller window size.
Correct Answer: C
QUESTION 18
Correct Answer: AB
QUESTION 19
Correct Answer:
QUESTION 20
To enable BGP tunneling over an IPv4 backbone, the IPv4 address 192.168.30.1 is converted into a valid IPv6 address.
Which three IPv6 addresses are acceptable formats for the IPv4 address? (Choose three.)
A. 192.168.30.1:0:0:0:0:0:0
B. 0:0:0:0:0:0:192.168.30.1
C. ::192.168.30.1
D. C0A8:1E01::
E. 192.168.30.1::
F. ::C0A8:1E01
QUESTION 21
Which are new LSA types in OSPF for IPv6 (OSPFv3)? (Choose two)
A. LSA Type 8
B. LSA Type 9
Correct Answer: AB
QUESTION 22
Using the rules for IPv6 addressing, how can the address 2031:0000:240F:0000:0000:09C0:123A:121B be rewritten?
A. 2031:0:240F::09C0:123A:121B
B. 2031::240F::09C0:123A:121B
C. 2031::240F:9C0::123A:121B
D. 2031::240F:::09C0:123A:121B
Correct Answer: A
QUESTION 23
Refer to the exhibit R1 is configured with VRF-Lite and can ping R2. R2 is fully configured, but it has no active EIGRP
neighbors in vrf Yellow. If the configuration of R2 is complete, then which issue prevents the EIGRP 100 neighbor
relationship in vrf Yellow from forming?
A. The no auto-summary command is preventing the EIGRP neighbor relationship from forming
B. There is a Layer 1 issue that prevents the EIGRP neighbor relationship from forming
D. EIGRP 100 network 192 168 1 0/24 is configured in the global routing table on R1
Correct Answer: D
QUESTION 24
A. EIGRP
B. RIP2
C. OSPF
D. BGP
E. ISIS
QUESTION 25
C. host and routers inside a 6to4 site will need a special code
Correct Answer: D
QUESTION 26
if you run the command auto-cost reference-bandwidth 10000 one of the router in the network, what will happen?
Correct Answer: B
QUESTION 27
Refer to the exhibit, In the network diagram, Area 1 is defined as a stub area. Because redistribution is not allowed in
the stub area, EIGRP routes cannot be propagated into the OSPF domain. How does defining area 1 as a not-so-stubby
area (NSSA) make it possible to inject EIGRP routes into the OSPF NSSA domain?
C. by creating a link between the EIGRP domain and the RIP domain, and redistributing EIGRP into RIP
D. by manually changing the routing metric of EIGRP so that it matches the routing metric of OSPF
Correct Answer: B
QUESTION 28
Which two conditions can cause BGP neighbor establishment to fail? (Choose Two)
A. There is an access list blocking all TCP traffic between the two BGP neighbors
C. BGP synchronization is enabled in a transit autonomous system with fully-meshed IBGP neighbors.
D. The BGP update interval is different between the two BGP neighbors
E. The BGP neighbor is referencing an incorrect autonomous system number in its neighbor statement.
Correct Answer: AE
QUESTION 29
Which logical operator do you use to ensure that the status of an object track list is up only when all configured objects
are up?
A. and
B. or
C. true
D. xor
Correct Answer: A
QUESTION 30
This configuration is incorrect because the MTU must match the ppp-max-payload
A. That is defined.
B. This configuration is incorrect because the dialer interface number must be the same as the dialer pool number
Correct Answer: D
QUESTION 31
A network engineer is enabling RIPng on a new customer link Under which configuration mode is RIPng enabled?
A. Global
B. Router
C. Interface
D. IPv6
Correct Answer: C
QUESTION 32
what are the two correct statements about enable secret and enable password command (choose two)
A. the enable password command has a strong encryption algorithm than enable secret
B. if both commands are missing from the global configuration, vty lines use the console password
C. the enable secret command is backwards compatible with more versions of IOS
D. the enable secret and enable password commands must be used together
Correct Answer: CE
QUESTION 33
C. when the packet\\'s destination has load-balanced entries in the route table
D. when the packet\\'s ingress and egress interface are the same
Correct Answer: D
QUESTION 34
Refer to the following configuration command. router (config-line)# ntp master 10 Which statement about this command
is true?
A. The router acts as an authoritative NTP clock and allows only 10 NTP client connections.
C. The router acts as an authoritative NTP clock with a priority number of 10.
Correct Answer: B
QUESTION 35
Correct Answer: C
QUESTION 36
Which statement describes the difference between a manually configured IPv6 in IPv4 tunnel versus an automatic 6to4
tunnel?
C. A manually configured IPv6 in IPv4 tunnel does not require dual-stack (IPv4 and IPv6) routers at the tunnel
endpoints.
D. An automatic 6to4 tunnel does not require dual-stack (IPv4 and IPv6) routers at the tunnel endpoints
Correct Answer: B
QUESTION 37
Which two OSPF area types filter type 4 and type 5 LSAs?
A. Level 2
B. not-so-stubby
C. totally stubby
D. Level 1
E. stub
F. Level 1 - Level2
Correct Answer: E
QUESTION 38
When an IPv6 enabled host boots, it sends a router solicitation (RS) message. An IPv6 router responds with a router
advertisement (RA). Which two items are contained in the RA? (Choose two.)
D. keepalive timers
Correct Answer: BC
QUESTION 39
Which Cisco IOS VPN technology leverages IPsec, mGRE, dynamic routing protocol, NHRP, and Cisco Express
Forwarding?
A. FlexVPN
B. DMVPN
C. GETVPN
Correct Answer: B
Dynamic Multipoint Virtual Private Network (DMVPN) is a dynamic tunneling form of a virtual private network (VPN)
supported on Cisco IOS-based routers and Unix-like Operating Systems based on the standard protocols, GRE, NHRP
and
VPN network without having to pre-configure (static) all possible tunnel end-point peers, including Ipsec (Internet
Protocol Security) and ISAKMP (Internet Security Association and Key Management Protocol) peers. DMVPN is initially
the hubs (VPN headends) on the spokes, no change in the configuration on the hub is required to accept new spokes.
Using this initial hub-and-spoke network, tunnels between spokes can be dynamically built on demand (dynamic-mesh)
without additional configuration on the hubs or spokes. This dynamic-mesh capability alleviates the need for any load on
the hub to route data between the spoke networks.
Reference: http://en.wikipedia.org/wiki/Dynamic_Multipoint_Virtual_Private_Network
QUESTION 40
Which two packet type can an EIGRP router send when a route goes into the Active state ?(Choose two)
A. update
B. request
C. hello
D. query
E. reply
Correct Answer: DE
To Read the Whole Q&As, please purchase the Complete Version from Our website.
We provide exam PDF and VCE of Cisco, Microsoft, IBM, CompTIA, Oracle and other IT Certifications.
You can view Vendor list of All Certification Exams offered:
https://www.certbus.com/allproducts
Need Help
Please provide as much detail as possible so we can best assist you.
To update a previously submitted ticket:
Any charges made through this site will appear as Global Simulators Limited.
All trademarks are the property of their respective owners.
Copyright © certbus, All Rights Reserved.