Beruflich Dokumente
Kultur Dokumente
N Div =10
7. Again do the above step up to picked lines (or) directly select the vertical line in
figure → Apply → N Div =5 → ok.
N Div=5
N Div =10
8. Mesh → Areas → mapped → ¾ sides → click on figure → click ok.
N Div=5
N Div= 10
9. Plot on menu → layered elements → click on figure → enter start and end of
layers data.
10. Plot → layered elements next plot → elements.
11. Solution → define loads → apply → structural → displacement → symmetry
boundary conditions → on lines → Horizontal, vertical → apply.
Case 3:- 1 0
2 90
3 90 NL
4 0i
18. General post processor → Element table → define table → Add → By sequence
numbers → SMISC 9 → Apply → Add → by sequence number → SMISC13 →
Apply → close → plot results → contour plot → element table → select
SMISC9,SMISC13, → ok.
This is for case (1)
Repeat step 18 for case (2) & case (3) also for getting the interlaminar stresses.
The layers are arranged like this
0 LAYER 1
30 LAYER 2
60 LAYER 3
90 LAYER 4
90 L5
60 L6
30 L7
0 L8