Beruflich Dokumente
Kultur Dokumente
I/O signal monitor The status of I/O signals can be monitored on the LCD. Sensor proof pressure 5 MPa
Operating temp:5 to 40 ℃
■OPTIONAL SPECIFICATIONS Ambient temperature Storage temp:−20 to 60 ℃
Regulator Symbol Description Ambient humidity 80% RH or less, no condensation
The built-in control valve for the
Automatic Leak Leak Master enables the tester to
Weight Approx. 12 kg
J automatically measure leak coefficient,
Master calibration Serial ID format
K(Ve)and perform K(Ve)checks.
communication (default) Leak rate data and test parameters
port (fixed length)are output.
A pneumatic circuit incorporating an I format
Intelligent2 A2 isobaric circuit which reduces the (RS-232C)
pneumatic circuit measurement time for large-volume parts. Output T format Leak rate data (fixed length) is output.
format is
Small-volume pneumatic For volumes of 50 mL or less and selectable Printer format Leak rate data and a list of test parameters are output.
A01 low leak rates.
circuit
DB-37P male connector
External pressure detection method A method for detecting leaks Control I/O port NPN open-collector output, photocoupler input
C
(secondary pressure system) on the leaking side.
Filter regulator for pilot pressure, connectors for
DP range : ±10 kPa Standard accessories interface ports, power cord (125 V, 3 m),
Wide-range display D4 Minimum reading : 1 Pa
and components Quick mounting brackets,
Inspection record, and operation manual
Prevents the stop valves
Stop valve check switch W on the WORK and MASTER ports 5 m power cord, high-voltage power cord
from being left open. Optional accessories (withstand voltage: 250 V AC max, 2 m),
fitting for CAL port and traceability certificate
PNP open-collector output S The control I/O port has a PNP output.
BAL
DET
END
Leak Master
LS-1822A
LM - 1B series 7 8 9
4 5 6
CAL. 1 2 3
Leak Calibrator LC and QLC series
MASTER WORK
0 ENTER
NOTE: This catalog reflects information available as of April 2006. Specifications are subject to change without notice.