Beruflich Dokumente
Kultur Dokumente
Garment Steamer
water or other liquids. refilling water tank.
4. Never yank cord to disconnect from • Do not allow to be used as a toy. Close
outlet; instead, grasp plug and pull to attention is necessary when used by or near
disconnect. children, pets or plants.
Model SC620 5. Do not allow cord to touch hot surfaces. • Use only as described in this manual. Use
Let the system cool completely before only manufacturer’s recommended
putting away or opening water tank accessories.
(removing the safety cap). Wrap cord • Do not pull cord, use cord as a handle, close
loosely around system when storing. a door on cord, or pull cord around sharp
6. Always disconnect system from electrical edges or corners. Keep cord away from
outlet when filling with water or emptying heated surfaces.
and when not in use. Always turn the • Do not use extension cords or outlets with
safety cap slowly when opening the water inadequate current carrying capacity.
tank . This will allow any remaining steam • Turn off all controls as applicable before
to escape gradually. unplugging from electrical outlet.
7. Do not operate the system with a damaged • Do not unplug by pulling on cord. To unplug,
cord or plug, or if the appliance or any other grasp the plug, not the cord.
part of the system has been dropped or • Do not handle plug or steam cleaner with wet
damaged. To avoid the risk of electric hands or operate without shoes.
shock, do not disassemble or attempt to • Do not put any objects into openings. Do not
repair the Garment Steamer. Return the use with any opening blocked.
system to EURO-PRO Corporation (see • Store your appliance indoors in a cool, dry
warranty) for examination and repair. area.
Incorrect re-assembly or repair can cause a • Keep your work area well lit.
risk of electrical shock or injury to persons • When in use, never turn the appliance over
when the Garment Steamer is used. or on its side. Never direct steam towards
8. Close supervision is necessary for any people, animals or plants.
appliance being used by or near children. • Do not immerse the steam cleaner into water
Do not leave the system unattended while or other liquids. Always unplug the power
connected. cord from the electrical socket when filling the
9. Burns can occur from touching hot metal steam cleaner.
parts, hot water or steam. Use caution • Do NOT add cleaning solutions, scented
when draining unit after use as there may perfumes, oils or any other chemicals to
be hot water in the unit. Never direct steam the water used in this appliance as this
at any person. The steam is very hot and may damage the unit or make it unsafe for
can cause burns. use. Use tap water or distilled/purified
(<5
352
2 10. Do not operate in the presence of water if the tap water in your area is very hard.
explosive and/or flammable fumes. • Always allow the appliance to cool
11. This appliance is intended only for completely for at least 30 minutes before
household use. Follow all user instructions storing.
in this manual. • Only hang the steamer hose on the supplied
12. Never use any chemicals or substance hanger rod.
other than tap water in the machine. Use of • Always disconnect the unit from electrical
chemicals may damage the machine. Use outlet before filing with or removing water. Be
For information or assistance: of chemicals will automatically void your careful to AVOID spilling excess water into the
warranty. reservoir when removing or placing the
13. Be careful. Burns can occur from touching reservoir bottle into the reservoir.
EURO-PRO Corporation HOT METAL PARTS, HOT WATER OR
178 West Service Rd. STEAM.
Champlain, NY 12919
1-800-798-7398 SAVE THESE INSTRUCTIONS
www.euro-pro.com For Household Use Only
1 Rev. 0402A
2
3
Technical Specifications
Voltage: 120V~ 60Hz.
Power: 1500 Watts
Water Capacity: 150 US Fl. Oz. (4.5 liters)
Max. Steam Temperature: 220°F
4
5
Step 2: Assembling Steamer Hose 3. To attach the garment brush Preparing Garment 3. After filling the water bottle, close the
(marked E) onto the diffuser Steamer for Use cap clockwise. (See fig. 8)
1. Insert end of steamer hose with the (marked F), place the two hinges
long tube bushing (marked A) into at the back of the garment brush CAUTION: Before filling the water
the adapter hole (marked B) on the (see fig. 6) into the two open tabs tank, check to make sure that the water
unit. Rotate hose 90° to lock in place. that are at the back of the steam tank sits securely in the unit before
(See fig. 4) diffuser. Swing the garment brush proceeding.
up against the bottom of the steam
diffuser until the locking tab engages. Step 1: Preparing for Use
1. Unwind the power cord.
2. Check the wheels to see that they
swivel and roll properly.
3. Set the unit on the floor and remove
the water tank. Check for sediment or
Fig. 8
build-up in the base of the unit reservoir
and water tank. Follow steps for
cleaning and storing the unit if water 4. Replace the water tank into the unit.
was accidentally left in the water tank (See fig. 9)
during storage of the unit on page 8.
4. Place the steamer hose with the
nozzle end up on the garment
hook.(See fig. 7)
Fig. 4
2. To attach the steam diffuser, grasp Fig. 6
steam diffuser in one hand and the hose
in the other. Depress the locking button
on the hose end until the locking button
engages the hole in the steam diffuser. Fig. 7
A slight rotation of the steam diffuser Fig. 9
may help engage the locking button. 5. Make sure that the hose is and
(See fig. 5) unencumbered and that the unit rolls Step 3: Using Garment Steamer
freely.
Note: It will make pressing easier if
Step 2: Filling the Water Bottle there are few creases in the laundry
that needs pressing. To avoid excess
IMPORTANT: Do NOT add cleaning creasing, shake each item out before
solutions, scented perfumes, oils or any placing in a drier or hanging to dry.
other chemicals to the water used in this 1. Always check that the On/Off
appliance. Use tap water or
switch is in the “Off” position.
distilled/purified water if the tap water
in your area is very hard. 2. Plug appliance into electrical
outlet.
1. Always make sure that the 3. Push the “On/Off” switch to the
appliance is unplugged before filling “On” position. The power “On”
the water bottle. light (green) will come on.
2. To open the cap on the water bottle,
turn counterclockwise. Fill the water
bottle with tap water or
Fig. 5 distilled/purified water if your tap
water in your are is very hard.
(See fig. 8)
6 7
Step 3: Using Garment Steamer cont. 3. After the unit has cooled down,
If steamer hose gurgles during use: If the steamer stops producing
• This is a normal result of steam then starts again:
4. Once steam is being released remove the water tank and empty
condensation collecting inside the • You may wish to examine the
from the steam diffuser with the the water remaining in the water
hose. Simply lift the steam inside of the reservoir. The most
garment brush attached, hold tank in a sink. Rinse the water
diffuser/handgrip upward until the common reason for this effect is
the handgrip with the nozzle tank and set aside to dry.
hose is extended to its full height. the accumulation of sediment from
facing upward and begin steaming 4. Disconnect the steamer hose from
• The gurgling will disappear when mineral laden water.
from the bottom of the garment the unit and set aside.
the excess moisture inside the • Clean the sediment from inside the
allowing the escaping steam to rise 5. Disconnect the garment rod
hose has had a chance to drain water reservoir following the
inside and out side removing the entirely from the unit.
back into the base. instructions on page 8.
wrinkles. (See fig. 10) 6. Lift the unit over a sink and empty
5. After a few seconds, remove what water has remained in the
the steam diffuser from the water reservoir. Wash the interior
garment and smooth the garment of the reservoir by flushing with TROUBLE SHOOTING
with your free hand and check to some tap water. This will dislodge
see if more steam is required. any sediment that has Below is a chart detailing the most common problems, their causes and solutions.
Note: Do NOT leave the steam accumulated. Drain this water
diffuser in one area for a long period of from the reservoir and dry.
time because the garment will get wet. 7. Reattach the garment rod and
steamer hose or store separately. PROBLEM CAUSE SOLUTION
8. Once the unit has dried, you may
store in a cool, dry place.
1. Steamer is not
Important: If you wish to leave your plugged into 1. Plug power cord into
steamer ready for use on a daily electrical outlet. electrical outlet.
basis, simply leave the water bottle Steamer Does
2. The water tank is 2. Refill water tank
filled and in place. While you do not Not Get Hot
empty and the following instructions on
have to empty the water bottle each reservoir has page 7.
day, you should periodically empty the
old water out of the steamer and drained.
remove any sediment that has
accumulated. We recommend that
Fig. 10 you empty and clean it once a month 1. Refill the water tank
1. Water level is too
depending on amount of use and No Steam following instructions on
Important: For heavier fabrics, you low.
water mineral content in your area. page 7.
may need to use repeated
applications. Avoid heating a single Safety Thermostat
area with steam for a prolonged
period. Check the garment to see Should your unit run out of water, the safety 1. Hold the steamer hose
that the process is succeeding. thermostat will trip in order to prevent Water Drips 1. Condensation has upright fully extended
damage to the unit. To reset, unplug unit, From The formed inside the and allow excess
Step 4: Maintenance & Storage refill water tank, re-plug unit into wall outlet Steam Diffuser steamer hose. moisture to drain back
and depress On/Off switch. This will reset in the water reservoir.
1. Turn the unit “Off”. The power on the thermal protector circuit.
light (green) will go out. Disconnect
the plug from the electrical outlet.
2. Wait for garment steamer to cool
down completely for at least 30
minutes before draining the water
tank.
8 9
PURCHASER___________________________________________________________
DEALER ______________________________________________________________
*important: Carefully pack item to avoid damage in shipping. Be sure to attach tag to item before packing
with your name, complete address and phone number with note giving purchase information, model
number and what you believe is the problem with item. We recommend you insure the package (as
damage in shipping is not covered by your warranty). Mark the outside of your package “ATTENTION
CUSTOMER SERVICE”.
RETURN TO: EURO-PRO Corporation, 178 WEST SERVICE RD., CHAMPLAIN, N.Y. 12919
PURCHASER: ……………………………………..…………………………………………………
ADDRESS: ………………………………………...……………………………………………….
Printed in China