Beruflich Dokumente
Kultur Dokumente
Specifications are subject to change without notice. These products are not intended for use as critical components in life support or nuclear systems.
ODX-1300
1300 VA DC/AC
INPUT
Input voltage range -30, +25% Vin nom
Maximum input ripple 5% Vin nom (Vrms, 100Hz)
Inrush current <25A
Polarity protection By diode
OUTPUT
Nominal output voltage (Von) See table (ordering codes)
150 … 250V (models of 250V output) via RS-232
Output voltage range
200 … 400V (models of 400V output) via RS-232
Output frequency range 5…60Hz via RS-232
Load regulation < 4%
Line regulation < 2% Vin -25% … +25%, < 10% Vin -30% … +30%
Output wave distortion THD < 3% (average of 16 samples)
Output HF ripple < 2.5%
ENVIRONMENTAL
Storage temperature -25 … 85°C
Operating temperature:
Full load -25 … 55°C (EN50155 OT1)
62.5% load -25 … 70°C (EN50155 OT3)
25% load -25 … 85°C (EN50155 OT5)
Relative humidity without condensation 5 … 95%
Cooling Controlled internal fan
MTBF (MIL-HDBK-217-E; Gb, 25°C) 100.000 h
EMC
Immunity according EN61000-6-2, EN50121-3-2
Emissions according EN61000-6-4, EN50121-3-2
SAFETY
Dielectric strength: Input /output 3000 Vrms / 50Hz / 1min
Dielectric strength: Output / ground 1500 Vrms / 50Hz / 1min
Dielectric strength: Input / ground 1500 Vrms / 50Hz / 1min
Safety according to EN60950-1, EN62368-1
Fire and smoke EN45545-2
MECHANICAL
Weight <3200 g
PROTECTIONS
Against overloads and short-circuits Shutdown with auto-recovery (see working parameters)
Against over-temperature Shutdown with auto-recovery
CONTROL
Output alarm Open when alarm. Maximum rating: 0.16A at 160Vdc
Remote OFF input Off applying 15…143Vdc, Impedance>18kΩ
2/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9
ODX-1300
1300 VA DC/AC
ORDERING CODES
ODX-1300-7447 110 77 - 138 250 3.10 1100 1300 6.6 90 < 0.34 1
ODX-1300-7457 110 77 - 138 400 1.88 1100 1300 3.4 91 < 0.34 1
3/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9
ODX-1300
1300 VA DC/AC
4/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9
ODX-1300
1300 VA DC/AC
It is possible to control and monitor de unit via RS232 by means of an application tool named PAM. This application is free
and can be downloaded from the Premium web side
Also it is possible to control and monitor de unit directly using the protocol showed in table:
Protocol configuration: ASCII code, 9600 bauds, parity none, 8 bits, 1bit stop
Note: OK (Data accepted) / ERR (Data not valid for the current parameter)
5/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9
ODX-1300
1300 VA DC/AC
Note 1:
Vo
Fi Fo
Example for N=1: start-up time = N x 1.7s for changes from 16Hz to 50Hz Mode V/F curve
6/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9
ODX-1300
1300 VA DC/AC
DIMENSIONS
SIZE-1
SIZE-2
7/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9
ODX-1300
1300 VA DC/AC
EU DECLARATION OF CONFORMITY
and that standards and/or technical specifications referenced overleaf have been applied:
Notes:
For the fulfilment of this declaration the product must be used only for the aim that has been
conceived, considering the limitations established in the instructions manual or datasheet.
Jordi Gazo
Chief Executive Officer PREMIUM S.A. is an ISO9001and ISO14001
certified company byBureau Veritas
8/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9
ODX-1300
1300 VA DC/AC
ANNEXE
Applicable values for the different sections of the norm EN50155: 2017
4.3.1 Working altitude Up to 2000m
Class OT1 (-25 to 55°C): load < 100%
4.3.2 Ambient temperature Class OT3 (-25 to 70°C): load <62.5%
Class OT5 (-25 to 85°C): load <25%
Switch-on extended
4.3.3 ST1
operating temp.
Rapid temperature
4.3.4 H1
variations
4.3.5 Shocks and vibrations According EN61373:2010 Category 1 class B
9/9
www.premiumpsu.com 30-04-2020
Powering Your Challenge 9502145-9
CA-563-9