Beruflich Dokumente
Kultur Dokumente
Objectives
1. · List the STAN components and their asset codes.
2. · Describe the sensor and channel calibrations procedure.
3. Describe how to acquire and process the STAN data.
Details
·Referring to the STAN Online Training and your STAN notes and the practical tasks,
answer the following questions.
Find the answer to the following questions, and be prepared for small verbal test in the morning:
Safety
1. IS – What is it?
2. Which parts are IS, which not?
3. What can be connected in a safe, zone 1, or zone 2 areas?
DART Software
1. RT and PB – what are the differences? How do we correct a flow rate in RT?
2. What are the globals or parameters required for DART to correct flow rates fully? How
do you input?
3. How do we correct for a CMF? Two ways?
4. How about for a standard Shrinkage and Water Meter Factor?
5. How do we configure DART for a Stan job?
6. What is the STAN.log file for?
Operation
1. What can go wrong with the data?
2. If sensor is reading different to Software display – what could be wrong?
3. If sensor is not powered up – what could be wrong?
4. If sensor fails, how will you record necessary data?
5. If have to connect water Floco what would you do?
6. Why do we need to be careful with the acquisition rate of data from the floco and
rotron? Is there a maximum?
References
STAN Online Training:
file://Ftc/Ftc_Web_Site/Schlumberger/Data_Acquisition/STAN_Online_Training/In
troduction%20-%20TOC.htm
InTouch Reference Page "Unigage - Downhole / Linc / Stan" ID: 3258326