Sie sind auf Seite 1von 1

KHWOPA ENGINEERING COLLEGE 5. What is noise?

Describe various noise coupling mechanism and


ASSESSMENT - 2062 (EVEN) ways to minimize them. [7]

LEVEL:- B. E. (Computer) III/II 6. What is electrostatic discharge? How can you implement ESD
SUBJECT:- BEG332EC, Microprocessor based Instrumentation protection? [7]
FULL MARKS:- 80
TIME:- 03:00 hrs. PASS MARKS:- 32 7. A microprocessor has 16 physical address output lines, labeled
Candidates are requested to give their answers in their own words as far as
A0-A15, eight data lines D0-D7 and other read write control
practicable. Figures in the margin indicate full marks. signals RD, WR, IO/M. You are required to connect this
processor to an EPROM of 2KB and RAM A, RAM B and
Attempt ALL questions.
RAM C of 8KB each. Assume that the base address for the
1. a) Explain the features of microprocessor based system. [4] EPROM is 0000H and at 800H RAM A will reside. RAM B
b) Explain closed loop microprocessor based system with and RAM C are stacked together with RAM A. Both EPROM
example. How closed loop system is different from open and RAMs have active low output enable and chip select
loop system. [4+2] signal. Design a complete memory mapping system with
necessary decoding logic incorporating signals from the
2. What is bidirectional data transfer? Assuming suitable port processor so that you can perform I/O operation from RAMs
addresses, write a master program to transfer data from master and ROM. [10]
MPU to slave MPU. [7]
Determine the control word for the following configuration of 8. Write short note: [63]
the ports of 8255. a. Analog Vs. Digital Transmission
a. Port A input, mode of port A: mode 0, Port B output, mode b. Water fall model of software development
of port B: mode 0, Port C lower pins output. Remaining pins c. Satellite communication
of Port C upper outputs. [2]
b. Port A mode: mode 2, Port B input, mode of port B: mode 0.
The remaining pins of port C lower output. [2]

3. How does a computer communicate with a modem? Briefly


*****
explain the various handshaking signals between the two. [7]

4. a) Interface 8 bit A/D converter with 8085 microprocessor


using status check. Write subroutine to initiate the
conversion and to read output data. [7]
b) Calculate the values of the LSB, MSB, and full scale output
for an 8 bit DAC for the 0 to 10V range. [3]

Das könnte Ihnen auch gefallen