Sie sind auf Seite 1von 4

Configuration for SunRocket:

Dial Plan:
(>#|911|611|411|311|00|0T|[2-9]xxxxxxxxx|1[2-9]xxxxxxxxx|[2-9]xxxxxxT|011[2-9]x.T|
*x.T)
Configuration for VoIP.ms:
(<:1415>[2-9]xxxxxx|1[2-9]xx[2-9]xxxxxxS0|[2-9]xx[2-9]xxxxxxS0|*xx|*xx.|[3468]11|911S0|822|0|00|[2-9]xxxxxx|
4XXX|xxxxxxxxxxxx.)
FROM: http://www.fatwallet.com/forums/hot-deals/758191/?start=20
Lot of useful information HERE
It is where I got most of my information to get up and running
Couple of things to make the set up easier.
Make sure your AC211-SR's firmware is version 4.62. If not upgrade it. Firmware and
insructions can
be found HERE
Auto-provisioning is turned off. Under WAN > AutoConfiguration, uncheck Enable
Automatic Configuration. Click Save Settings and Reset the AC-211. Do this first!
Your GizmoProject password is 6 characters or less. (Apparently the AC-211 will only
store a password of that length.) If you need to change the GizmoProject password, you
can do so in their software at Edit > Change Password.
You reset the AC-211 after making the changes to the SIP settings.
Your GizmoProject software is not running while using the AC-211. Go to File > Exit
rather than the usual X button or their software will minimize, not close.

Here are the settings for my AC211SR gizmo. These settings are in the SIP menu picked
from the left of the screen.
SIP Server Settings
Primary server
IP Address: proxy01.sipphone.com
Port: 5060
Domain Name*: proxy01.sipphone.com
Gateway Settings
DialPlan: (>#|911|611|r(411)8004664411|311|00|0T|[2-9]xxxxxxxxx|1[2-9]xxxxxxxxx|
[2-9]xxxxxxT|011[2-9]x.T|*x.T)
My dial plan uses Google411 for directory service, This can also be tweaked to dial your
local 911 service. I haven't set this up yet but you should be able to do it by using the
same format that the 411 uses in the dial plan.
Transport: UDP
Line 1
User / Phone Number: Your Gizmo #
CallerID Name
Port*: 64064
AEC On: ON
Authentication User Name: Your Gizmo #
PasswordLine1: Your Gizmo Project Password(Remember this must be 6 or less
characters as that is alll the Ac211 will accept. Can be changed in the Gizmo Project
Software)
Line 2 Leave Alone
NAT Settings
NAT IP Address: BLANK
RTP/RTCP Port Base: 16384
STUN Server Settings
STUN server IP Address: stun01.sipphone.com
STUN server Port:3478
Settings under the SIP Extensions Tab
Support PRACK method with provisional response reliability: UNCHECKED
Encode SIP URI with user parameter: UNCHECKED
INVITE Expires Timer value (sec):9999
SIP Session Timer value (sec):60
SIP Registration Timer value (sec):CHECKED 60
Send RTP on 183 Session Progress:CHECKED
This is all AT YOUR OWN RISK. I'm not a tech expert and am just trying to post what
got me up and running. I'll sure try to help if you get and a jamb and at the least point
you in the right direction for help.

Das könnte Ihnen auch gefallen