Beruflich Dokumente
Kultur Dokumente
General Specifications
Antenna Type Sector
RET Interface 2x 8 pin connector as per IEC 60130-9 Daisy chain in: Male / Daisy chain out: Female Pin3:
RS485A(AISG_B), Pin5: RS485B(AISG_A), Pin6: DC 10~30V, Pin7: DC_ Return
Dimensions
Width 467 mm | 18.386 in
Array Layout
Page 1 of 5
©2020 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: June 1, 2020
4P-4L-C2
Port Configuration
Page 2 of 5
©2020 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: June 1, 2020
4P-4L-C2
Electrical Specifications
Impedance 50 ohm
Polarization ±45°
Electrical Specifications
Frequency Band, MHz 694–790 790–890 890–960
Page 3 of 5
©2020 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: June 1, 2020
4P-4L-C2
Gain, dBi 16.1 16.6 17
Beamwidth, Horizontal, degrees 66 61 58
Beamwidth, Vertical, degrees 8.7 7.7 7
Beam Tilt, degrees 0–10 0–10 0–10
USLS (First Lobe), dB 17 21 21
Front-to-Back Ratio, Copolarization 180° ± 30°, 28 29 28
dB
Isolation, Cross Polarization, dB 28 28 28
Isolation, Inter-band, dB 28 28 28
VSWR | Return loss, dB 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
Mechanical Specifications
Wind Loading at Velocity, frontal 1,080.0 N @ 150 km/h | 242.8 lbf @ 150 km/h
Wind Loading at Velocity, lateral 106.8 lbf @ 150 km/h | 475.0 N @ 150 km/h
Regulatory Compliance/Certifications
Agency Classification
Page 4 of 5
©2020 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: June 1, 2020
4P-4L-C2
CHINA-ROHS Below maximum concentration value
ISO 9001:2015 Designed, manufactured and/or distributed under this quality management system
REACH-SVHC Compliant as per SVHC revision on www.commscope.com/ProductCompliance
ROHS Compliant
Included Products
BSAMNT- Wide Profile Antenna Downtilt Mounting Kit for 2.4 - 4.5 in (60 - 115 mm) OD round members. Kit contains one scissor
—
B95-02 top bracket set, one middle bracket set and one bottom bracket set.
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
Page 5 of 5
©2020 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: June 1, 2020