Beruflich Dokumente
Kultur Dokumente
Pin Description
1 Red - Battery constant (+12 / 24 V)
2 Black - Ground
3 Blue/Black - Sender Signal -
4 Brown - Battery switched (+12 / 24 V)
5 Green - Sender Signal +
6 Blue/Red - Illumination (+)
7 Not Connected
8 Not Connected
Pin Description
Green/Black - Configuration
Programming the Tachometer (Illustration B): 11
(- Trigger)
Operation Basics: 12 Green/Red - Mode (+ Trigger)
Short Press (< 2sec.) - Long Press (> 2sec.) Red - Alarm Output
13
(max 100 mA)
The Configuration button must be connected before
1-10, 14 unassigned
programming can be done.
The display will return to normal operation if a button is not
NOTE: The Push-button supplied is to
pressed for 30 seconds. Any settings you have made will
be used as a:
not be saved. a) Configuration button to set up the
tachometer before use.
Setting the Pulses per Revolution: (0.5 to 399.9 pulses)
b) Mode button for operation of the
1. With the ignition switch off, hold in the Configuration tachometer during normal use.
button.
2. Turn ignition on.
3. Release the Configuration button. The Warning Icon in the gauge will
4. “Pulse” will appear on the display. illuminate and the Alarm Output (Pin
5. Long press to get to the pulse setting screen. 13 of 14 pin connector) will trigger to
6. Short press will increase the value of the flashing ground when the RPM's exceed this
number by 1. limit.
7. Long press to move to the next position.
8. Long press to exit pulse setting.
9. “Pulse” will appear on the display.
10. Turn off ignition.
Illustration B
Tach With Display 85mm
Tech Support 1-800-265-1818
Instruction Sheet # A2C59519487 Rev 11-2010
http://usa.vdo.com
Mode Button:
Total Operating
Trip Hours Time Voltage
Hours
1. Press the Mode key repeatedly until the trip hours are
displayed.
2. Press and hold Mode key to reset.
To set clock format (12 / 24 hour) see Set Unit and Alarm
Threshold on page 2.
The recommended panel thickness Place the bracket on the stud bolt
For 85mm instruments, the Spin- is 1.5 to 3 mm. The drill hole must and tighten the knurled nut. Do not
Lok™ nut can be mounted at have a diameter of 75.4mm. Ensure over-tighten.
position A or B. This allows you two that the installation location is level
clamping depths. and has no sharp edges.