Beruflich Dokumente
Kultur Dokumente
The Participant will utilize the following DataMan Functions to successfully complete this
exercise:
· Step by step instructions in this lab
· Tools provided for assembling the reader and S-Mount/M12 along with the LED light
LED’s—after the rubber ring has been placed in the reader from step 3.
Assembling the Reader and Accessories Place the flat side of the LED rubber gasket onto the reader body and then plug
the LED light into the smaller receptacle on the reader. Secure the LED light to the
1. If you are using a new reader, remove the lens plug. reader using the 4 screws. Tighten screws to 9N-cm (0.08 in-lbs) in the order
shown in the diagram.
NOTE: Restart the reader and Setup Tool to recognize the newly installed LED
lights!
2. Lens – Screw the large diameter end of the M12-10.3mm lens into the body of the 4. Mount the Reader on the Bracket using the two or four 3M x 5mm hex screws.
reader’s smaller diameter threaded hole. Writing points out of the reader.
NOTE: Screw about half way in as we will be focusing the lens in Lab section 02_2.
Page 1 Page 2
Industrial ID featuring DataMan Section 3 | Lab Exercise
This completes the lab for assembling and connecting cables to a reader for Installation.
Page 3