Beruflich Dokumente
Kultur Dokumente
IEC 60950-1 : 2005 + Amendment 1 : 2009 and EN 60950-1 : 2006 + EN 60950-1/A11 : 2009
(The model designation may be followed by additional letters and numbers or blanks
denoting differences in SELV secondary circuits or minor mechanical differences.)
Ratings ............................................. : -
Report No.
Page: 2 of 18 CHK+1BU10-0175+S02
Reg.Nr.: DAT-PL-155/94-03
Page: 3 of 18 CHK+1BU10-0175+S02
Page: 4 of 18 CHK+1BU10-0175+S02
General remarks:
This report covers not all items of the considered standard. Overview of tested clauses, for detailed
information refer to following pages.
Clause Result
2.5 Limited power and overload of operator accessible connectors P
4.3.8 Batteries P
4.7.1 Reducing the risk of ignition and spread of flame P
5.3 Abnormal operating and fault conditions P
Specific checks according to IEC 60950-1 / EN 60950-1 and special Fujitsu Technology Solutions
requirements. The listed checks represents a spot-check and not a detailed check.
The test results presented in this report relate only to the object tested.
• Test Equipment
(1 page)
Report No.
Page: 5 of 18 CHK+1BU10-0175+S02
IEC 60950-1
Clause Requirement + Test Result - Remark Verdict
4.7.1 Reducing the risk of ignition and spread of flame Refer below P
Method 1, selection and application of components (see appended table 1.5.1) P
wiring and materials
Method 2, application of all of simulated fault - N
condition tests
Page: 6 of 18 CHK+1BU10-0175+S02
Page: 7 of 18 CHK+1BU10-0175+S02
Page: 8 of 18 CHK+1BU10-0175+S02
Page: 9 of 18 CHK+1BU10-0175+S02
Supplementary information:
1) an asterisk indicates a mark which assures the agreed level of surveillance
2) max. abnormal charging current
3) Itrip / Ihold
Report No.
Page: 10 of 18 CHK+1BU10-0175+S02
Circuit output tested: USB rear A, B (located in combined LAN / USB jack)
Measured Uoc (V) with all load circuits 4.9
disconnected:
Measured UOL (V): 3.7
IOL (A) VA
Meas. Limit Meas. Limit
Normal condition 5.0 8.0 18.5 100
Circuit output tested: USB rear A, B, C, D (located in 4 * USB jack, USB Port)
Measured Uoc (V) with all load circuits 4.9
disconnected:
Measured UOL (V): 3.8
IOL (A) VA
Meas. Limit Meas. Limit
Normal condition 5.2 8.0 19.8 100
Report No.
Page: 11 of 18 CHK+1BU10-0175+S02
Page: 12 of 18 CHK+1BU10-0175+S02
Page: 13 of 18 CHK+1BU10-0175+S02
* Calculated by 5V / 1KΩ
** Tested by UL
Page: 14 of 18 CHK+1BU10-0175+S02
Schematics
VBATT_SIO
VBATT_RTC
Report No.
Page: 15 of 18 CHK+1BU10-0175+S02
Page: 16 of 18 CHK+1BU10-0175+S02
Pictures
Page: 17 of 18 CHK+1BU10-0175+S02
583R50 540R01
592R00
Report No.
Page: 18 of 18 CHK+1BU10-0175+S02
426V51 426R56
- Page 1 of 1 -
Test Equipment