Beruflich Dokumente
Kultur Dokumente
82 26/11/2020
Service
Chassis ID Path
A 645343 8521/Repair//Seat height level control valve, replace
Model Identity
FH 89579012
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
1/6
IMPACT 4.07.82 26/11/2020
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
2/6
IMPACT 4.07.82 26/11/2020
Warning
Block the scissors with an 50 mm pipe or two sockets placed inside each other.
2
Lower the seat so that the air is drained out.
3
Drain the primary container and empty the braking system.
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
3/6
IMPACT 4.07.82 26/11/2020
Caution
Bend carefully with a small screwdriver so as not to damage the level control valve.
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
4/6
IMPACT 4.07.82 26/11/2020
Check the following before mounting the new level control valve:
That the quadrant gear segment is working correctly.
5/6
IMPACT 4.07.82 26/11/2020
7
Fit the new level control valve. Ensure that the position of the level control valve gear segment is correct in relation to
the connected equipment.
Turn the valve gear segment to ensure that it engages correctly.
8
Fill the vehicle's compressed air system.
9
Raise the seat to maximum height position. Remove the spacer that is blocking the seat.
10
The lever arm A shall allow the wireB 1-2mm play, as shown by the arrows.
Copyright to this documentation belongs to the Volvo Group. No reproduction, copying, change, amendment or other similar disposal is entitled without prior written consent by
the Volvo Group
The information contained herein is current at the time of its original distribution, but is subject to change. The reader is advised that printed copies are uncontrolled.
6/6