Beruflich Dokumente
Kultur Dokumente
1 Be
in your community due to environmental sure the power cord is plugged
considerations. into a properly grounded wall outlet.
For disposal or recycling information please contact Then, press the POWER button on the
your local authorities, or the Electronics Industries projection display or the remote control
Alliance: <http://www.eiae.org.> to turn the unit on.
2 While
Lamp unit handle pressing the VOL- button on
Lamp replacement procedure the projection display, hold down the
Front cover
1 Turn power off, wait until power PIP or SPLIT button on the remote
indicator stops blinking red, then CAUTION control at same time for more than
unplug the power cord from the 5 seconds.
• Because the lamp unit is hot immediately after
wall outlet and confirm that the area its use, touching it may cause burns.
around the lamp unit has cooled • Please allow the lamp to cool before handling or For models PT-50LC13/
PT-60LC13/PT-50LCX63/
down. replacing the lamp unit. PT-60LCX63/PT-43LCX64/
and PT-50LCX64/PT-60LCX64
POWER
button /
LAMP indicator POWER
indicator
6 screws.
Replace the Lamp unit and cover
Tighten the lamp unit/cover
screw with a screwdriver. 3 When reset
procedure LAMP TIME WAS
• Properly dispose of old lamp. Please see the
is complete, RESET TO 0.
• Please wait more than one hour for lamp
operating instructions for the projection display. the screen on
replacement.
[If you need to replace the lamp more urgently] Note the right will
Lamp cover screw appear.
• The Projection display has a forced cooling
feature. After the POWER button is turned OFF, Attach the lamp unit and lamp unit housing door END
and during the first minute of the normal cooling securely. If the lamp unit and lamp unit housing * This screen may be
fan operation, press the VOL+ button on the door are not attached securely, the protective different from the actual
projection display and button on the remote circuit will be activated and the lamp will not turn screen.
control at same time for more than 5 seconds. The on. Note
cooling fan operates for about 10 minutes. The
7
When lamp time reset is finished, the LAMP
LAMP indicator flashes red 5 times every 5 Replace the Front cover. indicator goes out.
seconds.
LSQC0334 C
PANASONIC CONSUMER ELECTRONICS COMPANY, DIVISION PANASONIC PUERTO RICO, INC.,
OF PANASONIC CORPORATION OF NORTH AMERICA Ave. 65 de Infanteria, Km. 9.5
One Panasonic Way San Gabriel Industrial Park Carolina, Puerto Rico 00985
Secaucus, New Jersey 07094