Beruflich Dokumente
Kultur Dokumente
1. In general, motors are designed to operate in a maximum ambient temperature of ______ unless specifically designed for a higher
temperature.
a. 60o C b. 50o C c. 45oC d. 40oC
2. A type of single phase motor that can be operated on either ac or dc is a ________ motor.
a. multispeed b. capacitor start c. universal d. repulsion-induction
3. For screw shell devices with attached leads, the conductor attached to the screw shell shall be ______ in color.
a. white or gray b. orange c. green d. black
4. Branch circuit conductors shall have an ampacity not less than _______.
a. the load increased 125%
b. 100% of the load to be served
c. 80% of the load to be served
d. 125% of the continuous load plus 80% of the non-continuous load
5. A switch intended for isolating an electric current from the source of power that has no interrupting rating, and it is intended to be
operated only after the circuit has been opened by some other means is a/an _________.
a. isolating switch b. bypass isolation switch c. general use switch d. transfer switch
7. Not readily accessible to persons unless special means for access are used is _________.
a. elevated b. guarded c. isolated d. listed
8. After cutting a conduit, to remove the rough edges on both ends, the conduit ends should be _______.
a. sanded b. shaped c. burnished d. ground
9. The instrument used to indicate phase relation between current and voltage is the __________.
a. megger b. power factor meter c. voltmeter d. galvanometer
11. You have an adjustable trip coil rated 5 amps on a 200amps switch. If you want the switch to trip at 120 amps, the trip coil should be
set at _________.
a. 2 amps b. 3 amps c. 4 amps d. 5 amps
12. When an ammeter is disconnected from an in-service transformer, the secondary terminals of the current transformer must be
___________.
a. shorted b. open c. disconnected d. grounded
14. Motors 1/3, ¼ and 1/8 are connected in parallel. Those motors deliver a total of _________.
a. 1HP b. 7/8 HP c. 17/24HP d. .07HP
16. A fixture that weighs more than _________ shall be supported independently of the outlet box.
a. 25 lbs b. 30 lbs c. 50 lbs d. 75 lbs
17. The force which move electrons from atom to atom through a closed conducting path is called_______
a. flux b. resistance c. admittance d. emf
18. An advantage of a 240-volt system compared with a 120-V system of the same wattage is ________.
a. reduced voltage drop b. reduce power use
c. large currents d. lower electrical pressure
HABILIS EE TRAINING CENTER, INC.
61st Isabel Ramiro Road, Purok 6A, Tambo-Hinaplanon,
Iligan City, 9200 Tel No. (063) 2250809 Refresher Day 19
19. A resistor has an indicated tolerance error of 10%. With the value of 1,000 ohms, the minimum resistance the resistor may have
is_________.
a. 1,100 ohms b. 990 ohms c. 910 ohms d. 900 ohms
20. A transformer has a primary voltage of 120 volts and a secondary voltage of 480 volts. If there are 40 turns on the primary, the
secondary contains ___________.
a. 10 turns b. 40 turns c. 120 turns d. 160 turns
22. Sometimes copper inductors are coated (tinned) to help prevent ______.
a. higher resistances b. mechanical damage
c. capacitive reactance d. chemical reaction
25. The inductive action that causes current to flow on the outside surface of a cionductor is known as the _____.
a. corona effect b. skin effect c. electrolytic action d. DC reactance
26. Electrical continuity is required by the electrical code for metallic conduit_________.
a. to assure equipment grounding b. to reduce static electricity
c. to reduce inductive heat d. to trace electrical wiring
28. An electrical timer switch for lighting is normally connected in ________ with lighting circuit being controlled.
a. series b. parallel c. sequence d. tandem
31. A three-phase, 6-pole AC alternator 34kVA, on Y-connected system. During one complete mechanical rotation (360 0) will have
________ electrical rotations.
a. 1 b. 1 ½ c. 3 d. 12
32. The voltage per turn of the primary of a transformer is __________ the voltage per turn of the secondary.
a. more than b. the same as c. less than d. NOT
33. A single concrete encased electrode shall be augmented by one additional electrode if it does not have a resistance to ground of
__________.
a. 25Ω b. 30Ω c. 50Ω d. not a code requirement
35. On a 120 V 1P circuit, ground fault protection for personnel operates on the principle of unbalanced current between_________.
a. the grounded and the ungrounded conductor
b. the ungrounded conductors
c. the grounding conductor and the neutral conductor
d. the service disconnect and the branch circuit
37. _________ duty is a type of service where both the load and the time intervals may have wide variations.
a. continuous b. periodic c. intermittent d. varying
45. What percentage of the maximum (peak) voltage is the effective (RMS) voltage?
a. 100% b. 70.7% c. 63.7% d. 57.7%