Beruflich Dokumente
Kultur Dokumente
1
IV B.Tech I Semester Supplimentary Examinations, February 2008
MOTION CONTROL DESIGN
(Mechatronics)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
5. Describe any three types of air compressors used in pneumatic system. [16]
6. (a) Explain the advantage of adoptive control system over feed back control sys-
tem. [8]
(b) Describe any three types of mechanical actuators with a neat sketch. [8]
⋆⋆⋆⋆⋆
1 of 1
Code No: RR411401 Set No. 2
IV B.Tech I Semester Supplimentary Examinations, February 2008
MOTION CONTROL DESIGN
(Mechatronics)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
2. (a) Explain the operation of a sorting device used in motion control. [8]
(b) Explain the working of a conveyor system. [8]
5. (a) Classify Various types of air compressors used in Pneumatic systems. [8]
(b) Draw a circuit diagram to control and operate double acting pneumatic cylin-
der with 4/2 Directional control valve(Manual Type). [8]
7. Explain the fuzzy logic system to control and operate an electric motor to run at
1500 RPM. [16]
8. (a) Describe “AND” , “OR” logic gates used in PLC programming and draw their
truth tables. [8]
(b) Listout various symbols used in ladder programming. [8]
⋆⋆⋆⋆⋆
1 of 1
Code No: RR411401 Set No. 3
IV B.Tech I Semester Supplimentary Examinations, February 2008
MOTION CONTROL DESIGN
(Mechatronics)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
1. (a) What are the different feeding devices used in assembly lines. [8]
(b) Explain two types of vibratory feeding devices. [8]
5. Describe any three types of air compressors used in pneumatic system. [16]
6. (a) Describe Vane motor used in hydraulic systems with a neat sketch. [8]
(b) Describe piston motor used in hydraulic system. [8]
7. Explain the fundamental concepts of adoptive and fuzzy control systems. [16]
⋆⋆⋆⋆⋆
1 of 1
Code No: RR411401 Set No. 4
IV B.Tech I Semester Supplimentary Examinations, February 2008
MOTION CONTROL DESIGN
(Mechatronics)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
2. (a) Discuss various types of indexing mechanisms used in motion control. [8]
(b) Write the advantages of orienting devices. [8]
4. (a) Enumerate the differences between industrial hydraulic and Pneumatic sys-
tems. [8]
(b) Describe internal gear pump used in hydraulic system with a neat sketch. [8]
7. Explain in detail the fundamental concepts of adoptive control system and its ad-
vantage over feed back control system. [16]
⋆⋆⋆⋆⋆
1 of 1