Beruflich Dokumente
Kultur Dokumente
Step1. First a fall you have to open the command prompt by pressing the key (window + R).
Step2. As you press (window + R) it will open run command window in the run command
window simply type CMD. it will open command prompt.
Step3. In the next step you have to see the wifi networks, which are available in your system. To
see that you have to type (Wmic)
Step 5. Then simply type in the command prompt (netsh wlan show profiles) it will show all the
networks which all are available in your system.
Step 6. Now simply type (netsh wlan show profiles, and the network name e.g VishuWiFi).
Step 7. You have to type like this (netsh wlan show profiles VishuWifi). It will open all the details
related to that particular network.
Step 8. Now this is the last step that you need to apply. Again just type (netsh wlan show profiles
Vishuwifi key=clear) it will show the password of the network.
You have been hacked a wifi password … thanks for using this trick…..
Have fun……..
Steps to Hack Wifi password using cmd
PAGES
6
WORDS
725
1. Open our terminal (CTRL+ALT+T) and type airmon-ng (view tips and tricks
how to create keyboard shortcut on kali linux)
this command will lists our wireless card that attached with our system.
2. The next step we need to stop our wireless monitor mode by running
airmon-ng stop wlan0
From the picture above, we can see many available access point with all the
information. In the green box is our victim access point which is my own
access point
Information:
BSSID (Basic Service Set Identification): the MAC address of access point
#Data: Number of captured data packets (if WEP, unique IV count), including
data broadcast packets.
#/s: Number of data packets per second measure over the last 10 seconds.
CIPHER: The cipher detected. TKIP is typically used with WPA and CCMP is
typically used with WPA2.
ESSID: Shows the wireless network name. The so-called SSID, which can be
empty if SSID hiding is activated.
4. From the step 3 above, we can find access point with encryption algorithm
WPA2 and note the AP channel number. Now we will find out whether target
AP has WPS enabled or not.
wash -i wlan0 -c 8 -C -s
if the WPS Locked status is No, then we ready to crack and move to step 5.
Related Topics
Wireless networking Local area networks IEEE 802.11 Computer network
security NetshCryptographic protocols Wireless LAN Wi-Fi Service
set Wireless network