Beruflich Dokumente
Kultur Dokumente
Broadband
Intelligent, Networked, Multi-Channel Fire Alarm Control
Description and Emergency Voice Evacuation System
GAMEWELL-FCI
12 Clintonville Road, Northford, CT 06472-1610 USA • Tel: (203) 484-7161 • Fax: (203) 484-7118
Specifications are for information only, are not intended for installation purposes, and are subject to change without notice. No responsibility is assumed by Gamewell-FCI for their use.
©2008 by Honeywell International Inc. All rights reserved. www.gamewell-fci.com 9020-0613 Rev. D1 page 1 of 5
Description (Continued) The Intelligent Network Transponder (INX) acts as
The Field Configuration Program (FCP) is based on Bool- a network audio transponder for the E3 Series Broadband
ean logic statements providing AND, OR, NOT, and XOR Network. The INX transponder serves as the point of distri-
logic operators. These can be combined to produce addi- bution for the system’s audio and fire fighter telephone cir-
tional Boolean operators such as NAND, NOR, XNOR, etc. cuits and occupies a single node on the E3 Series
system silence, etc. The E3 Series Broadband is software- Broadband network.
programmable for multi-channel digital audio applications. A typical INX assembly consists of an ILI-MB-E3 or
It is ideal for a wide range of complex system applications ILI-S-E3, an Intelligent Network Interface-Voice Gateway
including high-rise or campus installations. An array of cab- (INI-VGX) module, a PM-9 power supply, and up to four
inets allows for neat, compact, attractive installations. (4), AM-50 amplifiers. The INX transponder occupies a sin-
A comprehensive set of timing functions can also be gle address on the network and provides termination points
attached to any input/output logic statement for staggered for the network connection using either a pair of unshielded
reset of fan control relays, time-delayed alarm activation, twisted-pair wire or fiber-optic cable.
automatic.
The INI-VGX uses advanced Digital Signal Processing
The E3 is a microprocessor-based fire alarm control panel (DSP) technology for audio compression and filtering
that uses an ILI-MB-E3 Intelligent Loop Module with two (2) allowing E3 Series Broadband to produce the clearest
signaling line circuits and two (2) notification appliance cir- audio possible while conserving network bandwidth for
cuits. When transmitting to remote locations, the optional instantaneous response. Background noise is automati-
RPT-E3 provides the ILI-MB-E3 with signal boosting and cally filtered during voice paging and fire fighter communi-
transient protection, as well as connectivity for both wire cations increasing audibility and eliminating the need for
and fiber-optic cables. Options also include an integral Dig- push-to-talk devices.
ital Alarm Communicator Transmitter (DACT) supporting
most popular reporting formats. The INI-VGX can accommodate up to sixteen (16), differ-
ent messages with a total combined duration of three min-
The Intelligent Network Command Center (INCC) serves utes. Each message can be field installed via a laptop
as the point of interface between an operator and the sys- computer and can be in the form of a voice message or an
tem’s audio evacuation, fire fighter intercom, and building evacuation tone.
network. The INCC occupies a single address on the E3
Series Broadband network. A typical INCC assembly con- The INI-VGX also provides a fire fighter phone riser and an
sists of an Intelligent Network Interface-Voice Gateway addressable signaling line circuit connecting to multiple
(INI-VGC-FO or INI-VGC-UTP) module (fiber-optic or phone jacks or warden stations through as many as sixteen
unshielded twisted-pair), or INI-VGC-UTP (unshielded (16), AOM-TELF modules. In addition, the INI-VGX SLC
twisted-pair only), one or more Addressable Switch Mod- can support up to thirty-two (32), speaker circuits using the
ules (ASM-16), optional Network Graphic Annunciator AOM-MUXF for dual channel applications.
(NGA) and remote 48 LED driver module (ANU-48).
The INX can contain four (4), 50 watt, 25 VRMS AM-50
Options include a paging microphone and a fire fighter’s
audio amplifiers, each with two (2), separate speaker cir-
handset connecting to the INI-VGC-FO or INI-VGC-UTP.
cuits that can be wired Style Y (Class B) or Style Z (Class
Each INI-VGC can support up to sixteen (16), ASM-16
A). Each amplifier can produce its own tone or message
modules. Each ASM-16 has sixteen (16), push-button
independently of other system amplifiers. Thus, an INX
switches for a maximum capacity of 256 switches per INI-
transponder can produce three (3), audio channels simulta-
VGC command center. Each switch has three (3), associ-
neously. Each INX transponder can support four (4), AM-
ated LEDs, colored green, yellow, and red. These switches
50s as main amplifiers with one (1), AM-50 as a fail-safe
and their LEDs are fully programmable to serve any sys-
backup amplifier.
tem function desired. They can control audio speaker cir-
cuits, notification appliance circuits, addressable relay The INX transponder receives its power from a PM-9, 9
outputs, fire fighter phone control circuits, or any special ampere, filtered, switching power supply providing twenty-
application that might be required. four (24), VDC nominal operating voltage. The PM-9 has
Multiple INCCs can be configured into the E3 Series an integral standby battery charger capable of recharging
Broadband network to serve as a completely independent up to fifty-five (55), A/H batteries. The E3-BB-BC/INX
command center for their local area or as remote com- cabinet can house up to 18 A/H sized batteries.
mand centers mimicking, in part or in whole, the function of
a main command center.
GAMEWELL-FCI
12 Clintonville Road, Northford, CT 06472-1610 USA • Tel: (203) 484-7161 • Fax: (203) 484-7118
9020-0613 Rev. D1 page 2 of 5 www.gamewell-fci.com
E3 with
Two (2), notification appliance
Circuits, each rated FIRE FIRE Optional Digital
2.0 amps. @ 24 VDC Alarm Communicator
(Power-limited). Transmitter (DACT-E3)
for local or network-
Two analog addressable FIRE
wide event reporting
Signaling line circuits
for 39 devices
(Power-limited)
Style 6 (Class “A”) with
optional
CAOM Twisted-pair or fiber-optic cable
INCC-C Command Center with optional between nodes 3,000 ft. (900m)
Microphone and Fire Fighter’s Handset distance with wire
ASM-16 Addressable Switch Modules with up to 8 dB loss with fiber-optic
16 Programmable, addressable
Switches, each with three (3), programmable
Indicating LEDs (red, green yellow)
(Power-limited)
Gamewell-FCI
Gamewell-FCI
Figure 1
GAMEWELL-FCI
12 Clintonville Road, Northford, CT 06472-1610 USA • Tel: (203) 484-7161 • Fax: (203) 484-7118
www.gamewell-fci.com 9020-0613 Rev. D1 page 3 of 5
L o c a l A n n u n c ia to rs , L C D -7 1 0 0 , (M a x . 5 ) One SLC
G lo b a l d is p la y fo r a ll n e tw o rk e v e n ts if (1 6 A O M -T E L F s & 3 2 A O M -M U X F s )
s e t to R e g io n “ 0 ”
NAC F IR E
INX
NAC F IR E
In itia tin g / C o n tro l O n e p h o n e ris e r
D e v ic e s T y p ic a l fo r
S L C N o . 2 (if u s e d )
E 3 S e rie s
G a m e w e ll-F C I G a m e w e ll-F C I
6 S p e a k e r a p p lia n c e c k ts .
1 5 0 w a tts m a x . @ 2 5 V R M S
w / 5 0 w a tts s ta n d b y
3 ,0 0 0 ft. (7,620 cm ) (m a x .) b e tw e e n n o d e s u s in g w ire
8 d B lo s s (m a x .) b e tw e e n n o d e s u s in g fib e r -o p tic c a b le
One SLC
(1 6 A O M -T E L F s & 3 2 A O M -M U X F s )
F IR E
NAC
INX
F IR E
NAC
O n e p h o n e ris e r
In itia tin g / C o n tro l D e v ic e s
T y p ic a l fo r S L C N o . 2
(if u s e d )
E 3 S e rie s
G a m e w e ll-F C I G a m e w e ll-F C I
6 S p e a k e r a p p lia n c e c k ts .
C o n n e c t if w ire d 1 5 0 w a tts m a x . @ 2 5 V R M S
C la s s A , S ty le 6 o r 7 o n ly w / 5 0 w a tts s ta n d b y
O n e p h o n e ris e r
L o c a l a n n u n c ia to rs ,
L C D -7 1 0 0 , (M a x . 5 )
G lo b a l d is p la y fo r a ll n e tw o rk
E v e n ts if s e t to R e g io n “ 0 ”
E 3 S e rie s
G a m e w e ll-F C I
G a m e w e ll-F C I
6 S p e a k e r a p p lia n c e c k ts .
1 5 0 w a tts m a x . @ 2 5 V R M S
w / 5 0 w a tts s ta n d b y
Figure 2
GAMEWELL-FCI
12 Clintonville Road, Northford, CT 06472-1610 USA • Tel: (203) 484-7161 • Fax: (203) 484-7118
9020-0613 Rev. D1 page 4 of 5 www.gamewell-fci.com
Specifications Ordering Information (Continued)
Detailed product specifications may be found in: INCC Intelligent Network Command Center
9020-0542 INCC Intelligent Network Command (Continued)
Center Datasheet Part Number Description
9020-0637 E3 Series Control Panel Datasheet INCC-ID Inner door w/6 single slots
9020-0541 INX Intelligent Network Transponder INCC-CABR INCC backbox (black) with red outer door,
Datasheet 19” H x 19” W x 4” D (48 x 48 x 10 cm)
GAMEWELL-FCI
12 Clintonville Road, Northford, CT 06472-1610 USA • Tel: (203) 484-7161 • Fax: (203) 484-7118
www.gamewell-fci.com 9020-0613 Rev. D1 page 5 of 5