Beruflich Dokumente
Kultur Dokumente
USER’S GUIDE
Second Edition
1
INDEX
2
INSTALLATION INSTRUCTIONS
Procedure:
1. Install Driver,
2. Install PonyProg 2000,
3. Install Restorer.
1) Install Driver:
a. Open the folder ‘Driver’ on the CD, double click on the PL-2303
Driver Installer. Follow instructions.
b. Ensure COM port 2 has been selected. Right click My Computer,
Properties, Hardware, Device Manager, Ports, right click ‘Prolific
USB-Serial Comm Port, Properties, Port Settings, Advanced,
select com port 2.
3
c) Set pointer 1 to ‘MicroWire16 eeprom’.
d) Set pointer 2 to ‘9346’.
e) Click ‘Setup’ and run calibration.
f) Click ‘Setup’, ‘Interface Setup’. Select ‘Serial’ and
‘COM2’.
4
3) Install Restorer:
a) Copy all the files found under the ‘Software’,
‘Restorer’ folder, to any folder on the hard drive.
b) Open Restorer.
c) Set pointer 1 to ‘COM2’.
d) Set pointer 2 to ‘Native’
5
PROGRAMS TO BE USED TO RESET CHIPS:
Type A: Type B:
C450 C250
C350 C252
8022 C300
8031 C352
8020 5440
C451
C550
C650
6
RESETTING INSTRUCTIONS:
Type A:
1. Remove the chip from the image unit and insert the chip into
the socket on the resetera.
2. Run PonyProg2000.
3. Click ‘Open Device File’ and select the chip data that is to
written onto the chip. (If the chip date is not available, refer
to ‘Reading and Saving Chip Data’)
Type B:
3. Run Restorer.
7
4. Click on READ DS2432.
5. Click on Unlock Status Page.
6. Click on Open, browse for the chip data.
7. Select the chip data to be written to the chip. (If the chip
date is not available, refer to ‘Reading and Saving Chip Data’)
8
READING AND SAVING CHIP DATA:
If certain chip data is not available with release of the User CD,
data can be read and saved by each user. Follow the steps below: