Beruflich Dokumente
Kultur Dokumente
1
I B.Tech Regular Examinations, May/Jun 2008
INTRODUCTION TO AEROSPACE ENGINEERING
(Aeronautical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
2. (a) What are the flight instruments are connected into a Pitot- static system.
(b) How many kinds of altimeters are in use. [8+8]
7. (a) Explain in detail with the help of a figure directional static stability.
(b) Explain in detail with the help of a figure lateral static stability. [8+8]
⋆⋆⋆⋆⋆
1 of 1
Code No: 07A12101 Set No. 2
I B.Tech Regular Examinations, May/Jun 2008
INTRODUCTION TO AEROSPACE ENGINEERING
(Aeronautical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
2. Explain in detail the principle of altimeter and explain about radio altimeter. [16]
3. (a) How is skin friction caused? Why is the skin friction becoming greater impor-
tance recently.
(b) Explain what happens in the boundary layer? [8+8]
(a) Elevator
(b) Aileron
(c) Rudder.
7. (a) Explain in detail with the help of a figure directional static stability.
(b) Explain in detail with the help of a figure lateral static stability. [8+8]
⋆⋆⋆⋆⋆
1 of 1
Code No: 07A12101 Set No. 3
I B.Tech Regular Examinations, May/Jun 2008
INTRODUCTION TO AEROSPACE ENGINEERING
(Aeronautical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
2. (a) What design features of an aileron system are employed to overcome adverse
yaw?
(b) Describe the function of ruddervators. [8+8]
5. Explain with the aid of sketches, two mechanisms of liquid propellants used in
rocket engine. [16]
6. “Study of skin friction in laminar & turbulent flow becomes increasingly great
importance” Discuss. [16]
⋆⋆⋆⋆⋆
1 of 1
Code No: 07A12101 Set No. 4
I B.Tech Regular Examinations, May/Jun 2008
INTRODUCTION TO AEROSPACE ENGINEERING
(Aeronautical Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
4. Name three types of fuselages classified according to the method by which stresses
are transmitted to the structure. [16]
6. A rough egg- shaped body with a circular cross section 75mm in diameter is tested
in a wind tunnel at 100 knots and the air resistance is found to be 1.8N. What is
the value of the drag coefficient? [16]
7. An aircraft weighing 30, 000N descends with engines off at a slide angle of 30 . Find
the drag and lift components that act during the slide. [16]
⋆⋆⋆⋆⋆
1 of 1