Beruflich Dokumente
Kultur Dokumente
CRT4053
DEH-50UB/XS/EW5
CD RDS RECEIVER
DEH-50UB /XS/EW5
This service manual should be used together with the following manual(s):
Model No. Order No. Mech.Module Remarks
CX-3240 CRT4050 S10.5COMP2-iPod/USB CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely
A repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
CLASS 1
D LASER PRODUCT
WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.
E
DEH-50UB/XS/EW5
2
1 2 3 4
5 6 7 8
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
Please be sure that all screws are fastened, and that there are no loose screws.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc. C
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
DEH-50UB/XS/EW5
7
3
5 6 8
1 2 3 4
CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
A
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 5
2. SPECIFICATIONS ............................................................................................................................................ 6
2.1 SPECIFICATIONS ..................................................................................................................................... 6
2.2 DISC/CONTENT FORMAT ........................................................................................................................ 6
2.3 PANEL FACILITIES.................................................................................................................................... 7
2.4 CONNECTION DIAGRAM ....................................................................................................................... 10
3. BASIC ITEMS FOR SERVICE.........................................................................................................................11
3.1 CHECK POINTS AFTER SERVICING......................................................................................................11
3.2 PCB LOCATIONS .....................................................................................................................................11
3.3 JIGS LIST ................................................................................................................................................ 12
3.4 CLEANING............................................................................................................................................... 12
B 4. BLOCK DIAGRAM.......................................................................................................................................... 14
4.1 BLOCK DIAGRAM ................................................................................................................................... 14
5. DIAGNOSIS.................................................................................................................................................... 18
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 18
5.2 ERROR CODE LIST ................................................................................................................................ 19
5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 21
6. SERVICE MODE ............................................................................................................................................ 22
6.1 CD TEST MODE ...................................................................................................................................... 22
6.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 25
7. DISASSEMBLY .............................................................................................................................................. 27
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 32
8.1 PCL OUTPUT CONFIRMATION.............................................................................................................. 32
C 9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 34
9.1 PACKING ................................................................................................................................................. 34
9.2 EXTERIOR(1) .......................................................................................................................................... 36
9.3 EXTERIOR(2) .......................................................................................................................................... 38
9.4 CD MECHANISM MODULE..................................................................................................................... 40
10. SCHEMATIC DIAGRAM ............................................................................................................................... 42
10.1 OVERALL CONNECTION DIAGRAM(GUIDE PAGE) ........................................................................... 42
10.2 KEYBOARD UNIT.................................................................................................................................. 48
10.3 CD MECHANISM MODULE(GUIDE PAGE) .......................................................................................... 50
10.4 WAVEFORMS ........................................................................................................................................ 56
11. PCB CONNECTION DIAGRAM.................................................................................................................... 60
11.1 TUNER AMP UNIT................................................................................................................................. 60
D
11.2 KEYBOARD UNIT .................................................................................................................................. 64
11.3 CD CORE UNIT(S10.5COMP2-iPod) .................................................................................................... 66
12. ELECTRICAL PARTS LIST .......................................................................................................................... 68
DEH-50UB/XS/EW5
4
1 2 3 4
5 6 7 8
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A
- Service Precaution
1. You should conform to the regulations governing
the product (safety, radio and noise, and other
regulations), and should keep the safety during
servicing by following the safety instructions
described in this manual.
2. Before disassembling the unit, be sure to turn off
the power. Unplugging and plugging the connectors
during power-on mode may damage the ICs inside
the unit.
3. To protect the pickup unit from electrostatic discharge
during servicing, take an appropriate treatment B
(shorting-solder) by referring to "the DISASSEMBLY".
4. After replacing the pickup unit, be sure to check the
grating.
5. Be careful in handling ICs. Some ICs such as MOS
type are so fragile that they can be damaged by
electrostatic induction.
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
D
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
DEH-50UB/XS/EW5
7
5
5 6 8
1 2 3 4
2. SPECIFICATIONS
2.1 SPECIFICATIONS
A
Backup current
.................................... 5 mA or less
DEH-50UB/XS/EW5
6
1 2 3 4
5 6 7 8
DEH-50UB/XS/EW5
7
7
5 6 8
1 2 3 4
DEH-50UB/XS/EW5
8
1 2 3 4
5 6 7 8
BPZ20P060FTC
DEH-50UB/XS/EW5
7
9
5 6 8
1 2 3 4
DEH-50UB/XS/EW5
10
1 2 3 4
5 6 7 8
4 Check whether no disc is inside the product. The media used for the operating check must be
ejected.
5 Appearance check No scratches or dirt on its appearance after
receiving it for service.
See the table below for the items to be checked regarding audio:
B Keyboard Unit
C CD Core Unit
(S10.5COMP2-iPod)
Unit Number : YWM5189
Unit Name : Tuner Amp Unit
Unit Number :
Unit Name : Keyboard Unit F
Unit Number : CWX3526
Unit Name : CD Core Unit (S10.5COMP2-iPod)
DEH-50UB/XS/EW5
7
11
5 6 8
1 2 3 4
- Grease List
Name Grease No. Remarks
Grease GEM1024 CD Mechanism Module
B
Grease GEM1045 CD Mechanism Module
3.4 CLEANING
- Jigs List
Name Jig No. Remarks
Test Disc TCD-782 Checking the grating
C Before shipping out the product, be sure to clean the
L.P.F. Checking the grating (Two pieces)
following portions by using the prescribed cleaning
tools:
Portions to be cleaned Cleaning tools
CD pickup lenses Cleaning liquid : GEM1004
Cleaning paper : GED-008
- Grease List
Name Grease No. Remarks
Grease GEM1024 CD Mechanism Module
Grease GEM1045 CD Mechanism Module
D
DEH-50UB/XS/EW5
12
1 2 3 4
5 6 7 8
DEH-50UB/XS/EW5
7
13
5 6 8
1 2 3 4
4. BLOCK DIAGRAM
4.1 BLOCK DIAGRAM
A
A TUNER AMP UNIT
VDD
CE1
CE2
SL
LDET
TUNPDO
TUNPDI
TUNPCK
7 6 13 5 10 9 8 11 14 18 19 20 21
CE1
DI
NC
CK
CE2
ROM_VDD
SL
LDET
DO
RDS_CK
RDS_DATA
RDS_LOCK
RDS_HSLK
FM/AM TUNER UNIT
OSC LPF
B
ANTENNA CN401
AM ANT
1 FMRF
1 ATT
2,3
IC2
IC1 2.5V
FM ANT
3 3.3V
ATT Lch
23
FMRF MIXER, IF AMP DET, FM MPX,
RDS DECODER
RF adj
ANT adj
T51 CF52
V
AUDIOGND
IC4
OSCGND
VDD_3.3
DGND
C
VCC
NC
2 12 15 22 16 4 17
VDD3.3V
TUNL
VCC
CDL
CN621
6
REAR 5 AUXL AUXL
AUX 4 AUXGND AUXGND
3 KEY1 34
KEYD
WIRED 2 KEY2 94
KEYAD
REMOTE 1
USB5V SYSTEM V
IC501 CONTROLLER
BD9781HFP IC 601(2/2)
1 PEG408A
CN252 B.UP VIN
US5V 5 4 2
5 VOUT VIN SW 41
5 7 28 MUTE
D 6
FB
INV
EN SYNC
IC251
USB R5523N001B
EN 1 24
USBCTL
FLG 3 25
C CD CORE UNIT(S10.5COMP2-iPod) 4
USDM
FLG
SYSPW
48
USDP
RF-AMP, CD DECODER, 3
MP3/WMA DECODER,
DIGITAL SERVO / DATA PROCESSOR CPU,
PICKUP UNIT USB HOST CONTROLLER
(P10.5)(SERVICE)
USBXTAL 1
VDD2
LASER CN101 X205
DIODE LD- 141 48MHz
15 15 Q101 LD /USBXTAL 2
MD 142 Q102
5 5 PD
REFO 133 VCC VDD2
VREF 8 8 REFOUT
AC,BD,E,F 39
HOLOGRAM /PUEN
UNIT
B.UP
FOM
3 3
FOM CN701 CN701
FOP
CD
FOP LOUT CDL
MONITOR
FOCUS ACT. 2 2 DRIVER LOUT
55
13 7 51
E DIODE TRACKING ACT.
TOP
1 1 TOP ILMPW
TOM
4 4
TOM IC301 5 DP DP
LD+ BA5839FP IC201 DP 16 4
14 14 TD,FD
12
FOM
PE5611B DM
4 DM
17 3 DM
11 SD,MD
FOP
14 VDD
TOP
13
TOM VDD2 CD3.3V REGULATOR
SPINDLE Q201
MOTOR M VDD CDVDD 3 IC702
VDD3 9 11 1
16 22 28 NJM2885DL1-33 VDD
SOP LOEJ
15 LOEJ
SOM 21 20
18 17
LOAD/ CARRIAGE LCOP CLCONT CLCONT /ADENA 4
MOTOR M 17
LCOM CONT
9 41 ROT0
CONT 16 /RESET CDRST 23 3
/RESET 8 12 CDRST ROT1
DEH-50UB/XS/EW5
14
1 2 3 4
5 6 7 8
SYSTEM CN351
CONTROLLER
IC 601(1/2)
PEG408A MUTE
SWL SWL
CE2 65
TUNPCE2 BZ601
5 RCA OUT
CE1 BUZZER
MUTE
66
TUNPCE1 Q351
TUNPDO 68
TUNPDI PEE 26
TUNPDI 69 Q454
TUNPDO
TUNPCK 67
TUNPCK
LDET 74
LDET XIN
15 B
SL 97 SL X601
13 15MHz
XOUT VDD REGULATOR
Q911
VDD
Q401 Q912
RDS_CK 73
RCK
Lch RDS_HSLK
23 78 47
RDS57K DALMON
Q402
RDS_DATA 77 BSENS CN901
RDSDT B.UP
18 B.UP
BSENS 16 16
RDS_LOCK 76 BACK UP
RDSLK Q931
75 ACC
ASENS 14 14
ACC
ASENS
RESET
TEL MUTE
2 IC961 1 12 Q951
VDD RESET
S-80835CNMC-B8U TEL
42
TELIN 9 9
TEL
C
ELECTRONIC VOLUME/
SOURCE SELECTOR
15 15
B.UP GND
POWER AMP 6,20
TUNL 6 IN2_L
12 VCC 23 FL2 FL-
Pre/SW_L
FL- 7 7
CDL 7 IN1_L FL-
21 FL1 FL+
10 14 IC 301 FL+ 5 5
FL+
Front_L FLIN 3 RL2 RL-
11 12
PAL007C RL- 8 8
IC151 Rear_L RLIN 5 RL1 RL+ RL-
PML018A RL+ 6 6
AUXL 2 MUTE STBY B.REM RL+
IN5+_L
AUXGND 1 22 4 25 BREM
IN5-_L 11 11
B.REM
SYSTEM VST,VCK,VDT
ONTROLLER
IC 601(2/2)
PEG408A
MUTE
Q451
41
MUTE
RR RR
D
VCC8.4V REGULATOR
- +
VCC
2 IC921 1 3.3V REGULATOR BACK FR FR
TL B.UP
NJM2388F84 UP - +
3 IC401 1
4 VDD3.3V
NJM2885DL1-33
VCC B. FL FL
48 REM - +
SYSPW
GND ACC RL RL
- +
B KEYBOARD UNIT
CN902 CN1802
ILM+B
Q841
ILM+ ILM+ ILLUMI
B.UP 9 2 KEY MATRIX
S1801 S1802 S1803
51 EJECT TA/NEWS SOURCE
ILMPW
S1805 S1806
E
Q842 S1804
BACK/DISP MUTE LOC/RPT
S1810
ROTARY S.Rtrv
COMMANDER
S1827
KDT1-3
82 JOYST JOYST
JOYST 4 7
SWVDD SWVDD
SWVDD 3
VDD 8
Q851 47 54
VDD X0
3 46 X1801
49 OPT IN IC1803 V3 5MHz
SWVDD 55
GP1UX51RK 1 57
REM LCD DRIVER/ X1
Q852 REMOTE CONTROL KEY CONTROLLER
NT SENSOR IC1801
35 DPDT DPDT 50 PD6538A
DPDT 5 6 SI LCD
36 KYDT KYDT 49 LCD1801
F
KYDT 6 5 SO
19 DSENS DSENS
DSENS 10 1
DEH-50UB/XS/EW5
7
15
5 6 8
1 2 3 4
RDS_CK
RDS_LOCK
CE2
CE1
RDS_HSLK
CK
LDET
ROM_VDD
SL
DI
DO
NC
RDS_DATA
A
IC 3 EEPROM IC 5
5.0V 5V t 3.3V
OSC LPF
AM ANT FMRF
1 ATT
Rch
24
IC 2
2.5V
FM ANT IC 1
3 3.3V
ATT Lch
23
FMRF MIXER, IF AM P DET, FM MPX,
B RDS DECODER
RF adj
ANT adj
T51 CF52
AUDIOGND
IC 4
OSCGND
VDD_3.3
3.3V
DGND
VCC
NC
2 12 15 22 16 4 17
DEH-50UB/XS/EW5
16
1 2 3 4
5 6 7 8
- LCD(YAW5090)
E
SEGMENT
COMMON
DEH-50UB/XS/EW5
7
17
5 6 8
1 2 3 4
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A
Power ON
Vcc = 5 V
Pin 16
B bsens
Pin 18
bsens = L
asens
Pin 75
asens = L
C
dsens
Pin 19
dsens = L
300 ms
SWVDD H
D
Pin 49
300 ms
Source ON
SYSPW H
Pin 48
DEH-50UB/XS/EW5
18
1 2 3 4
5 6 7 8
DEH-50UB/XS/EW5
7
19
5 6 8
1 2 3 4
iPod error
USB error
All the files in the USB device are protected Transfer the songs not protected by DRM to
PROTECT
by DRM the USB device.
The connected USB device is not supported Connect a USB device that is compliant as a
N/A USB
by this unit Mass Storage Class.
F
USB device is not formatted with FAT16 or
ERROR-23 Format the USB device with FAT16 or FAT32.
FAT32
DEH-50UB/XS/EW5
20
1 2 3 4
5 6 7 8
AUX
AUX
W/R
USB INPUT
ANTENNA
1 3 5 7 9 11 13 15
WIRED REMOTE INPUT
2 4 6 8 10 12 14 16
C
POWER SUPPLY
1. FR+ 9. MUTE
2. RR+ 10. NC
REAR OUTPUT OR 3. FR- 11. B.REM
SUBWOOFER OUTPUT 4. RR- 12. NC
5. FL+ 13. NC
6. RL+ 14. ACC
7. FL- 15. GND
8. RL- 16. B.UP
D
DEH-50UB/XS/EW5
7
21
5 6 8
1 2 3 4
6. SERVICE MODE
6.1 CD TEST MODE
A
DEH-50UB/XS/EW5
22
1 2 3 4
5 6 7 8
Outline) Use the direct FUNCTION keys to display, select, or issue the KEY 1 - 6.
• For convenience, a name of each direct FUNCTION key is shown as "A", "B", and "C".
B
• How to issue the 1 - 6 keys for the CDS source:
(The areas below are overwritten and displayed on character strings for the normal mode display.)
1 During the slave test mode, the key name "K1" is shown at the left by default.
In this condition, press the A key to toggle K1 - K6, and select a command to be sent to the slave.
C O M P A C T D I S C
K 1 ! T - ! ! ! ! ! ! • The one-line model shows only the bottom column.
FOLDER TRK MINUTE SECOND
A key
C O M P A C T D I S C C
K 6 ! T - ! ! ! ! ! !
2 During the K1 - K6 key names are displayed, press the B key and issue the selected command.
D
3 Press the C key to change display/non-display of key names.
When the non-display mode is selected for the K1 - K6 key names, "A key" and "B key" are invalid.
C O M P A C T D I S C
K 1 ! T - ! ! ! ! ! !
C key
C O M P A C T D I S C
F - ! ! T - ! ! ! ! ! ! • Pressing the A key or B key does not work.
DEH-50UB/XS/EW5
7
23
5 6 8
1 2 3 4
- Flow Chart
[Key] [SOURCE] + [RPT] + Reset or
[SOURCE] + [RPT] + BU + ACC
Contents Test Mode In
A Display
[CD] or [SOURCE]
Source On
C *6
[BAND] [2]
Power Off Tracking Open
*9) TYP (1X) -> 2X -> 1X *10) OFF(TYP) -> FORCUS -> TRACKING
TRK MIN SEC TRK
22MIN22SEC22 TRK
11MIN11SEC11 TRK MIN SEC TRK
70MIN70SEC70 TRK
71MIN71SEC71
DEH-50UB/XS/EW5
24
1 2 3 4
5 6 7 8
Note :
The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism
module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU
unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the
PU unit must be changed, the grating should be checked using the procedure below.
Purpose :
To check that the grating is within an acceptable range when the PU unit is changed.
Symptoms of Mal-adjustment : B
If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform
track search operations, or taking a long time for track searching.
Method :
Measuring Equipment Oscilloscope, Two L.P.F.
Measuring Points E, F, REFO1
Disc TCD-782
Mode TEST MODE
CD CORE UNIT
REFO1 C
E F L.P.F.
Xch Ych
E 100 kohm
Oscilloscope
VREF 390 pF
F 100 kohm
VREF 390 pF
L.P.F. D
Checking Procedure
1. In test mode, load the disc and switch the 3 V regulator on.
2. Using the -> and <- buttons, move the PU unit to the innermost track.
3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance
adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the
fourth press.
4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase
E
difference is within 75 degrees. Refer to the photographs supplied to determine the phase angle.
5. If the phase difference is determined to be greater than 75 degrees try changing the PU unit to see if there is any
improvement. If, after trying this a number of times, the grating angle does not become less than 75 degrees then the
mechanism should be judged to be at fault.
Note
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be
seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the
average angle.
Hint
Reloading the disc changes the clamp position and may decrease the "wobble".
DEH-50UB/XS/EW5
7
25
5 6 8
1 2 3 4
0 degrees 30 degrees
45 degrees 60 degrees
75 degrees 90 degrees
DEH-50UB/XS/EW5
26
1 2 3 4
5 6 7 8
7. DISASSEMBLY
- Removing the Keyboard Unit (Fig.1,2)
A
Fig.1
Knob Unit
1 Remove the four screws.(Fig.2)
1 1
Remove the Cover B
and then remove the Keyboard Unit.
Fig.2
1 1
Cover
Fig.3
Holder
Fig.4
E
Fig.5
DEH-50UB/XS/EW5
7
27
5 6 8
1 2 3 4
A
Push the place of the arrows
and then remove the Panel Assy.
Fig.6
Panel Assy
Fig.7
C
1
1
D
1
Fig.8
CD Mechanism Module
DEH-50UB/XS/EW5
28
1 2 3 4
5 6 7 8
A
1 Remove the three screws.(Fig.9)
1 1
1 Fig.9
3
2
C
Fig.10
DEH-50UB/XS/EW5
7
29
5 6 8
1 2 3 4
B
B
Damper
A
Carriage Mechanism
E Damper
Lower Frame
DEH-50UB/XS/EW5
30
1 2 3 4
5 6 7 8
Screw B
CD Core Unit
Solder
Poly Washer
Change Arm
Inner Holder
Pickup Lock Arm
D
Feed Screw
Planet Gear
E
Pickup Rack
Chassis
Pickup F
DEH-50UB/XS/EW5
7
31
5 6 8
1 2 3 4
- PCL Output
In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode
cancelled), shift the TESTIN IC601(Pin 63) terminal to H.
The clock signal is output from the PCL terminal IC601(Pin 39).
The frequency of the clock signal is 468 750 Hz that is one 32th of the fundamental frequency.
The clock signal should be 468 750 Hz (-10 Hz, +15 Hz)
If the clock signal out of the range, the X’tal (X601) should be replaced with new one.
DEH-50UB/XS/EW5
32
1 2 3 4
5 6 7 8
DEH-50UB/XS/EW5
7
33
5 6 8
1 2 3 4
9.1 PACKING
13%
DEH-50UB/XS/EW5
34
1 2 3 4
5 6 7 8
DEH-50UB/XS/EW5
7
35
5 6 8
1 2 3 4
9.2 EXTERIOR(1)
A
B
A
B
DEH-50UB/XS/EW5
36
1 2 3 4
5 6 7 8
11 Screw BSZ26P060FTC B
12 Screw BSZ26P200FTC
13 Pin Jack(CN351) CKB1057
14 Plug(CN901) CKM1376
15 Connector(CN701) CKS3833
16 Connector(CN902) CKS4944
17 Antenna Jack(CN401) CKX1056
18 FM/AM Tuner Unit(Y401) CWE2097
19 Holder CND4324
20 Holder XNC7030
C
26 Button(DETACH) CAC4836
27 Spring CBH2367
28 Spring CBH2961
29 Spring CBH2962
D
30 Cover CNN1665
31 Arm CNV9311
32 Arm CNV9312
33 Chassis Unit YXA5330
34 Panel YNS5328
35 IC(IC301) PAL007C
36 IC(IC921) NJM2388F84
37 Transistor (Q702,Q911) 2SD2396
E
DEH-50UB/XS/EW5
7
37
5 6 8
1 2 3 4
9.3 EXTERIOR(2)
B
B
DEH-50UB/XS/EW5
38
1 2 3 4
5 6 7 8
16 Cover YNS5323
17 Lighting Conductor YNV5144
18 Connector(CN1802) CKS4943
19 Cushion XNM7049
20 LCD(LCD1801) YAW5090
C
21 Holder YNC5050
22 Sheet YNM5101
23 Lighting Conductor YNV5143
24 Connector YNV5145
DEH-50UB/XS/EW5
7
39
5 6 8
1 2 3 4
A 19
27
5
19 5
(1)
19
29 A
13 48 20
5
19 57
(1)
B B
66 16
13
(1)
9 25
54
44 (1)
23
31 C
44 9 (2)
15 58
73
72
60
8 69 21
(2)
C 46 71 70
38 33
39 62
70 7
68 63
50
40 4
36 (2) (1)
28 (1)
B
32 (1)
52 53
(1) 4
(2) 47 (1) (2)
18 17 35
(1)
37 45 C
61
14 6
41 12
D (1)
5 49 A
8 64 (2)
(1)
51 65
D
55 (2)
(1)
51 59
(1)
43 10
C (1)
E
74 56
D (2)
1
(1)
3 22
2
E 34 (1)
(1)
19 (1) (1)
26
11
42
24 (1)
(1)
(1)
30
19
67
F E
24
(1) : GEM1024
(2) : GEM1045
DEH-50UB/XS/EW5
40
1 2 3 4
5 6 7 8
31 Arm CND2586
32 Bracket CND2587
33 Arm CND2588
34 Lever CND2589
35 Holder CNV9522
36 Gear CNV7207
37 Gear CNV9513
38 Gear CNV7209 E
39 Gear CNV9514
40 Gear CNV9515
41 Gear CNV9516
42 Rack CNV9517
43 Arm CNV7216
44 Roller CNV8189
45 Gear CNV9518
46 Guide CNV9519
47 Gear CNV7595 F
48 Guide CNV9520
49 Arm CNV7805
DEH-50UB/XS/EW5
7
41
5 6 8
1 2 3 4
A-a A-b
Large size
SCH diagram
A-a
USBGND
USBGND
TUNR
CDGND
CDGND
CDVDD
BRXEN
CDRST
BDATA
Rch
AGND
PGND
BSRQ
LCH
BSCK
BRST
24
CDR
TUNL
CDL
DM
VD
VD
DP
Lch BEG
23 RDS-HSLK
BEGND
6 C1
5 B2
4 E2
RHSLK
RDS
19
18
17
16
15
14
13
12
11
10
22
9
8
7
6
5
4
3
2
1
RDS-LOCK
RDS_HSLK
6 C1
5 B2
4 E2
RLK GND
CN701 USGND3
BSRQ
UMH1N
BSCK
21 R413
BRST
220 RDS-CK
CDR
Q401
CDL
DM
UG
RDS_LOCK
AG
PG
VD
DP
RDAT
UMH1N
20 R415
A-a A-b Detailed page 220 RDS-DATA
Q402
RDS_DATA RCK GND
19
E1 1
B1 2
C2 3
CDVDD
FM/AM TUNER UNIT
BRXEN
CDRST
BDATA
R408
R410
R409
R411
RDS_CK
22K
22K
22K
22K
18 T3V
E1 1
B1 2
C2 3
VDD
VDD_3.3
17
COMP TUNG TUNPDO Q702
16 2SD2396
DGND DO NJM2885DL1-33
15 R401 Q701 GND
B DO GND IC401
2 GND
T5V
3 OUT
14 680 6 2E 1
1 IN
ROM_VDD 2C C704
OSCG
C407
R01
13 5 2B 2
L403 R414
VCC
OSCGND 1B 1
LDET R402 R701 4
C703
100/10
12 1C 3
R047
LDET 4R7(1/4W) 1E
C408
DI GND R403
22/10
47/6R3
R01
C402
C401
C403
C404
R01
4R7
11 680 270
D701
HZS7L(C3)
DI CK (1/4W)
10 680 R404 RT3T22M
CK CD/USB:+0.6dBs
C701
9 CE1 R405 GND GND GND C705
680 LDET
IN5+_R 28
IN4+_R 27
IN4-_R 26
IN3_R 25
IN2_R 24
IN1_R 23
CE1 R421 0R0 TUNPDI
8 680 TUNPCK 1
WC CE2 CE1 B.UP
7 R406 CE2 R703
CE2 GND
IC151
6 SL R407 4R7K
680 SL
IN5+_L
IN4+_L
IN5-_L
IN4-_L
R704
IN3_L
SL T8V L401
VCC
5 1K
VCC 100K
4 FM VDD R705
JUMPER
C405
C406
100/10
1
2
3
4
5
6
FM_ANT
R1
3 RFG 4R7K
RF_GND R706 V
AM
NJM2885DL1-33
2 L402
AM_ANT 100K
1
GND
1
R714 R707
L161
2 1
IC702
2 GND
3 OUT
ZNR401
C153
C156
CN401
R22
1
1 IN
R22 VCC1
GND 100K 100K
R709
R711
R713
220
220
IMSA-6801-01Y901
1K
3
C154
C159
C155
3
1
GND GND
C709
C710
R47
22/10
C708
1
R708
R710
R712
220
220
220
C412
AUXGND
VDCONT
1
BRXEN
CDRST
BDATA
/BSRQ
/BRST
USDM
USDP
TUNR
AUXR
BSCK
AUXL
TUNL
GND
GND GND
SYNC
RST
FLG
VDCONT
CDRST
ROT0
ROT1
USBCTL
/DSENS
/BSENS
D621
EZJZ1V270RM VDD
D622 L601
EZJZ1V270RM
D623
R967
1K
RST
AUX1:+2.2dBs
C BZ601
22K
R625
4700P
R633
C621
EZJZ1V270RM
0R0
GND 15MHz
REAR AUX AUXR R631 1 R618
AUXR 1
AUXL R632 2 1K
100 AUXL 2
CN621
C601
C602
18P
18P
R616
47K
4700P
100
C622
R626
C623
22K
R1
R602
AUXGND
10K
5 R627 X601
FOR WIRED REM.
AUXGND CPV1062
4 GND
3 WREM1 R621 1K GND YSS5002
2 KEY1 BUZZER
R603
WREM2
10K
1 R622 1K KEY2
WREMG
1K
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
WIRED REM.
9
8
7
6
5
4
3
2
1
GND WIRED REM.
NC
NC
NC
NC
NC
NC
NC
NC
NC
RX
SYNC
VDCONT
XOUT
TX
ROT0
ROT1
100
BYTE
VCC
USBCTL
PEE
CDRST
DSENS
VSS
CNVSS
FLG
RX2
BSENS
BDATA 31
RESET
NMI
XIN
BSO NC 99
32
C604
C605
BSI AVCC
10/16
1
BSCK 33 98
BSCK VREF
KEY1 34 97
KEYD SL
DPDT 35 96
DPDT AVSS
KYDT 36 95
KYDT MODEL
37 94
ILM2 SYSTEM CONTROLLER KEYAD
38 93
NC NC
PCL 39 IC601 92
PCL SSENS
40 91
ASENBO NC
MUTE 41
MUTE
PEG408A NC
90
TELIN 42 89
TELIN NC
/BRST 43 88
BRST RGBST
BRXEN 44 87
BRXEN RGBCK
/BSRQ 45 86
BSRQ RGBDT
US5V 46 85
ANTPW NC
DALMON 47 84
CN252 SYSPW 48
DALMON NC
83
5 SYSPW NC
USDM
ROMDATA
TUNPCE2
TUNPCE1
82
USB
USDM SWVDD 49
TUNPDO
TUNPCK
RDS57K
ROMCK
ROMCS
TUNPDI
4 SWVDD JOYST
TESTIN
RDSDT
ASENS
RDSLK
ILMPW
USDP
ISENS
ELPIN
4 3
NC 81
IPPW
LDET
USDP 50
D OELPW
VCC
RCK
VCK
VDT
VSS
VST
3
NC
NC
NC
NC
NC
NC
USG
2
EZJZ1V800AM
EZJZ1V800AM
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
VDD
1 1 L251 2
D251
D252
4
VOUT
VIN
R5523N001B
C251
R257
C252
10K
R1
R1
IC251
TEST
GND
FLG
EN
R610
47K
GND FLG
R607
1
2
3
680
FLG
C609
GND
47P
R617
C253
R01
47K
GND
US5V R254 USBCTL
USBCTL
5V
680
R604
R605
680
680
R619
0R0
BD9781HFP
B.UP IC501
GND
S5688G
RDS-LOCK
RDS-DATA
RDS-HSLK
D502
VIN
INV
SW
EN
RT
FB
TUNPDO
TUNPCK
RDS-CK
TUNPDI
/ASENS
ILMPW
LDET
1
3
4
5
6
2
VCK
VDT
VST
CE2
CE1
RT
USB5V GND FB
B.UP
L501 SW
R510
82K
3300P
D501
C506
C507
C501 150/6R3
R1
1 Q841 10K
4R7K
C505
R506
R842
100P
68K
E GND INV
2SA1036K
C503 R503
Q842
RT1N141M-11
220P 33K
R502
33K
8R2K
R505
GND
R511 GND
VDD
470
USB5V GND
R808
100K
R811
R849
47K
10K
EZJZ1V270RM
EZJZ1V270RM
EZJZ1V270RM
EZJZ1V270RM
EZJZ1V270RM
EZJZ1V270RM
GND
R813
100K
D810
D801
D802
D803
D804
D809
GND
CN902 DG
DGND 1 GND
IMG
ILMGND 2
SW5V
SWVDD 3
TP1
B JOYST
DPDT
4
5
DPDT
KYDT
R806
2R2K
2R2K
CN1802 KYDT
ROT1
6
TP3
R807 R804 R814
7
TP4 R805 R815
ROT0 2R2K 1K
8
ILMB 2R2K 1K
ILM+ 9
DSEN R825
DSENS 10
1K
A
DEH-50UB/XS/EW5
42
1 2 3 4
5 6 7 8
A-b
2R2/50 820
B
R360
22K
C2
E1
B1
1
2
3
C704
RT3N66M
Q351
1 GND
R359
CN351
6
5
4
C1
B2
E2
22K
SWL C351 R356 R352
2 RCRL
1
Front_R
DATA
Rear_R
Pre/SW_R
PGND
3 SWR
PML018A
4 SWL
Pre/SW_L
IC151
Front_L
Rear_L
IN5+_L
IN4+_L
IN5-_L
IN4-_L
5
IN3_L
IN2_L
IN1_L
RCFR
Vref
Pref
Vcc
Vp
6 RCFL
1
2
3
4
5
6
7
8
9
7 RCG1
10
11
12
13
14
VCC 8
9
FM(10%):-12.0dBs
L161
10
AM(15%):-7.5dBs
C153
C156
R22
CD/USB:-9.3dBs
R22 VCC1
AUX1:-9.7dBs
C154
C159
C155
C160
C163
C162
C165
R151
R152
R153
10/16
47/10
10/16
R1
1K
1K
1K
1
3A
FU353 >
AUXGND
1 2
TUNR
AUXR
AUXL
TUNL
VCK
VDT
VST
601
GND
R301
R303
R304
R306
470
470
470
470
ACGND
B.REM
PGND
PGND
AGND
PGND
PGND
MUTE
STBY
RRIN
FRIN
RLIN
FLIN
VCC
VCC
SVR
RR+
TAB
FR+
RL+
RR-
FL+
FR-
RL-
FL-
IC301
PAL007C
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
1
2
3
4
5
6
7
8
9
R309
VDD
15K(1/4W) GND
6
5
4
3
2
1
NC
NC
NC
NC
NC
L602
ROT0
ROT1
100
C308 C318
NC 99 GND
R47 R47
C604
C605
C606
C607
AVCC
10/16
10/16
R1
1
98 C307 C317
VREF R47
97 R47
SL C306 C316
SL
96
R47 R47
C309
2R2
AVSS
3300/16
R608 C305 C315
C313
C901
95
R1
MODEL
94 100K KEY2 R47 R47
FM(10%):+13.98dBs
C311
C310
2R2
KEYAD
10/16
93
NC Q454 MUTE AM(15%):+18.48dBs
92
SSENS
DTA124EUA CD/USB:+16.7dBs GND
RR2
RR1
FR1
FR2
RL2
RL1
FL1
FL2
91
NC AUX1:+16.3dBs GND
90
NC GND
89
NC R451 R452
VCC
88
S5688G
D903
RGBST 10K 220
87 MUTE S5688G
R453
C451
RGBCK
15K
33/10
86 Q451
RGBDT RT1N241M D904
85
NC FOR WIRED REM. GND 8.4V GND
CONTROL
84
NC NJM2388F84
14.4V
R606
CN901
VOUT
83
10K
IC921
5
GND
NC B.UP
VIN
82
>
JOYST
S-80835CNMC-B8U
N.C2
N.C1
RDS57K
JOYST
RDSDT
ASENS
RDSLK
NC 81
LDET
IC961
VCC
GND2 GND1 16 16
OUT
VDD
VSS
C922
R922
C923
C924
220/10
100/16
R01
R01
75
76
77
78
79
80
47K
8.4V ACC 15 15
D901 ACC
1
2
3
VDD
AANT 14 14
S5688G
GND 13 13
8R2K
R962
R047
C961
D902
5V 2SD2396 BUP3 BREM 12 12
RST Q911 B.REM
S5688G 11 11
VDD
GND
C962
10
10/16
D911 TEL 10
GND
R911
R912
22K
TEL
1R5K(1/4W)
3 1C
C911
C913
4 7 7
47/10
1B RL1
RL1 RL+
HZS6L(B2)
2 2B 5 6 6
2C FL1
FL1 FL+
D912
C912
R01
1 2E 6 5 5
RR2 RR-
SYSPW RR2
Q912 4 4
FR2
FR2 FR-
DALMON 3 3
RR1 RR+
GND VDD RR1
2 2
FR1
0R0
FR1 FR+
1 1
R613
100K
RDS-LOCK
RDS-DATA
RDS-HSLK
/ASENS
LDET
VDD
R931
R932
100K
100K
BS2 BS1 RR RR
/ASENS R933 D931 - +
BACK FR FR
C1
B2
E2
100K HZS7L(C3)
6
5
4
UP - +
RT3CLLM
R934
47K
Q931
VDD
SWVDD B. FL FL
GND REM - +
AS2AS1
1
2
3
C2
E1
B1
4R7K
R853
C851
R852
R1
4R7K
R936
R937
47K
Q851
2SA1036K
Q852 SWVDD ASENS
RT1N141M-11 GND
BSENS
GND
R811
R849
47K
10K
VDD
R952 R953 D951
L951 R955
1K 4R7K
15K(1/4W)
R813
R951
100K
MC2848-11
47K
Q951
2SA1037K
TELIN GND
GND TEL MUTE
GND
JOYST
DPDT NOTE :
KYDT
Symbol indicates a resistor. Decimal points for resistor The > mark found on some component parts indicates
ROT1
ROT0
No differentiation is made between chip resistors and and capacitor fixed values the importance of the safety factor of the part.
discrete resistors. are expressed as : Therefore, when replacing, be sure to use parts of
/DSENS
Symbol indicates a capacitor. 2.2 t 2R2 identical designation.
No differentiation is made between chip capacitors and 0.022 t R022
discrete capacitors. F
A
DEH-50UB/XS/EW5
7
43
5 6 8
4 3 2 1
44
DEH-50UB/XS/EW5
IN4+_R
IN5+_L
1 3 IN4-_R 26
C604
IN4+_L
4 25
1
IN3_R
1 IN4-_L
A-b
TUNL C155 5 24
10/16 IN2_R
IN3_L
R22 VCC1 6 IN1_R 23
C605 L161
IN2_L
VCC
7 GND 22
10/16 IN1_L
8 STB 21 F
GND
GND
Vref
C160 9 CLK 20
L602
R1
Vcc
10 DATA 19
C163 Front_L
11 Front_R 18
47/10 Rear_L
12 Rear_R 17
C606
Pre/SW_L
C162 13 Pre/SW_R 16
R1 Vp
10/16 14
10/16 PGND 15
Pref
VDD
C165
C607
PML018A
VDT R151
100K
R608
1K
FOR WIRED REM.
VCK R152
606
1K
0K
VST R153
1K
KEY2
SL
E
MUTE
AUX1:-9.7dBs
CD/USB:-9.3dBs
AM(15%):-7.5dBs
FM(10%):-12.0dBs
Q451
VCC
RT1N241M
GND
10K
R451
R301
Q454 470
R453 R303
DTA124EUA
470
5
GND
15K
220
R452
33/10
4
C451
D
MUTE
R304
470
R306
470
A-a A-b
C305
C306
C307
C308
R47
R47
R47
R47
C316
R47
C315
C318
C317
R47
R47
R47
SWL
SWR
8.4V
C351
C352
2R2/50
2R2/50
NTROL
820
820
R356
R351
D
UT
MUTE
N
R309
15K(1/4W)
0R0
R352
IC301
IC921
AUX1:+16.3dBs
PAL007C
CD/USB:+16.7dBs
Q351
FM(10%):+13.98dBs
AM(15%):+18.48dBs
NJM2388F84
1 TAB 6 1
C1 E1
2 PGND 5 2
RL2 B2 B1
3 RL- 4 3
E2 C2
4 STBY RT3N66M
RL1
5 RL+
6 VCC
RR2
A
7 RR-
B
8 PGND
GND
RR1 R359 R360
9 RR+
10/16
10 SVR 22K 22K
GND
C311
11 RRIN
12 RLIN
13 AGND
GND
GND
14 FLIN
14.4V
15 FRIN
B UP
C310 C309
3A
16 ACGND
FU353
CEK1286
FR1 2R2 2R2
2
17 FR+
3300/16
18 PGND
>
FR2 C313
19 FR-
S5688G C901
20 VCC
GND
D903 FL1 R1
9
8
7
6
5
4
3
2
1
10
D904
FL2
S5688G
23 FL-
CN901
SWL
24
RCFL
PGND
SWR
RCRL
RCG1
RCFR
RCRR
GND
25 B.REM A
CN351
4 3 2 1
DTA124EUA CD/USB:+16.7dBs GND
RL2
RL1
RR2
RR1
FR1
FR2
FL1
FL2
AUX1:+16.3dBs GND
GND
R451 R452
VCC
10K 220
MUTE
D903
S5688G
S5688G
15K
R453
C451
Q451
33/10
RT1N241M D904
5
4
IC921
10K
B.UP CN901
R606
CONTROL
GND
VOUT
VIN
2
JOYST
4
3
2
1
L901 BUP2 BUP1
N.C2
N.C1
>
600 H YEK5001 BUP
16 16
IC961
S5688G GND2 GND1
VCC
10A GND
OUT
VDD
VSS
15 15
5
5
8.4V ACC
R01
47K
R01
D901 ACC
C921
C922
R922
C923
C924
1
2
3
14 14
220/10
100/16
AANT
S-80835CNMC-B8U
S5688G
VDD
GND 13 13
D902
12 12
8R2K
R962
R047
C961
5V 2SD2396 BUP3 BREM
3
RST Q911 B.REM
S5688G 11 11
GND
VDD
D911 TEL 10 10
GND TEL
C962
10/16
22K
RT3T22M 9 9
R911
R912
13V RL2
RL2 RL-
8 8
VDD 1E FL2
GND RESET FL2 FL-
3 1C 4 7 7
1R5K(1/4W)
1B RL1
RL1 RL+
C911
C913
47/10
2 2B 5 6 6
1000/16
2C FL1
FL1 FL+
1 2E 6 5 5
R01
RR2
D912
C912
4
SYSPW RR2 RR-
HZS6L(B2)
Q912 4 4
FR2
FR2 FR-
DALMON 3 3
RR1 RR+
GND VDD RR1
2 2
FR1
FR1 FR+
1 1
R613
100K
VDD
6
6
BS2 BS1 RR RR
R931
100K
R932
100K
/ASENS R933 D931 - +
BACK FR FR
6
5
4
C1
B2
E2
100K HZS7L(C3) UP - +
47K
B.
R934
SWVDD FL FL
VDD
Q931
GND REM - +
1
2
3
AS2AS1
RT3CLLM
E1
B1
C2
5V L852 R851 /BSENS R935 D932 R938 GND ACC RL RL
- +
15K 47K HZS7L(A1) 1K (1/4W)
R1
R853
2R2K
C851
R852
4R7K
Q851
47K
R936
R937
4R7K
2SA1036K
Q852 SWVDD ASENS
RT1N141M-11 GND
BSENS
GND
DEH-50UB/XS/EW5
VDD
D951
7
7
R952 R953
L951 R955
1K 4R7K
15K(1/4W)
Q951 MC2848-11
47K
R951
2SA1037K
JOYST
DPDT NOTE :
5
KYDT The > mark found on some component parts indicates
Symbol indicates a resistor. Decimal points for resistor
ROT1
ROT0
No differentiation is made between chip resistors and and capacitor fixed values the importance of the safety factor of the part.
discrete resistors. are expressed as : Therefore, when replacing, be sure to use parts of
/DSENS identical designation.
Symbol indicates a capacitor. 2.2 t 2R2
No differentiation is made between chip capacitors and 0.022 t R022
discrete capacitors.
8
8
A-a A-b
A-b
45
E
A
D
C
F
B
F
E
B
A
D
C
46
A-a A-b
A-a
A-b
1
1
VD
VD
BSRQ
BRST
BSCK
BRXEN
BDATA
CDRST
CDVDD
CDGND
CDR
AGND
CDL
CDGND
PGND
DP
DM
USBGND
USBGND
23 BEG
RDS-HSLK
BEGND RHSLK
9
8
7
6
5
4
3
2
1
22
19
18
17
16
15
14
13
12
11
10
RDS RDS-LOCK
6 C1
5 B2
4 E2
RDS_HSLK RLK GND USGND3
21 R413 220 RDS-CK CN701
6 C1
5 B2
4 E2
RDS_LOCK RDAT
VD
UG
AG
PG
DP
DM
BSRQ
BRST
BSCK
CDR
CDL
20 R415 RDS-DATA
Q401
220
UMH1N
RDS_DATA RCK GND
19
Q402
UMH1N
RDS_CK
E1 1
B1 2
C2 3
T3V
22K
22K
22K
22K
18
R408
R410
R409
R411
VDD_3.3
BRXEN
BDATA
CDRST
CDVDD
E1 1
B1 2
C2 3
17
VDD
COMP TUNG TUNPDO Q702
16 2SD2396
DGND DO NJM2885DL1-33
15 R401 Q701 GND
DO GND IC401
14 T5V 6
680 2E 1
ROM_VDD 2C C704
13 OSCG 5 2B 2
3 OUT
2 GND
1 IN
L403 R414 GND
1
R01
OSCGND 1B 1
C407
12 LDET R402 R701 4
VCC
1C 3
LDET 4R7(1/4W) 1E
C703
11 DI GND R403
R047
100/10
680 270
R01
C408
R01
4R7
DI
22/10
C402
C401
C403
C404
CK R404 (1/4W)
2
2
10 RT3T22M
47/6R3
680
D701
CK CE1 CD/USB:+0.6dBs
9 R405 680 GND GND GND C705
LDET
C701
CE1
HZS7L(C3)
R421 0R0 TUNPDI
8 680 TUNPCK 1
WC CE2 CE1 B.UP
STB 21
7 R406 R703
GND 22
CE2
IN3_R 25
IN2_R 24
IN1_R 23
DATA 19
GND
IN4-_R 26
CE2
IN5+_R 28
IN4+_R 27
6 SL R407 4R7K
680 SL
SL R704
IC151
5 T8V 1K L401
IN5-_L
IN5+_L
IN4+_L
IN4-_L
IN3_L
IN2_L
IN1_L
Vref
Vcc
VCC 100K
VCC
4 FM VDD R705
1
2
3
4
5
6
7
8
9
FM_ANT
10
R1
3 RFG 4R7K
C405
C406
RF_GND R706 VCC
100/10
AM L402
JUMPER
2
AM_ANT 100K
1
1
GND R714 R707
ZNR401
1
2 1
L161
R22
GND IMSA-6801-01Y901
3 OUT
2 GND
1 IN
NJM2885DL1-33
1K
220
220
3
2
R709
R711
R713
3
1
1
R1
R22 VCC1
C154
C159
C155
C160
C163
GND GND
10/16
1
R47
C709
C710
22/10
DEH-50UB/XS/EW5
220
220
220
C708
C412
R708
R710
R712
1
GND
GND
VDCONT
/BSRQ
/BRST
BSCK
BRXEN
BDATA
CDRST
USDM
USDP
TUNR
AUXR
AUXGND
AUXL
TUNL
GND GND
3
3
FLG
RST
D621
SYNC
ROT0
ROT1
CDRST
USBCTL
VDCONT
/DSENS
/BSENS
EZJZ1V270RM VDD
D622 L601
EZJZ1V270RM
D623
1K
R967
RST
22K
GND
0R0
15MHz
R625
R633
C621
AUXR R631 1 R618
4700P
REAR AUX AUXR 1
AUXL R632 2 1K
100 AUXL 2
CN621
18P
18P
100
C601
C602
47K
6
R616
R1
22K
5 AUXGND R627 X601
C622
R626
C623
CPV1062
4700P
AUXGND
10K
4
R602
GND
3 WREM1 R621 1K GND YSS5002
2 KEY1 BUZZER
1 WREM2 R622 1K KEY2
10K
R603
WREMG
1K
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
PEE
FLG
RX2
NMI
VCC
XIN
VSS
BSO
SYNC
XOUT
BYTE
ROT0
ROT1
NC 99
32
CDRST
DSENS
BSENS
RESET
CNVSS
BSI AVCC
1
USBCTL
VDCONT
BSCK 33 98
C604
C605
10/16
BSCK VREF
KEY1 34 97
KEYD SL
DPDT 35 96
4
DPDT AVSS
4
KYDT 36 95
KYDT MODEL
37 94
ILM2 SYSTEM CONTROLLER KEYAD
38 93
NC NC
PCL 39 IC601 92
PCL SSENS
40 91
ASENBO NC
MUTE 41 PEG408A 90
MUTE NC
TELIN 42 89
TELIN NC
/BRST 43 88
BRST RGBST
BRXEN 44 87
BRXEN RGBCK
/BSRQ 45 86
BSRQ RGBDT
US5V 46 85
ANTPW NC
DALMON 47 84
CN252 DALMON NC
SYSPW 48 83
5 SYSPW NC
8 7 6 5
47
DEH-50UB/XS/EW5
A-a USB
1
3
4
5
2
USDP
USDM
GND
F
CN252
USG
US5V
USB5V
D251
C501
USB5V
B.UP
D252
L501
C502 D502
150/6R3
C504 EZJZ1V800AM
470
220P
R511
C503
GND
D501
1
33K
R502
GND
RB060L-40
SW
33K
R503
1
VIN
GND
1
4
R505 2
INV
SW
8R2K C505 3
RT
100P 4
L251
FB
GND
IC501
GND
R506 C506 5
FB
BD9781HFP
68K 3300P 6
2
3
INV
7
EN
C507
GND
E R1
0R0
R512
US5V
R617 C251
RT
SYNC
47K R1
R510 C253 IC251
82K R01 1 5
EN VOUT
2
GND
GND
3 4
FLG VIN
680
R254
R507
2R2K
R5523N001B
R257
VDD
USBCTL
10K
C252
R1
FLG
USBCTL
FLG
SYNC
USDP
USDM
TELIN
MUTE
/BRST
/BSRQ
B
BRXEN
SYSPW
SWVDD
D
DALMON
CN1802
ILM+
DGND
ROT0
ROT1
KYDT
DPDT
JOYST
DSENS
SWVDD
ILMGND
CN902
GND
9
8
7
6
5
4
3
2
10
A-a A-b
GND
DG
IMG
TP4
TP3
TP1
ILMB
KYDT
DPDT
DSEN
SW5V
R808
VDD
100K
PCL
49
48
47
46
45
44
43
42
41
40
39
D810
14.1V
EZJZ1V270RM ILMPW 51
D801
PCL
52
BRST
BSRQ
TELIN
MUTE
50 OELPW
SWVDD
BRXEN
EZJZ1V270RM
SYSPW
ANTPW
ASENBO
DALMON
D802 53 ILMPW
ELPIN
C
EZJZ1V270RM 54
D803 ISENS
55 IPPW
VST
EZJZ1V270RM 1
VST
D804
R816
VCK 56
VCK
2SA1036K
EZJZ1V270RM VDT 57
D809 VDT
Q841
58
EZJZ1V270RM ROMDATA
59
ROMCK
1K
R825
R806
2R2K
60
ROMCS
61
10K
R841
B.UP NC
RT1N141M-11
62
Q842
TEST
VCC
R842 R610 63
R807
2R2K
TESTIN
GND
GND
4R7K 47K 64
R805
2R2K
VSS
CE2 65
TUNPCE2
CE1 66
TUNPCE1
IC601
ILMPW R604
R804
2R2K
TUNPCK 67
TUNPCK
PEG408A
1K
680 70
R815
NC
47P
C609
71
NC
72
B
NC
1K
R814
RDS-CK 73
RCK
LDET R619 74
R813 LDET
/ASENS 0R0 75
100K ASENS
RDS-LOCK 76
RDSLK
GND
RDS-DATA 77
RDSDT
RDS-HSLK 78
RDS57K
79
NC
R811 80
NC
JOYST
SSENS
RGBST
RGBDT
RGBCK
NC
NC
NC
NC
NC
NC
47K
NC 81
82
83
84
85
86
87
88
89
90
91
92
R849
10K
A-b 5 4 3 2
A
100K
R613
5V
SWV
R853
8 7 6 5
1 2 3 4
120
10
10K
C
LCD DRIVER/
KEY CONTROLLER
D
5.00MHz
R1
R1
R1
B
DEH-50UB/XS/EW5
48
1 2 3 4
5 6 7 8
B KEYBOARD UNIT
MC2848-11
2R2K
2R2K
MC2848-11
4R7K
B
A
CN902
33K
8R2K
2R2K
3R3K
750
1K
1K
1K
1K
1K
1K
1K
B
DEH-50UB/XS/EW5
7
49
5 6 8
1 2 3 4
A
C-a
PICKUP UNIT(P10.5)(SERVICE)
B F
T
C
S
F F
f
T
T
F F
T
F
P
F
T F
F
T T
T
C
d
SWITCHES:
CD CORE UNIT(S10.5COMP2-iPod)
S901:HOME SWITCH.........ON-OFF
S903:DSCSNS SWITCH.....ON-OFF
S904:12EJ SWITCH............ON-OFF
S905:8EJ SWITCH..............ON-OFF
D
The underlined indicates the switch position.
M1 CXC7134
SPINDLE MOTOR
S
C
e
C
M2 CXC4026
T S
LOADING/CARRIAGE MOTOR
F 9 C 7
E a 8 4
5
F C
F C
3 T
T
S
S
1 CD DRIVER
C
DEH-50UB/XS/EW5
50
1 2 3 4
5 6 7 8
A
C-b
C CD CORE UNIT(S10.5COMP2-iPod)
SIGNAL LINE
F FOCUS SERVO LINE
T
TRACKING SERVO LINE
C
CARRIAGE SERVO LINE
S
SPINDLE SERVO LINE
B
b
PE5611B
C
R1
4R7K
m
D
l
k
6
E
A
CN701
i
g h j
C
DEH-50UB/XS/EW5
7
51
5 6 8
F
E
B
A
D
C
52
C-a C-b
C-b
C CD CORE UNIT(S10.5COMP2-iPod)
1
1
SIGNAL LINE
F
1
FOCUS SERVO LINE
T
TRACKING SERVO LINE
C
CARRIAGE SERVO LINE
S
SPINDLE SERVO LINE
2
2
DEH-50UB/XS/EW5
3
3
PE5611B
4
4
R1
5 6 7 8
A CN701
i
j
B
h
g
C
C-a C-b
R1
D
4R7K
m
l
k
3 C-b
DEH-50UB/XS/EW5
7
53
5 6 8
F
E
B
A
D
C
54
C-a C-b
C-a
C-b
1
1
1
2
PICKUP UNIT(P10.5)(SERVICE)
2
2
F
T
C
S
F F
f
T
DEH-50UB/XS/EW5
T
F F
3
3
T
F
F
T F
F
T T
T
4
4
SWITCHES:
CD CORE UNIT(S10.5COMP2-iPod)
S901:HOME SWITCH.........ON-OFF
S903:DSCSNS SWITCH ON-OFF
SWITCHES:
CD CORE UNIT(S10.5COMP2-iPod)
S901:HOME SWITCH.........ON-OFF
S903:DSCSNS SWITCH.....ON-OFF
S904:12EJ SWITCH............ON-OFF
S905:8EJ SWITCH..............ON-OFF
5
5
The underlined indicates the switch position.
M1 CXC7134
SPINDLE MOTOR
S
C
e
C
6
6
M2 CXC4026
T S
LOADING/CARRIAGE MOTOR
F 9 C 7
a 8 4
5
F C
F C
DEH-50UB/XS/EW5
T S
3 T S
7
7
1 CD DRIVER
3
8
8
C-a C-b
C-a
C-b
55
E
A
D
C
F
B
1 2 3 4
10.4 WAVEFORMS
- CD CORE UNIT Note : 1. The encircled numbers denote measuring points in the circuit diagram.
2. Reference voltage REFO1(1.65 V)
A
1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div
28SNS 5 V/div 5CLCONT 5 V/div 28SNS 5 V/div
312SNS 5 V/div 4LOEJ 5 V/div 312SNS 5 V/div
4LOEJ 5 V/div 6VD 10 V/div 4LOEJ 5 V/div
12 cm CD Loading operation 12 cm CD Loading operation 8 cm CD Loading operation
7SIN 1 V/div 1 s/div 0FIN 200 mV/div 500 ms/div @TE 500 mV/div 200 ms/div
8CIN 500 mV/div !RFOK(MONI_3) 2 V/div #FE 500 mV/div
9TIN 1 V/div 7SIN 2 V/div
12 cm CD-DA setup operation after loading 12 cm CD-DA Source On setup operation Source On setup operation
C
Ref.: Ref.: Ref.:
REFO REFO REFO
#FE 500 mV/div 20 ms/div $MDX 2 V/div 200 ms/div $MDX 2 V/div 5 µs/div
0FIN 500 mV/div 7SIN 500 mV/div 7SIN 500 mV/div
@TE 500 mV/div
9TIN 500 mV/div
D CD-DA Play operation Spindle waveform during play operation Spindle waveform during play operation
(Wider)
0FIN 500 mV/div 200 ms/div @TE 500 mV/div 2 ms/div %RFAGC 1 V/div 500 µs/div
E #FE 500 mV/div %RFAGC 500 mV/div @TE 500 mV/div
9TIN 500 mV/div
DEH-50UB/XS/EW5
56
1 2 3 4
5 6 7 8
%RFAGC 1 V/div 500 µs/div %RFAGC 1 V/div 500 µs/div %RFAGC 1 V/div 2 ms/div
@TE 500 mV/div @TE 500 mV/div @TE 500 mV/div A
9TIN 500 mV/div 9TIN 500 mV/div 9TIN 500 mV/div
%RFAGC 1 V/div 200 ms/div ^LOUT 1 V/div 200 µs/div 1DSCSNS 5 V/div 500 ms/div
@TE 1 V/div &ROUT 1 V/div 28SNS 5 V/div
8CIN 1 V/div 312SNS 5 V/div
7SIN 2 V/div 4LOEJ 5 V/div
Search operation(Outter to Inner) Analog audio waveform 12 cm CD Eject operation
1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div %RFAGC 1 V/div 500 µs/div
5CLCONT 5 V/div 28SNS 5 V/div 9TIN 1 V/div
4LOEJ 5 V/div 312SNS 5 V/div @TE 1 V/div
4LOEJ 5 V/div 0FIN 1 V/div
12 cm CD Eject operation 8 cm CD Eject operation Black dot(800 µm) during play
USB Play USB device inserting to USB connector. CD Play with USB(iPod) device connecting.
DEH-50UB/XS/EW5
7
57
5 6 8
1 2 3 4
ACC OFF with USB(iPod) device connecting. iPod Authentication Operation iPod Authentication Operation(zoom until 2 s)
DEH-50UB/XS/EW5
58
1 2 3 4
5 6 7 8
DEH-50UB/XS/EW5
7
59
5 6 8
1 2 3 4
B SIDE A 5 1
130
C313
SIDE B
P.C.Board Chip Part IC921
120
1
C923
D901
110
Q911
R938 D904 D903 R955
L901
E
C 100 C922
D931
D932
90
D911
80
R912
C913
D912
Q702
70 C911
D
E
D701
R701
60
C703
D502
CN701
50 C502
15
C
10
L501
CN701 40
E
5
1
30 C501 C708
20 BZ601
CN902
B
CN1802 10 L852
1 5
F Y
0
10 20 30 40 50 60 70
A X
DEH-50UB/XS/EW5
60
1 2 3 4
5 6 7 8
SIDE A
D ASSY
N901 CN351 RCA
10
2
10 20
IC301 5
1 1
1 5 15 25 B
C311
C451
ANTENNA
CN401
D901
R454
1
D902
R309
L951
D904 D903 R955
C405
Y401
L161
1
D454 C352
C351 C165 C
5
L401
C162
C160
10
15
D
C401
20
X601
L601 C605
C607 L602
C962 L403 E
C408
R414
CN902 10
1 5
FRONT F
C309
R359 R360 1
B C310
C357 C358
FU353
Q351 R352 R453
Q454
E
R452
1
Q453 Q451
E
R351
C315
C318 R451
C305 C317
1 ZNR401 C307
R304 C302 R303 R301 D951
R954
C303
L402 R953
C304 R306 C301 R951
E
R952
Q951
R356
C406 D622
R632
R407
15
C411
R406 R627 C623
R405 D623
R151 R631
R404 D621
R152
10 C163 R603
R421
20
R153
R403 C705
IC151
R613
5
C156
C153
25
R412
R402
C159
C154
1
R611
R614
C155
C608 PCL
IC602
50
C407 C704 C716 TEST 45
R612
D
55
40
R932 R610
35
C715
60
R604
R607
65
30
R605
70
25
C402 IC601
75
20
C609
R401
80
15
R619
R601
R409
10
85
90
C602 R
5
Q402 R408 95
1
0
1
R411 10
C412 R609
R415
C604
R608
1
Q401
R410
R813
C403 C603
R811 R815
E R413
C606 R967
C961
R814
R962 IC961 R805
R606
1
IC401 R804
1
C410
Q842
C404
E
R842
Q841
R841
E
R816
SIDE B
150
1 B
D251
130
L251 D252
R626
1
120
C901
C924
R256
C921
R255
R922
110
R937 C931
100 C
R934 R936
R933
Q931
1
R935
90
3
80
C912 Q912
C711
1
PCL R911
50
45
R617
IC251
70
C252
40
C253 D
1
35 C251
R254
30
Q701
60
1
R507
25
R714 C702
15
10
R703
C507
R712
R509
R808 40
R813 R508
R811 R815 C506 IC501
R967 E
1
R814 R707
1 R506
961 R805
C706 30
5
R711
IC702 C710 C505
1
R804 R503
R704
C709
1
C707 R616
R511 R502
R709 R713 R505
R512 C503
R807
R806
R849
R852 20
R851
D809 D810 Q852
Q851
E
E
C851
R853
1 10
D804 D801
D802
D803 Y F
0
90 80 70 60 50 40 30 20 10 X A
DEH-50UB/XS/EW5
7
63
5 6 8
F
E
B
A
D
C
64
B
B
1
1
KEYBOARD UNIT
11.2 KEYBOARD UNIT
2
2
SRC/OFF
S.Rtrv DISP/BACK/SCROLL
EJECT
DEH-50UB/XS/EW5
MUTE
LIST
3
3
MULTI-CONTROL
TA/NEWS LOC/RPT
BAND/ESC
RDM/SHFL/iPod
4
4
SIDE A
5 6 7 8
A
CN902
B
DEH-50UB/XS/EW5
7
65
5 6 8
1 2 3 4
PICKUP UNIT(P10.5)(SERVICE)
A CN701
REFO1
E
F
D HOME
E
LOADING/CARRIAGE MOTOR
M
M
SPINDLE MOTOR
C
DEH-50UB/XS/EW5
66
1 2 3 4
5 6 7 8
B
8EJ
12EJ
DSCSNS
C
DEH-50UB/XS/EW5
7
67
5 6 8
1 2 3 4
A
Unit Number : YWM5189
D
D
D
804
809
810
(B,68,5) Varistor
(B,77,16) Varistor
(B,56,16) Varistor
EZJZ1V270RM
EZJZ1V270RM
EZJZ1V270RM
Unit Name : Tuner Amp Unit D 901 (A,70,113) Diode S5688G
D
D 902 (A,76,106) Diode S5688G
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
RESISTORS R 627 (B,113,91) RS1/16S102J
R 631 (B,113,89) RS1/16S101J
R 151 (B,144,88) RS1/16S102J
R 152 (B,146,86) RS1/16S102J R 632 (B,113,93) RS1/16S101J A
R 153 (B,143,85) RS1/16S102J R 633 (B,22,141) RS1/16S0R0J
R 254 (B,60,63) RS1/16S681J R 701 (A,15,62) RD1/4PU271J
R 257 (B,58,50) RS1/16S103J R 703 (B,48,43) RS1/16S472J
R 704 (B,31,26) RS1/16S104J
R 301 (B,126,108) RS1/16S471J
R 303 (B,131,108) RS1/16S471J R 705 (B,48,46) RS1/16S472J
R 304 (B,139,108) RS1/16S471J R 706 (B,48,48) RS1/16S104J
R 306 (B,134,108) RS1/16S471J R 707 (B,31,31) RS1/16S104J
R 309 (A,97,106) RD1/4PU153J R 708 (B,46,50) RS1/16S221J
R 709 (B,38,22) RS1/16S102J
R 351 (B,155,118) RS1/16S821J
R 352 (B,156,125) RS1/16S0R0J R 710 (B,48,45) RS1/16S221J
R 711 (B,33,29) RS1/16S221J B
R 356 (B,136,102) RS1/16S821J
R 359 (B,162,133) RS1/16S223J R 712 (B,48,41) RS1/16S221J
R 360 (B,157,132) RS1/16S223J R 713 (B,32,25) RS1/16S221J
R 714 (B,26,53) RS1/16S104J
R 401 (B,151,53) RS1/16S681J
R 402 (B,157,78) RS1/16S681J R 804 (B,90,27) RS1/16S222J
R 403 (B,155,84) RS1/16S681J R 805 (B,87,30) RS1/16S222J
R 404 (B,155,87) RS1/16S681J R 806 (B,61,18) RS1/16S222J
R 405 (B,155,89) RS1/16S681J R 807 (B,71,18) RS1/16S222J
R 808 (B,80,39) RS1/16S104J
R 406 (B,155,91) RS1/16S681J
R 407 (B,155,92) RS1/16S102J R 811 (B,87,34) RS1/16S473J
R 408 (B,140,45) RS1/16S223J R 813 (B,85,37) RS1/16S104J
R 814 (B,85,34) RS1/16S102J C
R 409 (B,145,49) RS1/16S223J
R 410 (B,142,38) RS1/16S223J R 815 (B,84,34) RS1/16S102J
R 816 (B,106,17) RS1/16S1R0J
R 411 (B,141,42) RS1/16S223J
R 413 (B,155,35) RS1/16S221J R 825 (B,76,48) RS1/16S102J
R 414 (A,140,26) RD1/4PU4R7J R 841 (B,117,19) RS1/16S103J
R 415 (B,155,41) RS1/16S221J R 842 (B,120,21) RS1/16S472J
R 421 (B,153,86) RS1/16S0R0J R 849 (B,44,20) RS1/16S103J
R 851 (B,36,18) RS1/16S153J
R 451 (B,119,116) RS1/16S103J
R 452 (B,118,121) RS1/16S221J R 852 (B,22,19) RS1/16S472J
R 453 (B,120,125) RS1/16S153J R 853 (B,46,9) RS1/16S222J
R 502 (B,23,23) RS1/16S3302F R 911 (B,20,71) RS1/16S223J
R 912 (A,14,77) RD1/4PU152J D
R 503 (B,23,26) RS1/16S333J
R 922 (B,9,109) RS1/16S473J
R 505 (B,26,22) RS1/16S8201F
R 506 (B,25,30) RS1/16S683J R 931 (B,79,49) RS1/16S104J
R 507 (B,79,57) RS1/16S222J R 932 (B,119,65) RS1/16S104J
R 510 (B,26,44) RS1/16S823J R 933 (B,62,95) RS1/16S104J
R 511 (B,29,23) RS1/10SR471J R 934 (B,62,97) RS1/16S473J
R 935 (B,59,89) RS1/16S473J
R 512 (B,52,21) RS1/16S0R0J
R 602 (B,82,49) RS1/16S103J R 936 (B,58,97) RS1/16S473J
R 603 (B,97,86) RS1/16S103J R 937 (B,63,101) RS1/16S472J
R 604 (B,108,62) RS1/16S681J R 938 (A,55,103) RD1/4PU102J
R 605 (B,109,59) RS1/16S681J R 951 (B,105,105) RS1/16S473J
E
R 952 (B,105,104) RS1/16S102J
R 606 (B,104,28) RS1/16S103J
R 607 (B,109,61) RS1/16S681J R 953 (B,114,106) RS1/16S472J
R 608 (B,108,38) RS1/16S104J R 955 (A,70,103) RD1/4PU153J
R 610 (B,105,65) RS1/16S473J R 962 (B,101,30) RS1/16S822J
R 613 (B,111,80) RS1/16S104J R 967 (B,89,33) RS1/16S102J
DEH-50UB/XS/EW5
7
69
5 6 8
1 2 3 4
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
C 162 (A,122,88) CEJQ470M10 C 922 (A,16,98) CEJQ221M10
C 163 (B,122,85) CKSRYB104K25 C 923 (A,15,116) CEJQ101M16
C 165 (A,134,97) CEJQ100M16 C 924 (B,13,114) CKSRYB103K50
A C 251 (B,46,64) CKSRYB104K25 C 961 (B,104,32) CKSRYB473K25
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
R 1820 (B,25,145) RS1/4SA102J R 234 (B,23,26) RS1/16SS473J
C
Unit Number : CWX3526
R
R
256
259
(A,26,62)
(A,28,66)
RS1/16SS104J
RS1/16SS0R0J B
R 261 (A,26,65) RS1/16SS104J
Unit Name : CD Core Unit R 262 (A,30,60) RS1/16SS0R0J
R 263 (A,28,63) RS1/16SS0R0J
(S10.5COMP2-iPod)
R 273 (B,19,48) RS1/16SS103J
MISCELLANEOUS R 274 (B,18,51) RS1/16SS104J
R 275 (B,19,51) RS1/16SS104J
IC 201 (A,36,46) IC PE5611B R 276 (B,20,51) RS1/16SS104J
IC 202 (A,24,30) IC S-93C66BD0I-J8 R 277 (B,24,52) RS1/16SS103J
IC 205 (B,25,47) IC 341S2094
IC 301 (A,29,15) IC BA5839FP R 278 (B,27,51) RS1/16SS1003D
Q 101 (B,58,70) Transistor 2SA1577 R 279 (B,23,52) RS1/16SS104J
Q 102 (B,49,58) Chip Transistor 2SB1689 R 282 (A,30,61) RS1/16SS240J C
R 283 (A,29,61) RS1/16SS240J
Q 201 (B,27,54) Transistor 2SA1577 R 284 (B,30,63) RS1/16SS153J
X 201 (A,23,38) Ceramic Resonator 16.934 MHz CSS1603
X 204 (B,17,45) Oscillator 32.768 kHz CSS1735 R 285 (B,28,63) RS1/16SS153J
X 205 (B,34,63) Oscillator 48.000 MHz CSS1753 R 289 (B,19,45) RS1/16SS0R0J
S 901 (A,55,37) Switch(HOME) CSN1067 R 291 (B,43,62) RS1/16SS272J
R 292 (B,25,43) RS1/16SS221J
S 903 (B,20,59) Switch(DSCSNS) CSN1067 R 293 (B,27,52) RS1/16SS472J
S 904 (B,41,68) Switch(12EJ) CSN1068
S 905 (B,25,70) Switch(8EJ) CSN1068 R 294 (A,32,63) RS1/16SS471J
R 295 (B,55,64) RS1/16SS103J
RESISTORS R 307 (A,35,19) RS1/16SS183J
R 308 (A,38,19) RS1/16SS183J D
R 101 (B,61,74) RS1/10SR2R4J R 309 (A,35,21) RS1/16SS183J
R 102 (B,61,72) RS1/10SR2R4J
R 103 (B,61,71) RS1/10SR2R7J R 310 (A,38,22) RS1/16SS183J
R 104 (B,54,67) RS1/16SS222J R 601 (B,30,31) RS1/16SS0R0J
R 105 (B,45,58) RS1/16SS102J R 602 (B,27,31) RS1/16SS0R0J
R 606 (B,28,23) RS1/16S0R0J
R 107 (B,52,60) RS1/16SS105J R 701 (B,12,37) RS1/16SS221J
R 201 (A,20,33) RS1/16S472J
R 202 (A,27,33) RS1/16SS473J R 702 (A,24,56) RS1/16SS221J
R 203 (A,51,44) RS1/16S473J R 708 (B,15,37) RS1/16S0R0J
R 204 (A,24,58) RS1/16SS221J R 712 (B,15,54) RS1/16SS0R0J
R 206 (B,10,27) RS1/16SS104J R 713 (B,15,53) RS1/16SS0R0J
E
DEH-50UB/XS/EW5
72
1 2 3 4