Beruflich Dokumente
Kultur Dokumente
MODEL 44SM7
ARINC 429 to SYNCHRO CONVERTER
Description
The Model 44SM7 is a self contained, remotely mountable module that accepts low speed (12.5 KHz) ARINC 429 (Label
114, Desired Track [True] and Label 121, Horizontal Command) from the Garman 530 or other compatible GPS units.
The unit will convert this data into three wire, 11.8 V Line-to-Line Synchro information.
Specifications
Signal Input: Two-wire ARINC 429 Low Speed (12.5 KHz), Label 114-Desired Track and Label 121 –
Horizontal Command.
Input Impedance: 12 KΩ min.
Power: 100Vrms to 122Vrms (115Vrms nominal) 400Hz ±10% (Transformer Isolated)
Reference: 26Vrms, 400Hz @ 4 ma max (Transformer Isolated)
Power and Reference must be of the same phase.
Resolution: 0.05°
Accuracy: 0.5°
Output format: Synchro S1 (X), S2 (Z), S3 (Y)
Output Voltage: 11.8VL-L ±5%
Output Load: Litton Poly-Scientific CDH-11-B-2 (Zso = 12.9+j76.6 ohms)
Loaded by Harowe 8CT-101-A-5 (Zso = 33.6+j100 ohms)
Output Phase Shift: 0° ±3° with respect to the Reference
Valid Flag 28VDC and Ground Valid, 250ma
Protection: Unit will not be damaged by loss of Power or Reference. The Synchro output is internally limited
and will not be damaged by short circuit conditions. Recovery from short circuit is within 0.5 sec.
Grounds: Power and reference inputs are transformer isolated and are isolated from chassis ground and Z
common. Z common is isolated from the chassis. Z common, Chassis, and Power Low should be
interconnected at a single point.
Finish: Alodine per MIL-C-5541, Class 3
Weight: Approx 6.5 lbs
Size: Approx. 8.0” x 6.75” x 3.24”
Environment: Per RTCA/DO-160D (See Test requirements below)
Burn-In: 96 Hours with power applied. Chamber temperature will be cycled from +70°C to -45°C with a
dwell time of 2 hours at each temperature.
A 115V 400Hz Hi
B 115V 400Hz Lo
C Power Ground
D Chassis Ground
E S1(X)
F S2(Z)
G S3(Y)
H +28 VDC Hi
J NOT USED
K Input Selector
Jumper
L +28VDC Return
M Input Selector
Jumper
N 26V 400Hz Ref. Hi
P 26V 400Hz Ref. Lo
R ARINC 429 Input Lo
S Chassis Ground
T NOT USED
U ARINC 429 Input Hi
V +28VDC Valid Flag
W Ground Valid Flag
Note: Connect pins “K” and “M” together for RUN (Desired Track ± Horizontal Command) function.
Leave pins “K” and “M” open for SET (Desired Track) function.