Beruflich Dokumente
Kultur Dokumente
Which two IP addresses represent the network and broadcast addresses for the
network that includes host 192.168.100.130/27? (Choose two.)
network 192.168.100.0
network 192.168.100.128
network 192.168.100.130
broadcast 192.168.100.157
broadcast 192.168.100.159
broadcast 192.168.100.255
Top of Form
What range of networks are summarized by the address and mask, 192.168.32.0/19?
192.168.0.0/24 - 192.168.32.0/24
192.168.0.0/24 - 192.168.31.0/24
192.168.32.0/24 – 192.168.64.0/24
192.168.32.0/24 – 192.168.63.0/24
Bottom of Form
What is a characteristic of a classful routing protocol on the network?
Top of Form
A network administrator is asked to design a new addressing scheme for a corporate network. Present
there are 500 users at the head office, 200 users at sales, 425 at manufacturing, and 50 at the researc
site. Which statement defines the correct VLSM addressing map with minimal waste using the
172.16.0.0/16 network?
Bottom of Form
172.16.0.0/23 head office
172.16.2.0/23 manufacturing
172.16.4.0/24 sales
172.16.5.0/26 research
Top of Form
Refer to the exhibit. Which two are valid VLSM network addresses for the serial link between Router1
Router2? (Choose two.)
192.168.1.4/30
192.168.1.8/30
192.168.1.90/30
192.168.1.101/30
192.168.1.190/30
Bottom of Form
Refer to the exhibit. Based on the output of the show ip nat translations command,
which kind of address translation is in effect on this router?
static
public
overload
private
Top of Form
A network engineer is implementing a network design using VLSM for network 192.168.1.0/24. After
subnetting the network, the engineer has decided to take one of the subnets, 192.168.1.16/28 and sub
it further to provide for point-to-point serial link addresses. What is the maximum number of subnets th
can be created from the 192.168.1.16/28 subnet for serial connections?
1
16
Bottom of Form
How many addresses will be available for dynamic NAT translation when a router is
configured with the following commands?
10
24
31
Refer to the exhibit. All networks that are shown have a /24 prefix. Assuming that all
routes have been discovered by all routers in the network, which address will
successfully summarize only the networks that are shown?
192.168.8.0/21
192.168.8.0/24
192.168.16.0/20
192.168.16.0/21
192.168.16.0/24
Top of Form
What two pieces of information can be determined from the host IP address of 192.168.2.93/29? (Cho
two.)
The number of bits borrowed for the subnetwork is 5.
509
1021
2045
4093
Bottom of Form
Top of Form
When configuring NAT on a Cisco router, what is the inside local IP address?
the IP address of an inside host as it appears to the outside network
Top of Form
Which two addresses could be used as private IP addresses in a LAN? (Choose two.)
10.10.1.200
172.31.100.254
172.64.10.10
192.165.2.1
192.169.1.1
Bottom of Form
How does a router keep track of which inside local address is used when NAT overload
is configured?
The router adds an additional bit to the source IP address and maintains a separate
table.
The router modifies the QoS field.
10.1.1.2
198.18.1.55
64.100.0.1
Refer to the exhibit. What solution would solve the discontiguous network problem and
prevent the routers from advertising misleading networks?
Turn automatic summarization off and manually summarize the routes at the
classful boundary.
Allow automatic summarization to send the most optimal route.
Top of Form
Refer to the exhibit. Which two IP addresses could be assigned to the hosts that are shown in the exhi
(Choose two.)
192.168.65.31
192.168.65.32
192.168.65.35
192.168.65.60
192.168.65.63
192.168.65.64
Bottom of Form
Top of Form
Which two statements differentiate between flat and hierarchical networks? (Choose two.)
In a hierarchical design, the network consists of all Layer 2 devices.
In a flat network, all hosts can be reached without having to pass through a router.
In a flat network, hosts using multiple broadcast domains pass through routers.
In a hierarchical design, a network is divided into layers to reduce congestion and the size of failure
domains.
Bottom of Form
Top of Form
A network technician has been asked to implement a hierarchical addressing scheme. Which two
statements could describe the hierarchical addressing scheme structure to the technician? (Choose tw
A hierarchical addressing structure logically groups networks into smaller subnetworks.
What are two benefits of implementing a VLSM addressing scheme? (Choose two.)
allows efficient use of address space
supports only one subnet mask length throughout the entire network
allows efficient use of larger routing tables to eliminate the need for route
summarization
solves the problem of discontiguous networks with classful routing protocols