Beruflich Dokumente
Kultur Dokumente
Thank you! for registering at ThinkLABS, SINE, IITB for the Summer Training and Internship Program.
We appreciate your interest in the Summer training program. Further, you are requested to answer the questions given
below to qualify for same.
We will revert back with the status of selection within 24 hrs of submission.
1) Education Qualification
a) SE
b) TE
c) BE
d) others ( please specify)
2) Rate yourself in C programming.On a scale of 110(10 being the highest)
3) If a micrcontroller is running at 100 Mhz, what will be the duration of a clock cycle.
a) 1 ns
b) 10 ns
c) 0.1 us
d) 100 us
4) Which of these figures will occupy the maximum area?
a) A circle with a diam meter of x units
b) A square with each side of x units
c) An equilateral triangle with side of 2x units
5) If there are 1024*1280 pixels on a screen and each pixel can have around 256 colors. Find the memory required for this?
a. Close to 1MB
b. Greater than 10MB
c. Less than 100KB
d. None of the above
6) 8051 is a
a. RISC architecture
b. CISC architecture
c. Partially CISC architecture
d. Partially RISC architecture
7) A transconductance amplifier should ideally have a
a. High input impedance and high output impedance
b. Low input impedance and low output impedance
c. High input impedance and low output impedance
d. Low input impedance and high output impedance
8) Which of the following can you use independently to measure the speed of a robot?
a) Obstacle Sensor
b) Shaft encoder
c) Magnetic compass
d) Sharp sensor
9) What kind of motors are better suited for a sumo robot?
a: 3000 RPM DC Motor
b: 700 RPM DC Geared motor
c: 100 RPM DC Geared Motor
d: Stepper Motor
10) What kind of motors are better suited for a Micromouse?
a: RC Servo Motor HS311
b: 700 RPM DC Geared motor without encoders
c: 100 RPM DC Geared Motor without encoders
d: Stepper Motor
11) Robowars competition is about destroying other robots in the arena.
Which power supply would you use?
a: 24 VDC Ni Mh rechargable battery pack
b: 24 VDC Li ion battery
c: 24VDC Lead Acetate battery
d: 24DC Li Polymer Bettery
12) In a robotic arm, What is termed as DegreeOfFreedom?
a: The number axis along which the base of the arm can move
b: Number of grippers an arm has
c: Number of axis along which the joints of the arm can move
d: Number of limbs an arm has
13) Which motor driver would you prefer to run a bipolar stepper motor
with 500mA Coil current rating?
a: ULN2003
b: ULN2803
c: L293D
d: Relays.
14)Give a brief descrption of your project in 200 words (optional)
Team ThinkLABS