Sie sind auf Seite 1von 19

Technical Manual Error: Reference source not foundError:

UA5000 Universal Access Unit Reference source not found

The UA5000 supports a wide range of cabinet and frame models to be use
different situations. This chapter describes the structure and specification
cabinets, frames and cards.

1.1 Logical Structure


Figure 1 .1.1.I.1.1
s howst l hes ogical
o t U tructure
T U cf he o A5000.
following modules:
 TDM control and switching module
 Packet control and switching module
 Packet voice processing module
 Network-network interface (NNI) module
 User-network interface (UNI) module

POTS
ISDN E1
E1 TDM control and
TDM SHDSL switching module
V.24
V.35
UNI Module

NNI Module
Packet voice
N×64k
processing FE/GE
2/4-wire module

ADSL
STM-1
ADSL2+
ATM E3
ATM SHDSL IMA E1
Packet control and
Ethernet switching module FE/GE

Figure 1.1.1.I.1.1 UA5000 logical structure

The following describes the UA5000 logical structure.


 T h e T D M c o n t r o l a n d s w i t c h i n g m o d u l e i m p l e m e n
convergence of narrowband services through the TDM switching fabric.
 T h e p a c k e t c o n t r o l a n d s w i t c h i n g m o d u l e i m p l e m e n t s
convergence of broadband services through the packet switching fabric.
 The packet voice processing module converts voice stream t
through voice coding/decoding and sends them to the NGN.
 The N mNI p odule v nrovidesp i arious
A S etwork
A E orts n
V5, TDM E1, IMA E1, FE and GE ports.

Huawei Technologies Proprietary

1
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

 The UNI module provides various service ports including POTS, IS


(2B+D), ISDN PRI (30B+D), V.24 sub-rate, V.24/V.35 64 kbit/s, V.35/FE1 N x 64
kbit/s, E1, ADSL, ADSL2+, SHDSL (TDM/ATM), Ethernet and 2/4-wire VF ports.

1.2 Software Structure


Figure 1.2.1.I.1.1shows the software structure of the UA5000 system. The UA5000
software consists of the card software and host software.

Serial port Telnet


NMS
terminal

Inband/outband Serial port connection Inband/outband

Host software

Communication control bus

Card Card Board


Card
software 2 ... software
software 1 softwareN

UA5000 software architecture

Figure 1.2.1.I.1.1 UA5000 software architecture

I. Card software

The card software runs on a line card, interface card or monitor card. The software
drives the card and implements service management, data managem
management and fault diagnosis for the card.

II. Host software

The host software resides on a control card. The software consists of four layers as
s h o w n i Fn i g u r e 1 . 2 . 1 . ,I I s. 1o .m1 e o f w h i c h a r e f u r t h e r s u b d i v i d e d i n t o m o d u l e s .
Refer to “1.5Cards” for details about the control cards.

Huawei Technologies Proprietary

2
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Service control layer

System support layer

System support layer


System service layer

Figure 1.2.1.II.1.1 Host software structure

The name and functions of each layer are as follows.


 System support layer: drives the system hardware.
 System service layer: provides basic services for the software
fundamental module is the operating system.
 S y s t e m m a n a g e m e n t l a y e r : p r o v i d e s u s e r s w i t h m
equipment and services.
 Service control layer: interprets user commands and provides various services.

1.3 Cabinets
1.3.1 Cabinet Specifications

Table 1.3.1.I.1.1.1 lists the cabinets that can house the UA5000 frame.

Table 1.3.1.I.1.1.1 Specification of the cabinets that can house the UA5000 frame

Model Type Frame Max. ports*


configuration POTS ADSL P O T S &
only only ADSL
combo

ONU-F01D200 Outdoor, One HABD 384 192 192


front-access

ONU-F01D500 Outdoor, One HABD + 960 480 480


front-access one HABF

ONU-F01D1000 Outdoor, One HABD + 1408 704 704


front-access one HABE +

Huawei Technologies Proprietary

3
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Model Type Frame Max. ports*


configuration POTS ADSL P O T S &
only only ADSL
combo

one HABF

ONU-F02A Indoor, One HABA 960 480 480


rear-access One HABA+ one 1984 992 992
HABA

ONU-F02AF Indoor, One HABD+ One 960 480 480


front-access HABF

One HABD+ one 1984 992 992


HABE+ two
HABFs

1.3.2 Power Supply System and Environmental Monitor System

I. Power supply system

The power supply system used by the UA5000 can be any one of the PS48
PS4845 or a DC distribution unit. Refer to Table 1.3.2.I.1.1.1 for details.

Huawei Technologies Proprietary

4
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Table 1.3.2.I.1.1.1 Description of the power supply system

Parameter PS4860 PS4845 DC distribution unit

Input 220 V AC 220 V AC or 110 V AC –48 V DC (Two


inputs)

Composition Rectifier unit Rectifier unit 4815 NA


HRS1150-9000 Power monitor unit
Power monitor PSM-B5
unit PSM-B9 Power distribution
Power unit
distribution
unit

Structure 19 inches 19 inches wide, 3 U 19 inches wide, 2 U


wide, high high
3 U high

Applied Rear-access Front-access cabinet Front-access cabinet


cabinet cabinet and rear-access
cabinet

Features Stable and N+1 backup of the Compatible with the


reliable rectifier modules; –48V power supply
running, with Safe and reliable with two inputs or
perfect power power supply and DC one input.
management, distribution
environment and functions;
power monitoring
Outstanding
functions.
environment and
power monitor and
battery management

II. Environmental monitoring system

The UA 50 00 ha s po we rf ul e n viro nm en t al mo n it or ing fu n c


following items:
 Environmental parameters inside/outside of the cabinet
 Power supply
 Fan
 Battery
The environmental monitoring units include:

Huawei Technologies Proprietary

5
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

 Environmental monitoring card


 Environmental monitoring box
 Power monitor unit
 Built-in monitor card in the power distribution unit
1) Environmental monitoring card
The environmental monitoring card includes the H303ESC and H
following takes the H304ESC card as the example to introduce the functions an
features. N t aote t hatH lthough
a H he
c h 303ESC
t s b nd 304ES
features, the H304ESC card has no humidity monitoring function.
The H304ESC communicates with the control card throug
H304ESC can monitor 8 analog parameters and 22 digital parameters, and monitor
multiple types of intelligent power supply through serial ports. Detailed functions of
the H304ESC are as follows:
 Analog p a r a m e t e: r Tm
hoe n Hi t3 o0 r4 E S C has built-in temperatu
humidity sensors, which monitor the temperature and humidity in the cabinet. It
also p rovides
3a s i nalog t c ignale anterfaces
s F o onnect
each monitor signal, you can set the alarm upper/lower limits and the sensor
properties.
 Digital parameter monitor
: The H304ESC monitors the power distribution unit
and access control. It also provides 13 digital sensor interfaces t
various external digital sensors. The external sensor uses a 12V or 24V power
s u p p l y. Yo u c a n d e f i n e t h e sensor signal name and set
dynamically.
 F a n m o n :i t To hr e H 3 0 4 E S C p r o v i d e s t h e p o w e r s u p p l y i n t e r f a c e s
cabinet’s fan frame and controls the fan switch with respect to the temperature.
Moreover, it can monitor the running status of each fan through the fan monitor
card.
 I n t e l l i g e n t c o n t r o l o u: t pT uh te i Hn 3t e
0 r4 fEaSc Ce p r o v i d e s t w o c o n t r
i n t e r f a c e s . T h r o u g h t h e s e t w o i n t e r f a c e s , t h e H 3 0 4 E
commands from the NMS and control the connection with external intelligen
equipment.
 Intelligent power supply m
: o
Tnhe
i t oHr3 0 4 E S C c a n m o n i t o r a n d m a n a g e
multiple types of intelligent power supplies through its serial port.
2) Environmental monitoring box
T h e e n v i r o n m e n t a l m o n i t o r i n g b o x c o n s i s t s o
H601ESFB. The box has following functions:
 Monitors various environmental parameters, such as temperatu
smoke, water, door status and main distribution frame (MDF).
 Provides multiple types of extended monitor interfaces.

Huawei Technologies Proprietary

6
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

 M o n i t o r s t h e p o w e r s y s t e m w h e n c o n n e c t e d t o t h e m
GEPS4845 power module.
3) Power monitor unit
The power monitor unit includes PSM-B9 and PSM-B5. The unit ha
functions:
 Monitors the power supply in real time.
 Automatically manage the battery based on the configuration.
 Obtains the running parameter values of the power supply system.
 Configures and controls the power supply system.
4) Built-in monitor card in the power distribution unit
The built-in monitor card can monitor the following parameters:
 Lightning protection components
 Input voltage
 Output voltage
 Shunt protection switch
 Temperature and humidity in the power distribution unit
T h e c a r d p r o v i d e s e i g h t d i g i t a l m o n i t o r i n t e r f a c e s t o d
parameters, such as water, access control and MDF.

1.4 Frames
There a t re
t owo
f ypes
O i af f rames.f a tne o si t r ront-access
access frame. This section describes the frame types.

1.4.1 Rear-Access Frames

The HABA frame is the master frame of the rear-access UA5000, which stands at a
height of 16 U.
The H ABA
f p rame
3 s orovides
w 3 a a 6 lots,
f l c f H hich 0 re
if you are using the AIUB and TSSB, you must insert the AIUB cards and the TSSB
card i t np he s ositions
i Figure 1 hown
.4.1.I.1.1
. T her n emaining
s s a r ix lots re
for other types of cards.
You can insert narrowband line cards and broadband line cards in any of the 30 line
card slots.
The two narrowband control cards and the two broadband control cards in the frame
support backup in the event of a primary controller failure.
The H ABA
f c urame
am ano o ase a m inimum
o t P c f Tne nd
two PWX cards in the frame share the power supply load, and if one PWX fails, the
other has the capacity to dynamically provide the necessary power.
Figure 1.4.1.I.1.1 shows the layout of the HABA frame.

Huawei Technologies Proprietary

7
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Fan
00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17

P P A A T
V V I I S
x x x x U U S
P P x x x x x x x x x
P P / / B B B
W W S S S S S S S S S
M M R R / / /
X X L L L L L L L L L
B B S S x x x
U U S S S
x x L L L

Cable routing area


Fan
18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

x x x x x x x x x x x x x x x x x x
S S S S S S S S S S S S S S S S S S
L L L L L L L L L L L L L L L L L L

Cable routing area

P W X : S e c o n d a r y
power supply card
x P M B : B r o a d b a n d
c o n t r o l c
(APMB/IPMB)
P V x : N a r r o w b a n d
c o n t r o l c
(PVU8/PVU4/PVM)
R S U x : R e m o t e
s u b s c r i b e r u
(RSU8/RSU4)
A I U B : ATM in t e r f a ce
card
xSL: S ervice
l c ine ard
(ASL/DSL/ADMB/ …)
TSSB: Test card

Figure 1.4.1.I.1.1 HABA frame layout

Huawei Technologies Proprietary

8
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

1.4.2 Front-Access Frames

Th e re a r e f o u r m o d e ls o f re a r- a c ce s s f r a m e s: H A B D ( m a st e r f r a m e ), H A B E ( s l a ve
frame) and HABF (extended frame).

I. HABD frame

The HABD frame is the master frame of the front-access UA5000, which stands at a
height of 10 U. The HABD frame can be subtended with multiple slave frames, and
the HABD frame can aggregate the services from the subordinate frames.
The H ABD
p 1 srovides
o w 1 a8 a lots, f l f c hichH 2i y re vailable
are using the AIUB and TSSB, you must insert the AIUB cards and the TSSB card in
the positions shown in Figure 1.4.2.I.1.1. The remaining 6 slots are for other types of
cards.
You can insert narrowband line cards and broadband line cards in any of the 12 line
card slots.
The two narrowband control cards and the two broadband control cards in the frame
support backup in the event of a primary controller failure.
The H ABD
f c u rame
am an
o o ase a m inimum
o t P c f T ne nd
two PWX cards in the frame share the power supply load, and if one PWX fails, the
other has the capacity to dynamically provide the necessary power.
Figure 1.4.2.I.1.1 shows the layout of the HABD frame.

Fan
00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17

P P A A T
V V I I S
x x x x U U S
P P x x x x x x x x x
P P / / B B B
W W S S S S S S S S S
M M R R / / /
X X L L L L L L L L L
B B S S x x x
U U S S S
x x L L L

Cable routing area


Control and interconnect Subscriber line
cable connecting area connecting area

PWX: Secondary power supply


card
xPMB: Broadband control card
(APMB/IPMB)
PVx: Narrowband control card
(PVU8/PVU4/PVM)

Huawei Technologies Proprietary

9
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

RSUx: Remote subscriber unit


(RSU8/RSU4)
x S L : S e r v i c e l i n e c a r
(ASL/DSL/ADMB …)
AIUB: ATM interface card
TSSB: Test card

Figure 1.4.2.I.1.1 HABD frame layout

II. HABE frame

The HABE frame is the slave frame of the front-access UA5000, which stands at a
height of 10 U.
The HABE frame operates under the control of the HABD frame. The HABE frame
can be subtended with the HABF frame.
The HABE frame provides 18 slots, of which 14 are reserved for line cards and 4 for
other t oypes
c Y fc ards.
i n ou l an
c ansert
b arrowband
l c ine
as desired.
The two broadband control cards in the frame support backup in the even
primary controller failure. The HABE frame does not have narrowband control cards.
The n arrowband
l c i t f ine a ards
c bn t he
n rame c cre ontrolled
in the HABD frame.
The H ABE
f c urame
am ano o ase a m inimum
o t P c f Tne nd
two PWX cards in the frame share the power supply load, and if one PWX fails, the
other has the capacity to dynamically provide the necessary power.
Figure 1.4.2.II.1.1 shows the layout of the HABE frame.

Fan
00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17

A A
P P x x x x x x x x x x x x x x
P P
W W S S S S S S S S S S S S S S
S S
X X L L L L L L L L L L L L L L
B B

Cable routing area


Control & interconnect Subscriber line
cable conneting area connecting area

PWX: Secondary power


supply card

Huawei Technologies Proprietary

10
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

A P S B : B r o a d
control card for the slave
frame
x S L : S e r v i c e l i n e c a r d
(ASL/DSL/ADMB/ …)

Figure 1.4.2.II.1.1 HABE frame layout

III. HABF frame

The HABF frame is the extended frame of the front-access UA5000, which stands at
a height of 10 U.
The HABF frame operates under the control of either the HABD frame or the HABE
f ram e. Th e se rvin g HA B D or H AB E f r ame pr ovi de s t h e p ow er su pp ly t o t he HA BF
frame.
T h e H A B F f r a m e p r o v i d e s 1 8 s l o t s . Yo u c a n i n s e r t n a r r o w b a n d l i n e
broadband line cards as desired.
Figure 1.4.2.III.1.1 shows the layout of the HABF frame.

FAN
00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17

x x x x x x x x x x x x x x x x x x
S S S S S S S S S S S S S S S S S S
L L L L L L L L L L L L L L L L L L

Cable routing area


Interconnect cable Subscriber line
connecting area connecting area

x S L : S e r v i c e l i n e c a r d
(ASL/DSL/ADMB/ …)

Figure 1.4.2.III.1.1 HABF frame layout

1.4.3 Frame Hardware Description

I. Master frame

Figure 1.4.3.I.1.1 shows the hardware structure of the master frame.

Huawei Technologies Proprietary

11
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

To slave frame and


NNI extended frame

Master
frame
x A
P
P I
V
M U
x
B B

TDM bus
High speed bus
Expansion bus
Test bus

T x E D C
A D
S D A E S
S S
S S U H M
L L
B L A A C

UNI

Figure 1.4.3.I.1.1 Hardware structure of the master frame

The master frame is the control core of the UA5000. The frame can contr
subtended slave and extended frames.
The master frame switches, aggregates and transmits services upstream for master
frame, slave frame and extended frame.
The m aster
f c b rame
s wan s ef ubtended
a e f itht s lave rames
resources between frames. The frame can also be connected with subscriber lines.
The service handling process of the UA5000 is as follows:
 The narrowband line cards send services to the narrowband
(PVU8, PVU4 and PVM) through the TDM bus. After carrying out the protocol
p r o c e s s i n g a n d t i m e s l o t c r o s s i n g , t h e P V U 8 / P V U 4 /
services upstream through the NNI.
 T h e b r o a d b a n d l i n e c a r d s s e n d s e r v i c e s t o t h e b r o a d
(APMB/IPMB) t t h hrough
s b a he
t A igh peed
a a us, nd he
forwards these services upstream through the NNI.
The line card management of the UA5000 is as follows:
 The narrowband control card manages narrowband line cards and test
(TSS) in this frame, the slave and extended frames.
 The broadband control card manages the broadband line cards, interface cards
and test card in this frame, the slave and extended frames.

Huawei Technologies Proprietary

12
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

When the UA5000 acts as a component of the NGN, the PVM converts the TDM
signals o a n f ll s arrowband
d i I p ervice
a s t ata
I p ntot t P ackets
IPMB c T ard.I t hef PMB
t p hen u orwards
t t I n hesea ackets
with the broadband services.
The TSSB card tests the line cards, and reports the test results to the control cards.

II. Slave frame

Figure 1.4.3.II.1.1 shows the hardware structure of the slave frame.

To master frame and


extended frame

Slave
frame
A
P
S
B

TDM bus
High speed bus
Expansion bus
Test bus

T x E D C
A D
S D A E S
S S
S S U H M
L L
B L A A C

UNI

Figure 1.4.3.II.1.1 Hardware structure of the slave frame

The slave frame is typically designated as a subscriber access unit, which can also
extend its bus to the extended frame to enable sharing between frame resources.
Services from the narrowband line cards are converged by the TD
forwarded upstream to the master frame through the conversion card or backplane.
Services f t brom he
l c roadband
a c b t inei ards h s re onverged
bus. A bfter p eing b t rocessed
A c t s y a hef PSBu ard,
t he er
the master frame through conversion cards or backplane cables.

III. Extended frame

Figure 1.4.3.III.1.1 shows the hardware structure of the extended frame.

Huawei Technologies Proprietary

13
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

To master frame and


slave frame

Extended
frame

TDM bus
High speed bus
Expansion bus
Test bus

T x E D C
A D
S D A E S
S S
S S U H M
L L
B L A A C

UNI

Figure 1.4.3.III.1.1 Hardware structure of the extended frame

The extended frame operates as a subscriber access unit. Se


narrowband line cards are converged by the intra-frame TDM bus, and forwarded
upstream to the master frame through the conversion card or backplane.
Services f t brom he
l c roadband
a c b t inei ards h s re onverged
bus, and forwarded upstream to the master frame through the conversion card or
backplane.

1.5 Cards
The cards used in high-density UA5000 include control cards, line cards and other
cards.
T a b l e 1 . 5 . 1 . I, . T
1 a. 1b .l 1e 1 . 5 . 1 . I, . T
1 a. 1b .l 2e 1 . 5 . 1 . I, . T
1 a. 1b .l 3e 1 . 5 . 1 . I .a1n. d1 . 4
Table 1.5.1.I.1.1.5 describe the details of these cards.

Table 1.5.1.I.1.1.1 Description of control cards

Abbr. name Full name Function description

APMB Master frame The APMB card is also called the


service broadband control card for ATM
processing card signaling.

The APMB card:

Huawei Technologies Proprietary

14
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Abbr. name Full name Function description

 controls the broadband line cards

 provides various types of upstream


ports for broadband services,
including IMA E1, ATM E3, and STM-1
ATM

 supports active/standby backup

 p r o v i d e s t h e s w i t c h f a b r i c a
working clock for broadband services

IPMB Master frame IP The IPMB card is also called the


service broadband control card for IP
processing card signaling.

The IPMB card:


 controls the broadband line cards

 aggregates and processes broadband


services

 provides GE/FE ports

 supports active/standby backup

PVM Packet voice The PVM card:


processing card  processes the H.248 protocols

 converts the TDM voice signals into


IP packets

 provides o F p net t E ort


t o ransmit
voice over IP service

PVU8/PVU4 V5 interface The PVU8/PVU4 is also called the master


processing unit frame narrowband control card.

The PVU8/PVU4 card:


 controls the narrowband line cards

 provides upstream V5 E1 ports for


TDM services

 p r o v i d e s T D M s w i t c h f a b r i c a
working clock for the TDM services

 supports the active/standby backup

APSB Slave frame The APSB card:


broadband service  controls t b he l roadband
c i ine ards
processing card the slave frame

 subtends t b he s roadband
w ervices it
the master frame

Huawei Technologies Proprietary

15
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Abbr. name Full name Function description

 supports the active/standby backup

RSU8/RSU4 Remote subscriber The RSU8/RSU4 card:


processing unit  controls the narrowband line cards
in the remote subscriber frame

 s u b t e n d s t h e n a r r o w b a n d s e r v i c e
with the UA5000 master frame or the
MD5500 frame

 p r o v i d e s u p s t r e a m E 1 p o r t s f
narrowband services

 supports the active/standby backup

Table 1.5.1.I.1.1.2 Description of narrowband line cards

Abbr. name Full name Function description

ASL POTS line card The ASL card provides 16 POTS ports.

A32 POTS line card The A32 card provides 32 POTS ports.

DSL ISDN BRI line The DSL card provides eight ISDN BRI
card ports.

VFB 2/4-wire VF line The VFB card provides sixteen 2-wire VF


card ports or eight 4-wire VF ports.

CDI Direct dial-in The CDI card provides 16 direct dial-in


line card ports.

SDL SHDSL line card The SDL card provides four TDM SHDSL
ports and four E1 ports.

Table 1.5.1.I.1.1.3 Description of broadband line cards

Abbr. name Full name Function description

SDLB SHDSL line card The SDLB card supports:


 16 ATM SHDSL ports

 line test

 port backup

ADLB ADSL line card The ADLB card supports:


 16 ADSL ports

 a built-in splitter

ADMB ADSL/ADSL2+ line The ADMB card supports:

Huawei Technologies Proprietary

16
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Abbr. name Full name Function description

 16 ADSL/ADSL2+ ports
card
 a built-in splitter

ADMC ADSL/ADSL2+ line The ADMC card supports:


card  16 ADSL/ADSL2+ ports

 A built-in splitter

EAUA Ethernet line The EAUA card supports:


card  eight Ethernet ports

Table 1.5.1.I.1.1.4 Description of broadband and narrowband combo line cards

Abbr. Name Full name Function description

CSMB ADSL/ADSL2+ and The CSMB card supports:


POTS combo line  16 ADSL/ADSL2+ ports
card  16 POTS ports

 a built-in splitter

Table 1.5.1.I.1.1.5 Description of other cards

Abbr. Name Full name Function description

AIUB ATM interface The AIUB card carries out remote


card subtending of the UA5000.

An AIUB card supports:


 two STM-1 ATM ports or two ATM E3
ports

 eight IMA E1 ports through backplane

 1+ 1 card-level protection

DEHA Circuit emulation The DEHA card supports:


E1 interface card  16 E1 ports

 unstructured CES

EDTB E1 trunk card The EDTB card supports:


 16 E1 trunk ports

TSSB Test card The TSSB and TSSC cards are used to

TSSC test the narrowband and broadband line


cards. TSSC card supports Tx and Rx of
1 kHz signal tone.

Huawei Technologies Proprietary

17
Technical Manual Error: Reference source not foundError:
UA5000 Universal Access Unit Reference source not found

Abbr. Name Full name Function description

ESC Environment & The ESC card controls or monitors:


power supply  temperature
monitor card  humidity

 door sensor

 fan status

 battery status

 power supply status

This card reports the information


listed above to the control card
through a serial port.

PWX Secondary power The PWX card occupies one slot. A frame
supply card can use a minimum of one card and a
maximum of two. The PWX card supports
inter-card and inter-frame load-
sharing.

Huawei Technologies Proprietary

18
Huawei Technologies Proprietary

19

Das könnte Ihnen auch gefallen