Sie sind auf Seite 1von 4

USB to Serial TLL/CMOS Logic

Module

USB to Serial TLL/CMOS Logic Module

Introduction
This USB to serial converter is based on FT232 from FTDI. It gives out all 8 pins of the
serial port at user selectable 3.3 or 5V logic levels. It has Transmit and Receive indicator data
LEDs. It is most suitable for serial communication where data flow control is important.
Since all the pins of the module are available at 5V / 3V3 and TTL / CMOS levels it can also
be used for ISP (In System Programming) applications for microcontrollers such as NXP’s
ARM7 (LPC 2148, LPC2138…), 8051 (P89V51RD2….) etc. It has four mounting holes
which makes it easy to integrate in your design. It can also provide 5V 400mA and 3.3V
30mA supply for powering external device. Board is made up of two layers PTH PCB for
giving extra strength to the connectors.

Specifications
• USB powered
• Tx and Rx indicator LEDs
• Achievable data rates: 2400 to 115200 bps
• Serial pins available: TXD, RXD, CTS, DCD, DSR, DTR, RTS, RI and Ground
• 5V, 400mA and 3.3V, 30mA available for powering external device
• Two layer PTH PCB for giving extra strength to the connectors
• Used for serial communication involving flow control and for ISP for
microcontrollers which uses serial port

NEX Robotics Pvt. Ltd. 1


www.nex-robotics.com
USB to Serial TLL/CMOS Logic
Module

Connections:

Figure 1: Pin Configuration

Pin# Pin name Analog function


1 3V3 3.3V supply voltage
2 5V 5V supply voltage
3 CD carrier detect
4 RXD Serial data receive in
5 TXD Serial data transmit out
6 DTR Data terminal ready
7 GND Supply Ground
8 DSR Data set ready
9 RTS Request to send
10 CTS Clear to send
11 RI Ring indicator

Pin Description:

3V3 (Supply Voltage): Gives out 3.3V output. It can only supply maximum of 30mA. Do
not use this supply unless absolutely necessary.

5V (Supply Voltage): Gives out 5V supply from the USB port. It can supply current
depending on your PC’s USB port’s power configuration (high power / low power mode). As
a rule of thumb do not draw more than 100mA from the pin.

CD (Carrier Detect): This signal is used by a modem to signal that it has a made Connection
with another modem, or has detected a carrier tone.

RXD (Serial Data IN): Is serial data in pin. Receives Serial data from external TTL/CMOS
UART.

TXD (Serial Data OUT): Is serial data out pin. Transmit Serial data to external TTL/CMOS
UART.

NEX Robotics Pvt. Ltd. 2


www.nex-robotics.com
USB to Serial TLL/CMOS Logic
Module

DTR (Data Terminal Ready): This is out-going hand-shaking signal.

GND: Connect to supply ground

DSR (Data set ready): This is in-coming hand-shaking signal.

RTS (Request to send): This is out-going flow-control signal.

CTS (clear to send): This is in-coming flow-control signal.

RI (Supply Voltage): A modem toggles the state of this line when an incoming call rings
your phone.

Logic level selection:


Logic level of the USB to Serial TLL/CMOS Logic Module can be set at 3.3V or 5V by
setting logic level selection jumper shown in figure 1. Set the jumper at 3.3V or 5V as per
your requirement.

Note:
If logic level selection jumper is absent USB to Serial TLL/CMOS Logic Module will
not work.

Package contains:
1. USB to true serial TTL/CMOS Logic module: Qty. 1
2. Documentation CD

NEX Robotics Pvt. Ltd. 3


www.nex-robotics.com
USB to Serial TLL/CMOS Logic
Module

Notice
The contents of this manual are subject to change without notice. All efforts have been made to ensure the
accuracy of contents in this manual. However, should any errors be detected, NEX Robotics welcomes your
corrections. You can send us your queries / suggestions at
info@nex-robotics.com

Content of this manual is released under the Creative Commence cc by-nc-sa license. For legal information
refer to: http://creativecommons.org/licenses/by-nc-sa/3.0/legalcode

Product’s electronics is static sensitive. Use the product in static free environment.
Read the user manuals completely before start using this product

Recycling:
Almost all the part of this product are recyclable. Please send this product to the recycling plant after its
operational life. By recycling we can contribute to cleaner and healthier environment for the future generations.

NEX Robotics Pvt. Ltd. 4


www.nex-robotics.com

Das könnte Ihnen auch gefallen