Beruflich Dokumente
Kultur Dokumente
2 Y ic Layer 4 protocol does EIGRP use to provide reliability for te transmission of
routing information?
a Y L
b Y IP
c Y P
d Y RTP****
e Y TCP
f Y P
3 Y network administrator issues te command sow ip route and sees tis line of
output:
V92 V68 3 0/24 [V20/2] via V92 V68 2 2, 00:00:05, Serial0/0
at two pieces of information can be obtained from te output? (Coose two
a Y RIP is te routing protocol configured ****
b Y Tis is a static route to network V92 V68 3 0 ****
c Y Te metric for tis route is 2
d Y Te next periodic update is in 5 seconds
e Y Te autonomous system number is V20
5 Y at two problems may occur if te EIGRP default bandwidt for a serial link is
iger tan te actual bandwidt? (Coose two
a Y Routing updates will arrive too quickly for receiving routers to process
b Y Te port IP address will be rejected by te routing protocol
c Y Suboptimal pats will be selected
d Y Te port protocol will return to te HLC default
e Y VLS support will be disabled ****
f Y etwork convergence may be affected *****
6Y at two statements are correct regarding EIGRP autentication? (Coose two
aY EIGRP autentication uses te 5 algoritm ****
bY EIGRP autentication uses a pre-sared key ****
cY EIGRP autentication requires tat bot routers ave te same key cain name
dY EIGRP autentication uses varying levels of EP to encrypt data excanged
between routers
e Y EIGRP autentication can be configured on one router and updates from tis router
are protected; wereas a neigbor router can be witout te autentication
configuration and its updates are unprotected
7 Y Refer to te exibit ic statement is true about te EIGRP autentication
configuration?
a Y RT and RTB will accept updates from eac oter
b Y RT and RTB will not accept updates from eac oter because key V on RTB does
not matc RT *****
c Y RT and RTB will not accept updates from eac oter because te key cain names
do not matc
d Y Te ip autentication mode S does not matc te locally configured S
8 Y Refer to te exibit Routers and B ave EIGRP configured and automatic
summarization as been disabled on bot routers ic router command will
summarize te attaced routes?
a Y ip area-range eigrp V V92 V68 V0 80 255 255 255 224
b Y ip summary-address eigrp V V92 V68 V0 64 255 255 255 V92****
c Y ip summary-address V92 V68 V0 80 0 0 0 3V
d Y ip summary-address eigrp V V92 V68 V0 64 0 0 0 63
e Y ip area-range eigrp V V92 V68 V0 64 255 255 255 224
VV YRefer to te exibit Routers RTR-V and RTR-3 are completely configured Te
administrator needs to configure te routing protocol on router RTR-2 so tat
communication occurs trougout tenetwork ic group of commands will
successfully configure EIGRP on RTR-2?
a Y RTR-2(config router eigrp V*****
RTR-2(config-router network V98 V8 76 0
b Y RTR-2(config router eigrp V
RTR-2(config-router network V98 V8 76 0 0 0 0 3 no-summary
RTR-2(config-router network V98 V8 76 4 0 0 0 3 no-summary
RTR-2(config-router network V98 V8 76 V28 0 0 0 V92 no-summary
c Y RTR-2(config router eigrp V
RTR-2(config-router network V98 V8 76 0 0 0 0 3 area 0
RTR-2(config-router network V98 V8 76 4 0 0 0 3 area 0
RTR-2(config-router network V98 V8 76 V92 0 0 0 V92 area 0
d Y RTR-2(config router eigrp V
RTR-2(config-router network V98 V8 76 0 0 0 0 3
RTR-2(config-router network V98 V98 76 4 0 0 0 3
RTR-2(config-router network V98 V98 76 V28 0 0 0 V92
V3 Yat two statements are true regarding EIGRP tables? (Coose two
a Y feasible successor route can be found in te topology table ****
b Y successor route can only be found in te routing table
c Y Te topology table sows weter a route is in te passive or active state ****
d Y Te routing table sows te amount of time elapsed since a router adjacency was
formed
e Y Te neigbor table sows all adjacent Cisco devices
f Y dministrative distance is sown as a column in te neigbor table
V6 Yat is te purpose of te network command wen RIP is being configured as te
routing protocol?
a Y It identifies te networks connected to te neigboring router
b Y It restricts networks from being used for static routes
c Y It identifies all of te destination networks tat te router is allowed to install in its
routing table
d Y It identifies te directly connected networks tat will be included in te RIP routing
updates ****
V7 Yat is te maximum number of ops tat RIP will attempt before it considers te
destination unreacable?
a Y V4 ops
b Y V5 ops*****
c Y V6 ops
d Y V7 ops
V8 Yat does a router tat is running RIP use to determine te best pat to take wen
forwarding data?
a Y te ost portion of te network address****
b Y te speed of network convergence
c Y te calculated metric for te destination network
d Y te number of broadcasts occurring on an interface
e Y te number of errors occurring on an interface
V9 YRefer to te exibit ic statement is true about te output from te sow ip
protocols command?
a Y RIPv2 is configured on tis router ****
b Y uto summarization as been disabled
c Y Te next routing update is due in V7 seconds
d Y V92 V68 V6 V is te address configured on te local router
20 Yat tree statements are true about routers tat are configured for EIGRP?
(Coose tree
a Y Tey can support multiple routed protocols ****
bY Tey can support only link-state protocols
cY Tey send teir entire routing tables to neigboring routers
dY Tey send partial routing updates in response to topology canges ****
eY Tey send routing updates to all oter routers in te network
fY Tey use ello packets to inform neigboring routers of teir status ****