Beruflich Dokumente
Kultur Dokumente
PREPARATION
● Before beginning installation of product, make sure all parts are present. Compare parts with package
contents list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or
operate the product. Contact customer service for replacement part.
● Estimated Assembly Time: 15 - 30 minutes
● Tools Required for Assembly (not included): Flathead screwdriver , Phillips screwdriver, pliers, electrical
tape, wire cutters, safety glasses &3, 100 Watt, Type - A Medium Base Bulbs.
● Helpful Tools (not included): Wire Strippers.
1 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: LSM2825TM,LSM2825PS
STEP 1:
a . Determine the Rods to be assembled according to your
desired hanging height.
b . Pass the Supply Wires with Ground Wire through the 6” Rod
chosen Rods and then thread Rods and Socket Assembly
together as shown. Tighten until snug. 6” Rod
12” Rod
12” Rod
Socket
Assembly
STEP 2:
a . Pass the Supply Wires with Ground Wire through the Ceiling
Canopy
Swivel and Ceiling Canopy.
b . Thread the Swivel onto the top end of the Upper Rod and
hand tighten until snug.
Swivel
Upper Rod
Outlet Box
Outlet Box Screw
2 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: LSM2825TM,LSM2825PS
STEP 4 :
* Use Wire Connectors ( not supplied ) to connect the WHITE OR RIBBED WHITE OR RIBBED
wires . FROM HOUSE FROM FIXTURE
a . Connect the House Ground Wire to the Fixture Ground
Wire.
b . Connect the House White ( or Ribbed ) Wire to the BLACK ( OR RED ) WIRE BLACK OR SMOOTH
Fixture Supply Wire ( White or Ribbed Side ) .
FROM FIXTURE
c . Connect the House Black ( or Red ) Wire to the Fixture FROM HOUSE
Supply Wire ( Black or Smooth Side ).
d . Wrap each connection with approved electrical tape and
GROUND WIRE GROUND WIRE
carefully stuff all of the connected wires into the Outlet
FROM HOUSE FROM FIXTURE
STEP 5 :
a . Place the Ceiling Canopy over the Mounting Screws and
Outlet Box
thread Mounting Balls onto the Mounting Screws to secure
it. Hand tighten until snug.
Mounting Screw
Ceiling Canopy
Mounting Ball
STEP 6 :
a . Thread the beaded end of the Stem into the coupling
underside of the Socket Cluster. Hand tighten until snug.
Socket Cluster
Stem
STEP 7 :
a . Locate the Shade over the Center Stem, match the Holes
on Tabs onto the Mounting Holes on the ends of the Side
Arms. Side Arm
b. Thread Lock Screws into the Mounting Holes and hand
tighten until snug to secure the Shade. Tab
Lock Screw
Shade
Center Stem
3 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: LSM2825TM,LSM2825PS
STEP 8 :
a . Install the correct Bulbs referring to fixture markings and/or labels for maximum wattage.
STEP 9:
a. Locate the Diffuser over the end of the Stem, attach onto
the Tabs on the bottom of the Shade. And then place the Shade
Rubber Washer and the Steel Washer over the end of the
Stem. Secure them by threading the Knurled Nut onto the
Stem. Hand tighten until snug.
b. Locate the Cap over the end of the Stem and secure with
the Finial. Hand tighten until snug.
Socket Cluster
Stem
Tab
Rubber Washer
Diffuser
Your installation is completed now. Restore electricity. Retain this sheet for future reference.
4 OF 4