Beruflich Dokumente
Kultur Dokumente
6 CORPORATE PARKWAY
GOOSE CREEK , SC . 29445 STYLE NUMBER: TY1721AN, TY1721WT
www . quoizel . com
1 OF 4
PREPARATION STYLE NUMBER: TY1721AN, TY1721WT
● Before beginning installation of product, make sure all parts are present. Compare parts with package contents
list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or operate the
product. Contact customer service for replacement part.
● Estimated Assembly Time: 30 - 45 minutes
● Tool Required for Assembly (not included): Flathead screwdriver, Phillips screwdriver, Pliers, Electrical tape,
Wire cutter, Safety glasses and (4) 100W Type-A medium base bulbs .
● Helpful Tools (not included): Wire strippers.
INSTALLATION INSTRUCTIONS
Connector
Ring
Outlet Box
Outlet Box Screw
2 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: TY1721AN, TY1721WT
STEP 3:
a. Locate the Ceiling Canopy onto the Crossbar and slip
the Button Stop on the end of Lanyard into the Slot on Crossbar
the Crossbar as shown.
Slot
Button Stop
Lanyard
Ceiling Canopy
STEP 4:
Use Wire Connectors (not supplied) to connect the
WHITE OR RIBBED WHITE OR RIBBED
wires.
a. Connect the House Ground Wire to the Fixture Ground FROM HOUSE FROM FIXTURE
Wire.
b. Connect the House White (or Ribbed) Wire to the
Fixture Supply Wire (Black or Smooth Side). BLACK (OR RED) WIRE BLACK OR SMOOTH
c. Connect the House Black (or Red) Wire to the Fixture FROM FIXTURE
FROM HOUSE
Supply Wire (Black or Smooth Side).
d. Wrap each connection with approved electrical tape
and carefully stuff all of the connected wires into the GROUND WIRE GROUND WIRE
Outlet Box.
FROM HOUSE FROM FIXTURE
STEP 5:
a. Place the Ceiling Canopy over the Mounting Screws
and secure with the Mounting Balls. Hand-tighten until Outlet Box
snug.
Mounting
Screw
Ceiling
Canopy
Mounting Ball
STEP 6:
a. Screw the beaded end of the Center Stem into the Hex
Coupling underside of the Junction Box. Hand-tighten
until snug.
Hex Coupling
Junction Box
Center Stem
3 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER: TY1721AN, TY1721WT
STEP 7:
a. Pass the Spacer Tube, the Check Ring, the Flat
Washers, the Rubber Washers and the Shade over the
end of the Center Stem as shown. Secure them by
threading the 1/8 IP Hex Nut onto the Center Stem.
Hand-tighten until snug.
Center Stem
Spacer Tube
Check Ring
Shade Flat Washer
Rubber Washer
Rubber Washer
Flat Washer
1/8 IP Hex Nut
STEP 8:
a. Place the Cap over the end of the Center Stem and
secure with the Finial B. Hand-tighten until snug.
Center Stem
Cap
Finial B
STEP 9:
a. Install correct bulbs referring to fixture markings and/or labels for maximum wattage.
Your installation is completed now. Restore electricity. Retain this sheet for future reference.
4 OF 4