Beruflich Dokumente
Kultur Dokumente
CHANGE REQUEST
25.306 CR 106 rev Current version:
- 6.3.0
For HELP on using this form, see bottom of this page or look at the pop-up text over the symbols.
Proposed change affects: UICC apps ME X Radio Access Network X Core Network
Source: Fujitsu, Motorola, NEC, Nokia, Nortel Networks, NTTDocomo, Orange, Philips,
Vodafone Group
Reason for change: UE categories were discussed at RAN1#40 meeting. The proposed categories
classify the UEs in terms of 1) maximum number of E-DCH codes transmitted, 2)
support of the 2ms TTI and 3) maximum transport block size (i.e. maximum bit
rate). It was agreed that a total of 6 categories would span a reasonable range of
configurations. Among the 8 categories that were initially proposed, 5 were
agreed in RAN1. Two were felt as close enough to the agreed 5 to be potentially
removed. But there was no agreement wether the following category should be
included or not: 2xSF2, 10ms TTI only, 20000 bits. This category allows high bit
rate for 10ms TTI only configurations. Regardless of the gains a 2ms TTI may
bring, undoubtedly there is a benefit in making the 10ms TTI as efficient as
possible, and as such there should not be any reasons not to allow a category
aiming at doing so. Going even further, the maximum transport block size for
10ms TTI could be increased to 24000 bits. Therefore it is proposed to
standardize the 5 categories agreed in RAN1 with a maximum transport size of
th
24000 bits for the 10ms TTI + the 6 category that maximises the performance
of 10ms TTI only configurations.
Y N
CR page 1
Other specs X Other core specifications
affected: X Test specifications
X O&M Specifications
Other comments:
CR page 2
3GPP TS 25.306 v6.3.0 (2004-12) CR page 3
CR page 3
3GPP TS 25.306 v6.3.0 (2004-12) CR page 4
CR page 4
3GPP TS 25.306 v6.3.0 (2004-12) CR page 5
Radio frequency bands a), b), c), a+b), a+c), b+c), a+b+c)
TDD 1.28 Mcps UE power class 2, 3
RF parameters Radio frequency bands a), b), c), a+b), a+c), b+c), a+b+c)
Multi-mode related parameters Support of UTRA FDD Yes/No
Support of UTRA TDD 3.84 Mcps Yes/No
Support of UTRA TDD 1.28 Mcps Yes/No
Multi-RAT related parameters Support of GSM Yes/No (per GSM frequency band)
Support of multi-carrier Yes/No
Support of UTRAN to GERAN Yes/No
Network Assisted Cell Change
Security parameters Support of ciphering algorithm UEA0 Yes
Support of ciphering algorithm UEA1 Yes
Support of integrity protection Yes
algorithm UIA1
UE positioning related parameters Standalone location method(s) Yes/No
supported
Network assisted GPS support Network based / UE based / Both/
None
GPS reference time capable Yes/No
Support for IPDL Yes/No
Support for OTDOA UE based Yes/No
method
Support for Rx-Tx time difference type Yes/No
2 measurement
Support for UE Positioning assisted Yes
GPS measurement validity in
CELL_PCH and URA_PCH RRC
states
Support for SFN-SFN observed time Yes/No
difference type 2 measurement
Measurement related capabilities Need for downlink compressed mode Yes/No (per frequency band, UTRA
mode and RAT)
Need for uplink compressed mode Yes/No (per frequency band, UTRA
mode and RAT)
General capabilities Access Stratum release indicator R99, REL-4, REL-5
DL capabilities with simultaneous HS- DL capability with simultaneous HS- 32 kbps, 64 kbps, 128 kbps, 384 kbps
DSCH DSCH configuration
CR page 5
3GPP TS 25.306 v6.3.0 (2004-12) CR page 6
Table 5.1b: RLC and MAC-hs parameters for FDD HS-DSCH physical layer categories
Table 5.1d: RLC and MAC-hs parameters for 1.28 Mcps TDD HS-DSCH physical layer categories
CR page 6
3GPP TS 25.306 v6.3.0 (2004-12) CR page 7
Table 5.1f: RLC and MAC-hs parameters for 3.84 Mcps TDD HS-DSCH physical layer categories
CR page 7
3GPP TS 25.306 v6.3.0 (2004-12) CR page 8
CR page 8