Beruflich Dokumente
Kultur Dokumente
POWER SYSTEM
GROUP A
(Multiple Choice Question)
Choose the correct alternative answers of any ten questions from the following
10X1=10
A. The pick up current of a relay is 7.5 A and the fault current in the relay coil
is 30 A . Its plug setting multiplier is
a) 4 b) 2 c) 25 d) None of the above
B. The operator “a” rotates the vector in the anticlockwise direction through an
angle of :
a) 90o b) 120o c) 180o d) 360o
C. The surge impedance of 50 miles long underground cable is 50 ohms. For a
25 miles length of the same cable, it will be :
a) 25 ohms b) 50 ohms c) 100 ohms d) none of the above
D. A three phase circuit breaker is rated at 2000 MVA, 33KV. Its making
current will be:
a) 35KA b) 49KA c) 70 KA d) 89 KA
E. An acceleration factor is used for load flow studies by
a) Gauss- Seidal Method b) Newton- Raphson Method
c) Decoupled method d) None of the above
F. The voltage of a particular bus can be controlled by controlling
a) Phase angle b) Reactive power of the Bus
c) Active Power of the Bus d) Phase angle and reactive power
G. The order of lightening discharge current is :
a) 10000 A b) 100A c) 1A d) 1µA
H. The velocity of traveling wave in the transmission line depends on :
a) L only b) C only c) both L and C d) R only
I. A power system network with a capacity of 100MVA has a source
impedance of 10% at a point . The fault level at that point is :
a) 10 MVA b) 30 MVA c) 3000 MVA d) 1000MVA
J. When a line to ground fault occurs, the current in a faulty phase is 100A. The
zero sequence current is:
a) Zero b) 33.3 A c) 66.6 A d) 100A
GROUP B
(Short Answer Questions)
Answer any three questions
GROUP C
(Long Answer Question)
Answer any three questions