Beruflich Dokumente
Kultur Dokumente
LC-42D62U
SERVICE MANUAL
No. S57K2LC42D62U
SUPPLEMENT
MODEL LC-42D62U
In the interests of user-safety (Required by safety regulations in some countries) the set should be restored to its orig-
inal condition and only parts identical to those specified should be used.
OUTLINE
In this Service Manual, only parts in the LCD module are shown. For the other points, refer to the LC-42D62U
(S86V9LC42D62U) Service Manual.
New panel modules are incorporated in LC-42D62U with the Serial No.****51112~
How to distinguish the model labels of new and old panel modules.
As to the new panel module, the mark A is printed on the model label.
Example Example
LC-42D62U LC-42D62U
No Mark A
Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the
safety and performance of the set.
[1] Outline
In this Service Manual, only parts in the LCD module are shown. For the other points, refer to the LC-42D62U (S86V9LC42D62U) Service Manual.
New panel modules are incorporated in LC-42D62U with the Serial No.****51112~
How to distinguish the model labels of new and old panel modules.
As to the new panel module, the mark A is printed on the model label.
Example Example
LC-42D62U LC-42D62U
No Mark A
[2] Adjustment
When replacing the LCD control PCB, follow these steps to adjust VCOM.
1) Enter the adjustment process mode.
2) Select the item [VCOM ADJ] on the page 3/26 using the CH ( )/( ) keys on the remote controller.
3) Press the Enter key to check that the adjustment pattern is displayed.
4) Adjust the flicker in the middle of the screen to minimum using the VOL (+)/(-) keys on the remote controller.
5) Press the Enter key to turn off the pattern.
6) To exit the adjustment process mode after the adjustment is done, unplug the AC cord from the outlet to make a forced shutdown. (When the
power was turned off with the remote controller, once unplug the AC cord and plug it again. In this case, wait 10 seconds or so before plugging.)
CAUTION: Use due care in handling the information described here lest your users should know how to enter the adjustment process mode.
If the settings are tampered in this mode, unrecoverable system damage may result.
Description of display
TEMPAERATURE 7B
LAMP ERROR 0
i
PartsGuide
LC-42D62U
PARTS GUIDE
MODEL LC-42D62U
CONTENTS
Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these
parts with specified ones for maintaining the safety and performance of the set.
21
14
12
13 22
23-20
16
23-19 15
23-15
23-13 23-20
23-20
23-1
23-17
23-3
23-13 23-2
23-20 23-6
23-14 23-11 23-5
23-4 23-2
23-3
23-12
23-18
23-6
23-16 23-6
23-5
23-3
23-2
23-3 23-7
23-12
6 8
17
9
18
8
11 19
20 7
10
11 11
11
2
LC-42D62U
3
LC-42D62U
SHARP CORPORATION
AV Systems Group
CS Promotion Center
TQ2197-S YT. DS Yaita,Tochigi 329-2193, Japan