Beruflich Dokumente
Kultur Dokumente
uk
j^qbof^i==
p^cbqv==
a^q^=pebbq==
oÉîáëÉÇ=Nëí=gìåÉI=OMMS=
=
tefqb=pmfofq=_pOQR==
pb`qflk=NW=fabkqfcf`^qflk=lc=pr_pq^k`bLmobm^o^qflk=C=`ljm^kv
mêçÇìÅíLj~íÉêá~äW tefqb=pmfofq
m~êí=kçW= = = = MMOM=
^ééäáÅ~íáçåëW= = = = Solvent
j~åìÑ~ÅíìêÉêW R.K. & J. Jones Limited
^ÇÇêÉëëW= Southery Road, Feltwell
Thetford
Norfolk, IP26 4EH
qÉäW= = 01842 828101
c~ñW= = 01842 828171
bãÉêÖÉåÅó=qÉäÉéÜçåÉ=kçErhFW 0207 405 5375 (24 HOUR)
pb`qflk=OW=`ljmlpfqflkLfkcloj^qflk=lk=fkdobafbkqp=
fåÖêÉÇáÉåí=k~ãÉ= bfkb`p= `^p=kç= `çåíÉåíë= póãÄçä== oáëâ=
= == = = = = Eo=kçKF=
Naptha (Petroleum), 265-185-4 64742-82-1 100% Xn N 10,65,51/53,66
Hydrodesulfurized Heavy
=
br=fåÇÉñW 649-330-00-2
cçêãìä~W N/A
`^p=kçW 64742-82-1
`çãéçëáíáçå=`çããÉåíëW
Benzene (CAS No. 71-43-2) will normally be present in trace amounts, but will always be less than the
0.1% w/w marker level in the 21st ATP to the Dangerous Substance Directive. This White Spirit is not
Classified as a carcinogen under 67/548/EEC and The CHIP regulations 1996.
pb`qflk=PW=e^w^oap=fabkqfcf`^qflk=
cä~ãã~ÄäÉK=
e~êãÑìäW== May cause lung damage if swallowed. Repeated exposure may cause
skin dryness or cracking. Toxic to aquatic organisms, may cause long
term adverse effects in the aquatic environment.
In the environment it is likely to biodegrade slowly. On the basis of
information supplied it is unlikely to be hazardous to man in normal
use; it should, however be noted that it is classified as flammable.
pb`qflk=QW==cfopq=^fa=jb^probp
dÉåÉê~äW Do not give victim anything to drink if he/she is unconscious.
pb`qflk=R=W=cfob=cfdeqfkd=jb^probp=
bñíáåÖìáëÜáåÖ=jÉÇá~W Carbon dioxide (CO2). Dry chemicals, sand, dolomite Etc. Foam.
péÉÅá~ä=cáêÉ=cáÖÜíáåÖ=mêçÅÉÇìêÉëW=
Fires in closed or confined spaces should be tackled by trained
personnel who should wear breathing apparatus.
råìëì~ä=cáêÉ=C=bñéäçëáçå=e~ò~êÇëW==
Material may accumulate a static charge which could act as an
ignition source. Run off from fire must not empty drains.
e~ò~êÇçìë=aÉÅçãéçëáíáçå=mêçÇìÅíëW===
Carbon monoxide (CO). Oxides of: Carbon.
pb`qflk=SW==^``fabkq^i=obib^pb=jb^probpLpmfiip=^ka=ib^hp
mÉêëçå~ä=mêÉÅ~ìíáçåë=ÇìêáåÖ=ëéáääW=
= = = Repeated exposure can cause skin dryness and cracking. Wear
suitable protective clothing. Ensure good ventilation. Avoid breathing
vapour.
mêÉÅ~ìíáçåë=íç=mêçíÉÅí=båîáêçåãÉåíW=
Do not let the product or washing down water enter natural water
courses or the sewers.
pb`qflk=T=W=e^kaifkd=^ka=pqlo^db
rë~ÖÉ=mêÉÅ~ìíáçåëW Keep away from heat, sparks and open flame. Avoid spilling, skin and
eye contact. Where prolonged or repeated exposure is likely
PROTECTIVE CLOTHING should be worn including IMPERVIOUS
GLOVES and EYE PROTECTION. Ensure good ventilation.
rë~ÖÉ=aÉëÅêáéíáçåW Use only containers, pipes, joints and seals that are resistant to
hydrocarbons.
píçê~ÖÉ=mêÉÅ~ìíáçåëW Keep in cool, dry, ventilated storage and closed containers. Ground
container and transfer equipment to eliminate static electric sparks.
Protect from light, including direct sunrays. Flammable/combustible –
Keep away from oxidisers, heat and flames.
pb`qflk=U=W=bumlprob=`lkqolip=L=mboplk^i=molqb`qflk
fåÖêÉÇáÉåí=k~ãÉ= = `^p=kç= ==pqa= = iq=bum== pq=bum=
== = = = = = EUÜêëF= = ENRãáåF=
Naptha (Petroleum), Hydrodesulfrized 64742-82-1 OES 600.00 mg/m3
Heavy
=
fåÖêÉÇáÉåí=`çããÉåíëW OEL calculated by using the Reciprocal Calculation
Procedure (EH40/96)
mêçíÉÅíáîÉ=bèìáéãÉåíW
mêçíÉÅíáîÉ=däçîÉëW Use suitable protective gloves if risk of skin contact. Ensure gloves
are manufactured/tested in accordance with BS EN 374. Determined
penetration times carried out in accordance with EN 374 part III are
not performed under practical conditions. Therefore a maximum
wearing time corresponding to 50% of the penetration time is
recommended.
eóÖáÉåáÅ=tçêâ=oçìíáåÉëW Wash at the end of each working shift and before eating, smoking and
using the toilet. Wash promptly if skin becomes wet or contaminated.
pb`qflk=VW=mevpf`^i=^ka=`ebjf`^i=molmboqfbpK
^ééÉ~ê~åÅÉW Liquid.
lÇçìêLq~ëíÉW Characteristic.
mÜóëáÅ~ä=a~í~=`çããÉåíëW Aromatics %vol. 17-20
pçäìÄáäáíó=aÉëÅêáéíáçåW Insoluble in water
pçäìÄáäáíó=s~äìÉ=EÖLNMMÖ=eOMLOM⁄`W= <0.1
péÉÅáÑáÅ=dê~îáíó=Eï~íÉêZNFW 0.79 at 15ºC
s~éçìê=mêÉëëìêÉW= 0.4 @ 20ºC
s~éçìê=aÉåëáíóW 4.5-5
sáëÅçëáíóW 0.74-1.65 0.95 x 10(-6)m2/sec cps @ 25ºC
cä~ëÜ=mçáåí=jÉíÜçÇW CC (Closed cup)
^ìíç=fÖåáíáçå=qÉãéÉê~íìêÉE⁄`FW 230
cä~ãã~Äáäáíó=iáãáí=EìééÉêBFW N/D
`çäçìêW= = Colourless
_çáäáåÖ=mçáåíW= 150-200
lÇçìê=qÜêÉëÜçäÇ=EäçïÉêFW= 0.5mg/m3
cä~ëÜ=mçáåí=E⁄`F= 38
cä~ëÜ=mçáåí=jÉíÜçÇW CC (Closed cup)
cä~ãã~Äáäáíó=iáãáí=EìééÉê=BFW 6.5
cä~ãã~Äáäáíó=iáãáí=EäçïÉê=BFW 0.6
pb`qflk=NM=W=pq^_fifqv=^ka=ob^`qfsfqv=
pí~ÄáäáíóW Avoid heat, sparks, and flames.
pb`qflk=NO=W=b`lildf`^i=fkcloj^qflk=
båîáêçåãÉåí~ä=e~ò~êÇëW Can be expected to biodegrade slowly. Harmful to aquatic
organisms.
pb`qflk=NPW=afpmlp^i=`lkpfabo^qflkp
dÉåÉê~äL`äÉ~åáåÖW= Contaminated packages must be completely emptied before
sending away for laundering and re-use.
pb`qflk=NQ=W=qo^kpmloq=fkcloj^qflk
i~ÄÉä=Ñçê=`çåîÉó~åÅÉW
ol^aW=
rk=kçW 1300 ^ao=`ä~ëë=kçW 3
e~ò~êÇ=`ä~ëë=E^aoFW Class 3: Flammable Liquids
^ao=m~Åâ=dêW 31(c) ^ao=i~ÄÉä=kçW 3
e~òÅÜÉã=`çÇÉW 3Y
mêçéÉê=pÜáééáåÖ=k~ãÉW Turpentine Substitute
=
o^fiW=
pb^W=
rk=pÉ~W== 1300
pÉ~=íê~åëéçêí=`ä~ëë=kçW 3.3 fjad=m~ÖÉ=kçW 3375
=
=
^áêW=
rk=^áêW= = 1300
^áê=qê~åëéçêí=`ä~ëë=kçW 3 ^áê=m~Åâ=dêçìéW 3
pb`qflk=NR=W=obdri^qlov=fkcloj^qflk=
bb`=Ebfkb`pF=kçW 265-185-4
i~ÄÉäë=cçê=pìééäóW
pb`qflk=NS=W=lqebo=eb^iqe=^ka=p^cbqv=fkcloj^qflk=
rëÉê=kçíÉëW Since emptied containers retain residue, follow label warnings even after
container is emptied. Residual vapours may explode on ignition; do not cut,
drill or grind or weld on or near this container. For further Health & Safety
Information contact: Health & Safety Officer. Labels should not be removed
from containers until they have been issued in accordance with the Chemicals
(Hazard Information and Packaging Supply) (Amendment) Regulations 1999
(2).
oÉîáëáçå=`çããÉåíëW Amendment to section/s (1),(2), (16) Classification, Packaging and Labelling of
Chemicals. CHIP3
oÉîáëáçå=a~íÉW 20/06/02
oÉîáëáçå=kçKLoÉéä~ÅÉë=pahë=fëëìÉÇW 4-30/06/02
pap=kçW= = 0020.
If this product is re-distributed and re-formulated for sale, details of its hazards and recommended
methods for safe handling must be passed to customers. Customers are urged to ensure that the
product is entirely suitable for their own purpose. It is the customer’s responsibility to ensure that a
suitable and sufficient assessment of the risks created by a work activity using this product is
undertaken before this product is used.=
=
kçíÉW The information contained in this Safety Data Sheet does not constitute the users own
assessment of workplace risk as required by other Health & Safety Legislation (e.g. the Health and
Safety at Work Act,1974;the control of Substances Hazardous to Health Regulations,1988). The data
given here is based on current knowledge and experience. The purpose of this data sheet is to
describe the products in terms of their safety requirements. The data does not signify any warranty
with regard to the product's properties.