Beruflich Dokumente
Kultur Dokumente
Time Remaining:
priority 8192
priority 2048
Refer to the exhibit. If switch SW1 is configured with the four VLANs as shown in the
exhibit, how many physical interfaces are needed on router R1 to configure inter-VLAN
routing using subinterfaces?
Zero
One
Two
Four
Final del formulario
Refer to the exhibit. After the listed commands are entered into router R1 and switch S1, PC1
and PC2 cannot ping each other. The network administrator enters the show interfaces
trunk command and gets the results that are shown. What is the likely problem?
The router has not been configured with a routing protocol.
The trunk is established, but no VLANs have been configured to use it.
The trunk has not been established because the switch port has not been configured for
trunking.
The switch, the router, or both must be configured with the dynamic desirable option for
the Dynamic Trunking Protocol to establish a trunk.
Final del formulario
Refer to the exhibit. How will the configuration affect users who manage the switch over
HTTP?
The users will not require any additional authentication.
The users will be required to use the switch enable password for authentication.
The users will be authenticated by a separate server that is explicitly configured to
handle user authentication.
The users will be required to use the login username, password, and privilege level
credentials for authentication.
Final del formulario
Frames that contain an unknown destination MAC address are dropped by the switch.
The source MAC address within a frame is used by the switch to associate a port with
that MAC address.
Frames are directed by the switch from one port to another based on the destination
MAC address within the frame.
Data packets are forwarded by the switch from one port to another based on the
destination IP address within the packet.
Final del formulario
Refer to the exhibit. Host A and host B are not able to send traffic to each other. On the
basis of the output that is provided, what is the cause of the problem?
mismatched speed settings
VTP v2 is disabled.
Final del formulario
fast-forward
fragment-free
store-and-forward
Final del formulario
12 Principio del formulario
Why is it important that the network administrator consider the spanning-tree network
diameter when choosing the root bridge?
The network diameter limitation is 9.
Refer to the exhibit. SW1 has recently been installed to replace a hub. Hosts 1 and 4 both
transmit data at the same time. How will this event be handled by the network devices?
(Choose two.)
When a collision occurs, a backoff algorithm is invoked.
Refer to the exhibit. The network administrator is planning five additional VLANs to be
shared throughout the VTP domain on S3. What action should the administrator take before
creating the additional VLANs?
Create the VLANs on a switch in VTP server mode and allow them to propogate to the
other switches in the domain.
Modify the configuration revision to 10 to support the additional VLANs.
Enable the VTP pruning mode in order to create the VLANs on S3.
Close Window
All contents copyright 1992-2011 Cisco Systems, Inc. Privacy Statement and
Trademarks.
Time Remaining:
16 Principio del formulario
Refer to the exhibit. Switch SWA is not processing VTP advertisments from switch SWB.
What can done to correct the error?
Change the hostname of SWC to SWA.
disabled port
designated port
non-designated port
Final del formulario
to increase the bandwidth between the switch and its upstream device
Final del formulario
Refer to the exhibit. Users A and B are reporting intermittent connectivity problems. Pre-
installation surveys showed strong signal strength from the AP locations to the client
locations. Outside electrical interference has been eliminated. What will fix the problem?
Relocate the APs closer to each other.
four
five
eight
nine
Final del formulario
Refer to the exhibit. What can be determined from the configuration of this wireless
device?
This configuration is commonly found in an ad hoc network.
All wireless devices that are connected to this access point must have the SSID of
Academy.
Any wireless clients that are attached to this access point would have the same IP
address and SSID.
Any wireless clients that are attached to this access point must be connected using the
802.11n WAN protocol.
Final del formulario
Refer to the exhibit. Router RA receives a packet with a source address of 192.168.1.65
and a destination address of 192.168.1.161. What will the router do with this packet?
The router will drop the packet.
The router will forward the packet out interface FastEthernet 0/1.1.
The router will forward the packet out interface FastEthernet 0/1.2.
The router will forward the packet out interface FastEthernet 0/1.3.
The router will forward the packet out interface FastEthernet 0/1.2 and interface
FastEthernet 0/1.3.
Final del formulario
routing protocol
traffic that is leaving an access mode port that is connected to another switch
Final del formulario
Refer to the exhibit. Hosts A and B, connected to hub HB1, attempt to transmit a frame at
the same time but a collision occurs. Which hosts will receive the collision jamming
signal?
only hosts A and B
192.168.1.22 /28
192.168.1.33 /28
192.168.1.44 /28
192.168.1.55 /28
Final del formulario
<Pr Pa Ne
Showing 2 of 4
ev ge: xt>
Time Remaining:
VLAN 50 is not allowed on the trunk link between Switch1 and Switch2.
Final del formulario
Refer to the exhibit. The hosts connected to switch SW1 are not able to communicate with
the hosts in the same VLANs connected to switch SW2. What should be done to fix the
problem?
Configure VLANs with different VLAN IDs on switch SW2.
Reconfigure the trunk port on switch SW2 with static trunk configuration.
all VLANs
Final del formulario
The Cisco IOS version does not support disabling the command history buffer.
The size parameter reset the default buffer size but did not disable access to the buffer.
Final del formulario
9
Refer to the exhibit. R1 is configured for traditional inter-VLAN
routing. R1 can ping computer 3 but cannot ping computer 1. What
is a possible cause for this failure?
S1 port Fa0/11 is in the wrong VLAN.
Cat-B
Cat-C
Cat-D
Final del formulario
AM radio
television
MP3 player
cordless phone
microwave oven
Final del formulario
D
Final del formulario
Close Window
All contents copyright 1992-2011 Cisco Systems, Inc. Privacy
Statement and Trademarks.
Final del formulario
Close Window
All contents copyright 1992-2011 Cisco Systems, Inc. Privacy Statement and
Trademarks.
Time Remaining:
Divide the computers into separate workgroups using different physical switches.
Final del formulario
root
server
transparent
Final del formulario
Close Window
All contents copyright 1992-2011 Cisco Systems, Inc. Privacy Statement and
Trademarks.
Final del formulario