Beruflich Dokumente
Kultur Dokumente
Manual:MPLS/LDP
Applies to RouterOS: v3, v4 +
Summary
MikroTik RouterOS implements Label Distribution Protocol (RFC 3036, RFC 5036) for IPv4. LDP is a protocol
defined for distributing labels. It is the set of procedures and messages by which Label Switched Routers (LSRs)
establish Label Switched Paths (LSPs) through a network by mapping network-layer routing information directly to
data-link layer switched paths.
General
Sub-menu: /mpls ldp
General LDP settings.
Properties:
Property Description
distribute-for-default-route (yes | no; Defines whether to distribute label for default route or not.
Default: no)
hoplimit (integer; Default: 255) Max hop limit used for loop detection.
loop-detect (yes | no; Default: no) Defines whether to run LSP loop detection or not. Will not work correctly if not enabled on all LSRs.
Should be used only on non-TTL networks such as ATM.
lsr-id (IP; Default: 0.0.0.0) Unique label switching router's ID. If set to 0.0.0.0 highest IP address on the router is used.
path-vector-limit (integer; Default: 255) Max path vector limit used for loop detection.
transport-address (IP; Default: 0.0.0.0) Specifies LDP session connections origin address and also advertise this address as transport address to
LDP neighbors. If set to 0.0.0.0 highest IP address on the router is used.
use-explicit-null (yes | no; Default: no) Whether to distribute explicit-null label bindings.
Interface
Sub-menu: /mpls ldp interface
List of interfaces that connects Label Switching routers.
Properties:
Manual:MPLS/LDP 2
Property Description
accept-dynamic-neighbors (yes | no; Default: Defines whether to discover neighbors dynamically or use only statically configured in LDP
yes) neighbors menu
disabled (yes | no; Default: no) Defines whether item is ignored or used
hello-interval (time; Default: 5s) The interval between hello packets that the router sends out this interface.
hold-time (time; Default: 15s) Specifies the interval after which a neighbor is declared as not reachable.
transport-address (IP; Default: 0.0.0.0) Used transport address if differs from general settings. If set to 0.0.0.0 transport address from
general settings is used.
Neighbors
Sub-menu: /mpls ldp neighbor
Properties
Property Description
disabled (yes | no; Default: no) Defines whether item is ignored or used
send-targeted (yes | no; Default: yes) Specifies whether to send targeted hellos, used for targeted (not directly connected) LDP sessions.
Read-only properties
Property Description
sending-targeted-hello (yes | no) Shows whether targeted hellos are sent to the neighbor.
vpls (yes | no) Shows whether the neighbor is used for VPLS tunnel.
Accept Filters
Sub-menu: /mpls ldp accept-filter
List of label bindings which should be accepted from LDP neighbors.
Properties:
Manual:MPLS/LDP 3
Property Description
accept (yes | no; Default: yes) Whether to accept label bindings from the neighbors for specified prefix.
disabled (yes | no; Default: no) Defines whether item is ignored or used
neighbor (all | IP; Default: all) Neighbor to which this filter applies.
Advertise Filters
Sub-menu: /mpls ldp advertise-filter
List of label bindings which should be advertised to LDP neighbors.
Properties:
Property Description
accept (yes | no; Default: yes) Whether to advertise label bindings to the neighbors for specified prefix.
disabled (yes | no; Default: no) Defines whether item is ignored or used
neighbor (all | IP; Default: all) Neighbor to which this filter applies.
[Back to Content]
Article Sources and Contributors 4