Beruflich Dokumente
Kultur Dokumente
1. () () 2. : 1.Gg03t 2.2 3. 4. 1. 2. 3. 4. 5. 6.
GG TE
D WA
Pair Introduction
Headset Feature s Headset Call Controls
1. 2. 3. MFB(Answer/End/Reject/Setup a handsfree connection) Volume Up Button Volume Down Button
1.
Additional information
Power supply
Do not wear your headset when charging. Power supply must be connected to designated power sources as marked on the product. To reduce risk of damage to the electric cord, only remove it by grasping onto the AC adaptor rather than the cord itself from the outlet. Make sure the cord is well positioned to avoid potential damage. Before attempting to clean the AC power adapter, please unplug the unit from any power source to reduce risk of electric shock. The AC power adapter is designed for indoor use only, and must not be used outdoors.
Before you can use your headset, you must pair it with your phone.
MFB
Emergency calls
IMPORTANT!
You should never rely solely upon any electronic device for essential communications (e.g. 911 calls). Keep in mind that when making or receiving a call, your headset and the electronic device connected to must be switched on and in a service area with adequate cellular signal strength. Emergency calls can sometimes be disturbed on certain cellular phone networks or when certain network services and/or phone fea tures are in use. Check with your local cellular service provider .
Note: Sni mode means your headset has a handsfree connection with your phone.
This manual is published by G.G. Telecom, without any warranty. The information contained in this document is subject to change without notice. All rights reserved.
2.
Volume Up Button
3.
The
word mark and logos are owned by the Bluetooth SIG, Inc. and any use of such
Charge
Before using your headset, read the Additional Information session in this user?s guide. Before you get started, charge your headset for 2 hours: 1. Plug the GG USB charging cable into your headset.
marks by G.G. Telecom is under license. Other trademarks and trade names are those of their respective owners.
Make a call
1. If there is no handsfree connection between your headset and your phone. Press the MFB to set up a handsfree connection with your phone. 2. Dial the number you want to call on your phone. 3. Press Send on your phone to make the call. If your phone and headset are successfully paired, you will hear ringing sound on your headset.
Battery information
One new battery, or one that has not been used for a long period of time, could have reduced capacity the rst few times it is used. Do not expose your headset in an environment temperature above +55 (+131 ). If your headset is operated in cold temperatures, the battery capacity is reduced. The battery can only be charged in temperatures between +10 ( (+55 ) and +45 ( (+113 )
2. Plug the other end of the GG USB charging cable into the PC?s USB port, GG charging adapter or GG car charger. The Red LED indicator turns on when the headset is charging. 3. When charging is complete (The Red LED indicator is o ), remove the GG charging adapter or GG car charger, and detach the GG USB charging cable from your headset.
Quick Tips
1. To power on your headset, press and hold the MFB (about 3 seconds) until the blue indicator ashes 2 times . After power on, your headset will connect to your last used phone automatically. 2. To power off your headset,press and hold the MFB (about 3 seconds)until the red indicator ashes 2 times . 3. To setup the handsfree connection to your last used phone, press the MFB when there is no handsfree connection between your headset and your phone (please refer to the LED indicator chart). 4. To voice dial, press the MFB when there is a handsfree connection between your headset and your phone (please refer to the LED indicator chart). 5. To answer or end a call, press the MFB when there is a call or during a call. 6. To reject a call, press and hold the MFB (about 2 seconds)when there is a call.(&) 7. To redial the last call, and hold the Volume Down Button press (about 2 seconds ). when there is a handsfree connection between your headset and your phone. (&) 8. To adjust the volume,press the Volume UP /Down Button when dur ing a call. 9. To mute/unmute the microphone, press the Volume Up Button and Vol ume Down Button at the same time when during a call. 10. To disable/enable the LED indicator, double press the Volume Up / Down Button when your headset is in standby mode. 11.To reset your headset to factory settings, the MFB press and Vol ume Up Button and Volume Down Button at the same time when your headset is in standby mode. (&): Your Bluetooth phone must support handsfree pro le.
Additional information
Product care
Please check for any exceptions, due to national requirements or limitations, in usage of Bluetooth equipment before using your headset. Please check the laws and regulations on the use of mobile phones and hands free equip ment like your headset in the areas where you drive. Do not carry or store ammable goods such as gas, liquid in your vehicle compartment containing your headset. Do not use your headset while the plane is in the air, Turn OFF your headset before board -
15.105(b)
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC rules. These limits are designed to provide reasonable protection against harmful interference in a residential installa tion. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interfer ence will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment o and on, the user is encouraged to try to correct the interference by one or more of the following measures: Reorient or relocate the receiving antenna. Increase the separation between the equipment and receiver. Connect the equipment into an outlet on a circuit di erent from that to which the receiver is connected. Consult the dealer or an experienced radio/TV technician for help. You are cautioned that changes or modi cations not expressly approved by the par ty responsible for compliance could void your authority to operate the equipment. -
turns on
is off
ing any aircraft. Do not use your headset near the medical equipment without requesting permission. Use of non-G.G. Telecom original accessories may result in lost of performance, product damage, electronic shock or injury, and warranty termination. Please note only G.G. Tele com service partners should remove or replace the battery. Do not attempt do disassemble your headset. your headset does not contain consumer serviceable or replaceable components. Only G.G. Telecom service partners should per form service. Do not place your headset in extreme hot or cold temperature. Do not place your headset in dusty or dirty area, and only use soft damp cloth to clean it. Do not place your headset near lit cigarettes, cigars or candles, or near open ames etc. Do not allow children to play with your headset, as they might injure themselves or others as well as your headset, and small parts of it may become a choking hazard. If you will not be using your headset for a while, store it in a place that is dry, free from damp, dust and extreme temperatures.
YEAR H
AR
LE
COM