1)
Doe.no. en
Rev.ind, Draft
pate 2006-03-28
From
Dept. TRAP
Phone +46 (0)21 321523
Fox +46 (0)21 146918
Email hakan.b.karlsson@se.abb.com
Ape.
1
Memo
Exchange of Main Processing Module (MPM) in RExSxx
Te
Copy to
Before starting the work with disassembling the terminal, please bear in mind the
consequences of the ESD phenomenon.
Most electronic components are sensitive to electrostatic discharge, and latent damage
‘may occur, unless measures are taken
In order to prevent this, an ESD wrist strap must be used during the replacement of
the module.
1. Switch off DC supply to the terminal.
2. Remove the green connectors on the rear of the terminal.
3. Remove all optical cables.
4. Remove the rear cover plate at the left side of the terminal, see the figure below.
ABB Power Technologies AB203)
ABB -- - °
ae
Date 2006-03-28
5. Remove (Draw out) the MPM module, which is placed in the slot $9.
6
7. Please note that the new MPM looks different
ABB Power Technologies ABDoe.na, en
Rev. nd
Date 2006-03-28
Abi
Mount the small optical interfaces for SPA/IEC and/or LON on new MPM (if
equipped).
8 _ Insert the new MPM module in the same slot.
9. Mount rear cover plate and green connectors.
10. Switch on DC supply,
11. Download configuration and settings.
Ifyou have any problems or questions, please contact SA-T Supportline
Phone: +46 21 321680
E-mail: sa-tsupportline@se.abb.com
ABB Power Technologies AB