Beruflich Dokumente
Kultur Dokumente
TO-252-5
1: Vcc
2: NC
3: GND
4: Vo1 5: VO2
PIN DISCRIPTION
PIN NO.
1 2 3 4 5
PIN NAME
Vcc N.C. GND Vo1 Vo2 Power Supply Not internally connected Ground 3.3V Output 2.5V Output
FUNCTION
UTC
QW-R102-017,C
UTC UR3325
BLOCK DIAGRAM
Vcc PIN 1
Vcc
Vcc Vcc + Vo2 Thermal Shut Down Current Limit Sat. Prevention PIN 5
NC PIN 2
PIN 3 GND
UTC
QW-R102-017,C
UTC UR3325
PARAMETER
OPERATING RATINGS(Ta=25)
PARAMETER
Input Voltage 3.3V Output current 2.5V Output current
SYMBOL
Vcc Io1 Io2
MIN
3.0
MAX
16.0 1 1
UNIT
V A A
ELECTRICAL CHARACTERISTICS
(Refer to the test circuit, Ta=25, VCC=5V unless otherwise specified.)
PARAMETER
Bias Current 3.3V Output Output Voltage 1 Dropout Voltage 1 Peak Output Current 1 Ripple Rejection 1 Line Regulation 1
SYMBOL
IB Vo1 VD1 Io1 R.R.1 VLINE1
TEST CONDITIONS
Io1=0mA, Io2=0mA Io1=500mA Io1=500mA, Vcc=3.135V f=120Hz, ein=1Vrms Io1=200mA Vcc=4V ~ 16V, Io1=500mA Io1=0mA ~ 1A Io1=5mA, TJ=0 ~ 125 Vcc=16V Io2=500mA f=120Hz, ein=1Vrms Io2=200mA Vcc=4V ~ 16V, Io2=500mA Io2=0mA ~ 1A Io2=5mA, TJ=0 ~ 125
MIN
TYP
0.8
MAX
1.5 3.366 0.5
UNIT
mA V V A dB
3.234 1.0 50
30 75
mV mV %/ mA
VLOAD1 Load Regulation 1 Temperature Coefficient of Output TCVO1 Voltage 1* Short circuit Output Current 1 IOS1 2.5V Output Output Voltage 2 Vo2 Peak Output Current 2 Io2 Ripple Rejection 2 R.R.2
2.450 1.0 50
2.550
V A dB
VLINE2 Line Regulation 2 VLOAD2 Load Regulation 2 Temperature Coefficient of Output TCVO2 Voltage 2* Short circuit Output Current 2 IOS2 Vcc=16V * Design Guarantee. (Outgoing inspection is not done on all products.) This product is not designed for protection against radioactive rays.
30 75
mV mV %/ mA
Note: All characteristic are measured with a capacity across the input (0.33F) and the output (22F). Measurement is done at TATJ, and variations in the parameter of all measurement (except for Temperature Coefficient of Output Voltage)caused by temperature change are not considered.
UTC
QW-R102-017,C
UTC UR3325
POWER DISSIPATION
POWER DISSIPATION, P D (W) 12.5 10 7.5 5 2.5 0
(1) 10.0
AMBIENT TEMPERATURE, T a ()
OR
1 10F Ceramic
Vcc GND
0.33F
22F
Io
UTC
QW-R102-017,C
UTC UR3325
Vo1 or Vo2
22F
Io
APPLICATION INFORMATION
Operation Supply Voltage Range
The circuit functionality is guaranteed within operation of ambient temperature range, as long as it is within operation supply voltage range. The standard electrical characteristic values are guaranteed at the test circuit voltage of Vcc=5V. The cannot be guaranteed at other voltages in the operating range of 3.0V~16.0V, homever, the variation will be small. Input /Output characteristic
VOUT
For proper regulation, this device must be operated in the Recommended Operating Region shown above.
Power Dissipation
Refer to the thermal duration characteristics shown in Fig.3. Also, be sure to use this IC within a power dissipation rage allowing enough margins.
UTC
QW-R102-017,C
UTC UR3325
serially as ESR. For the bypass capacitor, a 0.33F capacitor placed as close to Vcc pin and GND pin as possible is recommended.
Grounding
It is recommended that every capacitor (bypass and output capacitors) is grounded to PIN3 using single-point connections.
Electromagnetic Fields
The IC is susceptible to strong electromagnetic fields and may cause malfunction. Therefore, caution should be used when placing it on the PCB.
Protection Diodes
It is recommended that protection diodes be used when the output is connected to an inductive load.
UTC assumes no responsibility for equipment failures that result from using products at values that exceed, even momentarily, rated values (such as maximum ratings, operating condition ranges, or other parameters) listed in products specifications of any and all UTC products described or contained herein. UTC products are not designed for use in life support appliances, devices or systems where malfunction of these products can be reasonably expected to result in personal injury. Reproduction in whole or in part is prohibited without the prior written consent of the copyright owner. The information presented in this document does not form part of any quotation or contract, is believed to be accurate and reliable and may be changed without notice.
UTC
QW-R102-017,C