Beruflich Dokumente
Kultur Dokumente
Users Mannual
ID-0/2/10/12/15/20/ 20-MFIA/WA Demo board
V3.02
ID Innovataions
1. Suitable modules
Module type
ID-0 ID-2 ID-10 ID-12 ID-15 ID-20 ID-20-MFIA ID-20-MFWA
Type
EM read only EM read only EM read only EM read only EM read only EM read only Mifare read/write Mifare read/wirte
Discribtion
No internal coil with ASCII and WG26 output No internal coil with ASCII I and WG26 and Magetic output With internal coil with ASCII and WG26 output With internal coil with ASCII I and WG26 and Magetic output With internal coil with ASCII WG26 and Magetic output and
With internal coil with ASCII and WG26 and Magetic output With internal coil with ASCII and WG26 and Magetic output No internal coil with ASCII and WG26 and Magetic output
2. Definition output
please use the datasheet as a reference for defferent module testing.
J1
PIN No 1 2 3 4 Pin Definition +5 GND RXD TXD
J2For MF module
PIN No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Pin Definition GND 0V To External antenna TX1 To External antenna TX2 To External antenna RX1 Card Present Future Format Selector (+/-) Data 1 Data 0 LED(LED/BEEPER) No Connection RXD TXD DC Voltage Supply
ID Innovataions
J3For EM module
PIN No 1 2 3 4 5 6 7 8 9 10 11 Pin Definition GND 0V RES To External antenna ANT1 To External antenna ANT2 Card Present Future Format Selector (+/-) Data 1 Data 0 LED(LED/BEEPER) DC Voltage Supply
Warning: when using the J40, the USB port is not available to use. usecommunication!
3
ID Innovataions
J01 : PC 3 wire COM Port, cross link with PC J40: USB interface is pretend to be a virtual COM port at the PC end. P1: 9v12v DC input.
Warning: Do not connect both USB and Serial port at the same time.
Testing procedure
1. Mifare module testing
a) b) c) d) e) f) Install attached Demo software < DEMO VB setup V3.0> and <USB Driver V3.0> to the PC. Connect the J01 with PC by attached D9 cable. Dis-link the J8 Plug in the ID-20MF-IA into J2 (make sure there is no module on the J3). Connect with the power on P1, Swich on the power by pressing the swich buton J00. The system starts work when the buzzle beeps. Use the Mifare Demo software to operate the read and write Before read or write a card, please detect the modules baud rate first then change it to the suitable baud rate. If testing an ID-20MF-WA, it is necessary to link an external antenna PCB on the J7.