Beruflich Dokumente
Kultur Dokumente
Applicable even on defective surfaces and provide PERFORATED PLASTER PROFILE superior plaster adhesion.
PS 1030
TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Galvanizing 0,40 mm 32*32 mm 24 Daldrma Galvaniz
BA ADED
PS 1010
(Imperforate) PERFORATED PLASTER PROFILE
Especially for interior areas, profiles with expanded metal flanges and sharp-edged head shape for superior plaster adhesion. Production is done in the desired size.
TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Galvanizing 0,40 mm 33*33 mm 24
KE PROFL,KE
PS 1052
SQUARE HOLE PLASTER PROFILE
Corner profiles made of aluminium and galvanised sheet steel, 6 mm plaster thickness; for thin- layer plaster in interior areas, for facade renovation trowel work as well as for composite thermal insulation systems (reinforcing fabric must be applied into the profiles head for composite thermal insulation systems). Production is done in the desired size.
TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Galvanizing//Aluminium 0,35-0,40 mm 26,5*26,5 mm 25
PS 1135
PLASTER BOART 135 DEGREE CORNER POFILE
Corner profiles are used on skimmed plasterboard.Profile forms an angle of 135 degrees. All corner profiles have to be embedded completely into joint filler and have to be skimmed up to the nosing. Where cutting is required this should be carried out by using a fine toothed hacksaw.
PS KPM
PLASTER BOART FINISH PROFILE
This profile uses to close finish details of corner. Production is done in the desired size.
TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Galvanizing//Aluminium 0,40 mm 11*25 mm 25
PS AN
DEPTH GAUGE BEAD
Depth gauge profiles are the rational way to produce precise, plane-flat plastered surfaces and to ensure exact inside corner formations. When setting these elements, be sure they are spaced at intervals not greater than 180 mm. When forming inside corners, the distance between the corner and the profile should be 10 cm. Production is done in the desired size. . TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Galvanizing 0,30mm-0,35 mm 6-10 mm 50
PS SB
SOCLE PROFILE
Box shaped socle profiles for thermal insulation systems. Available for greater insulation thickness on request. Production is done in the desired size.
. TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Aluminium 0,65mm 33-43-53mm 10
PS DM
DROPPER PROFILE
The building protects from water surface. Production is done in the desired size.
TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Aluminium 0,50mm 25mm*20mm 10 160gr/m2 mesh
PS FL
ALCALI RESISTANCE MASH CORNER PROFILES
Corner profiles combined with fine fibreglass mesh made of Aluminum-PVC for composite thermal insulation systems. Production is done in the desired size.
TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS ALMNYUM -- PVC 0,40mm TEKNK ZELLKLER 100*115mm 50
PS 1021-23-25
PLASTER BOART CORNER PROFILE
Used for protect and give a formal shape. Only for use under satin gypsum plaster. Plaster depth 3mm. Flange width 25mm(1), 23mm(2) ,21 mm(3) Production is done in the desired size. TECHNICAL SPECIFICATIONS
MATERIAL THICKNESS WING WIDTH PCS Galvanizing//Aluminium 0,30mm-0,35mm-0,40mm (21*21)-(23*23)-(25*25)mm 25
TEKNK ZELLKLER