Beruflich Dokumente
Kultur Dokumente
Control facilities and crewmembers of airliners before an accident. Some individuals may
consider these files to be of a graphic nature, and viewer discretion is advised.
The filesizes of each file, in kilobytes, are located next to the 'Download' link. Some files are
quite large, and may require a long period of time for the download to complete, especially if you
are using a dialup internet connection.
United Airlines Flight 93 was hijacked on September 11, 2001 near Cleveland, Ohio. The aircraft
crashed some time later in a field in south-western Pennsylvania. The hijackers can be heard
twice mistakenly transmitting messages intended for the passengers over the Cleveland ARTCC
frequency. Please note that this tape is not chronologically accurate; periods of dead air
(silence) have been removed for brevity.
Download (925k) the aircraft's Air Traffic Control tape in MP3 format.
USAir Flight 1493 had been cleared to land on Runway 24L at Los Angeles International Airport
when the 'Local' Air Traffic Controller cleared a Skywest Airlines commuter aircraft to 'taxi into
position and hold' on the same runway, with the intention of clearing the Skywest turboprop for
takeoff before the USAir jet landed. The controller failed to issue the clearance, however, and in
the dark, the USAir jet landed and collided with the Skywest aircraft.
Download (82k) the aircraft's Air Traffic Control tape in MP3 format.
The aircraft crashed while executing a non-precision localizer approach to runway 6R at Agana.
The crew descended below the approach profile, and struck terrain approximately 3 miles short
of the runway. The crew did not understand that the glideslope of the ILS system was out of
service.
Download (114k) the aircraft's Air Traffic Control tape in MP3 format.
Southern Airways Flight 242 crashed onto a highway near Hope, Georgia after penetrating a
severe thunderstorm, resulting in the loss of both engines.
Download (127k) the aircraft's Air Traffic Control tape in MP3 format.
Shortly after takeoff from Memphis, a jumpseat passenger aboard Federal Express Flight 705
(DC-10), attempted to take over the aircraft. Although critically injured, the crew returned to
Memphis for a successful landing. The would-be hijacker, a FedEx pilot who was to be
terminated from the airline, was sentenced to life in prison in wake of the incident.
Download (320k) the aircraft's Air Traffic Control tape (part 1) in MP3 format.
Download (173k) the aircraft's Air Traffic Control tape (part 2) in MP3 format.
Download (222k) the aircraft's Air Traffic Control tape in MP3 format.
EgyptAir Flight 990 crashed approximately 50 nautical miles off the Nantucket, Mass. coast in
October, 1999. The Boeing 767's Flight Data Recorder indicates that the aircraft entered a high-
rate descent, recovered, and then broke apart at 13,000 feet. This ATC tape excerpt picks
up just after Boston Center lost contact with the flight.
Download (129k) the aircraft's Air Traffic Control tape in MP3 format.
American Airlines flight 191 crashed shortly after takeoff from Chicago's O'Hare International
Airport in May, 1979, after the aircraft's no.1 engine separated during its takeoff roll. This
recording reproduces the conversation between the Air Traffic Controllers in O'Hare Tower, as
well as the on-duty controller's message to Flight 191 asking their intentions.
Download (88k) the aircraft's Air Traffic Control tape in MP3 format.
Alaska Airlines Flight 261 crashed into the Pacific Ocean near Pt. Magu, California after the
crew reported a problem with the aircraft's vertical stabilizer. This ATC tape excerpt picks up as
the crew reports the problem to Los Angeles Center, and ends shortly after several passing
aircraft witness the Alaska Airlines jet plunge into the Pacific.
Download (930k) the aircraft's Air Traffic Control tape in MP3 format.
PSA Flight 182, a Boeing 727-200, crashed while approaching the San Diego Lindbergh field
after colliding with a Cessna 172 owned by Gibbs Flight Services. When the PSA jet reported
the Cessna in sight, the tower instructed the crew to "maintain visual separation from that
traffic." Flying due east into the morning sun, the crew lost the aircraft, and they collided minutes
later. This is NOT the Cockpit Voice Recording from the 727, but rather the ATC tapes taken
from SAN Tracon and Tower the day of the accident. Only conversations between PSA 182 and
the approach controller / tower are featured.
Download (193k) PSA 182's Air Traffic Control tapes in MP3 format.
ValuJet Flight 592 (aka Critter 592), a DC-9-32, crashed minutes after takeoff from Miami
International Airport after a fire in the cargo hold. Improperly packaged oxygen canisters ignited
causing all of the aircraft's controls to be rendered useless. These are actual recordings from
Miami Center of the ATC communications between the doomed aircraft and the controller.
Download (108k) "Critter 592 needs to come back to Miami... smoke in the cockpit, smoke in
the cabin."
Download (70k) "Critter 592, we need, uh, the closest airport available."
Download (75k) Controller advises WINCO center controller of situation.
Download (121k) No response from Critter 592 - 1
Download (78k) No response from Critter 592 - 2
TWA Flight 800 crashed seven minutes after takeoff from New York's Kennedy airport. Climbing
through 13000 feet, the aircraft's center fuel tank exploded, separating the aircraft into two
pieces. The aircraft then fell into the Atlantic ocean. These are the actual recordings between
Boston Center and pilots who had witnessed the accident.