Beruflich Dokumente
Kultur Dokumente
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 23
Saab 9-2X 2005-2006
FUNCTON COLOR LOCATON
Start: WHTE/BLACK (+) GNTON SWTCH HARNESS*
gnition #1: GREEN (+) GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW (+) GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK (+) Brake Pedal Switch
Tach Signal: GREEN or BLUEGREEN ECM below GLOVE BOX
Parking Lights: BLACK/RED or ORANGE
(+)
At Light Switch
Headlights: N/A At Light Switch
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: NTEGRATON Module is located to the LEFT of the STEERNG COLUMN. On TURBO
models the TACH wire is in Pin 10 of the 35-pin plug, and on the NON-TURBO models the TACH
wire is in pin 9 of the 24 pin plug.
Saab 9-2X 2005-2006
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE (+) gnition Switch Harness
OEM Alarm Disarm: DSARMS with
FACTORY REMOTE
ONLY
Dome
Lights/Superv:
BLUE (-) GRAY Plug, NTEGRATON Module
OEM Horn: RED/GREEN (-) HORN SWTCH
Power Lock: RED/WHTE GRAY Plug in NTEGRATON Module
Power Unlock: YELLOW/RED BLUE Plug in NTEGRATON Module
Trunk Release: N/A
Alarm nput Wire: N/A
NOTES: NTEGRATON Module is located to the LEFT of the STEERNG COLUMN. On TURBO
models the TACH wire is in Pin 10 of the 35-pin plug, and on the NON-TURBO models the TACH
wire is in pin 9 of the 24 pin plug.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 23
Saab 9-3 1999-2002
FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: GREEN/RED GNTON SWTCH HARNESS
gnition #2: GREEN/RED GNTON SWTCH HARNESS
gnition #3: BLUE GNTON SWTCH HARNESS
Accessory: BROWN/GRAY GNTON SWTCH HARNESS
Brake Light: PURPLE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/YELLOW
AT COL PACK ON TOP OF MOTOR UNDER
METAL COVER
Parking Lights: GRAY/RED (+) AT HEADLGHT SWTCH **
Headlights: GREEN/RED (+) AT HEADLGHT SWTCH
Diesel Glow Plug: N/A
Clutch Bypass Wire:
NOTES: * This Vehicle s Equipped With A Transponder Type Theft System - Use Universal
Alarm Bypass Module or see nstallation Note #144 - Bypassing Transponder Theft Systems.
Saab 9-3 1999-2002
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: DSARMS WTH
UNLOCK
Dome
Lights/Superv:
SEE NOTE BELOW ***
OEM Horn: SEE NOTE BELOW ****
Power Lock: RED/PURPLE (-)***** PN 56 OF KEYLESS MODULE
UNDERNEATH DRVER'S SEAT
Power Unlock: BLUE/BROWN (-) PN 33 OF KEYLESS MODULE
UNDERNEATH DRVER'S SEAT
Trunk Release: GREEN/BLUE (-) AT SWTCH
Alarm nput Wire: SEE NOTE BELOW ***
NOTES: *** The Driver's Door Trigger s Gray/Green (-) n Pin 61, Front Passenger Door s
Black/Green (-) n Pin 60, Driver's Rear Door s Black/Green n Pin 12, Passenger Rear Door s
Black/Green n Pin 36. All Wires Are Found At Keyless Module Under Driver's Seat. Diode
solate Each Wire With Band Facing Away From The Remote Starter/Keyless Entry Module. ****
Connect The Yellow/White And Yellow Black Wires Together Through A Relay. Wires Are Found
n Steering Column Harness. ***** See Note #201 Negative Trigger Door Locks
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 23
Make: Model: Year:
Saab 9-3 2003-2004
FUNCTON COLOR LOCATON
Start: BROWN/WHTE (-) ECM Drivers side Connector Pin 58
gnition #1: RED/BLUE (+) GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE (+) GNTON SWTCH HARNESS
Brake Light: RED/GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/YELLOW or BLACK ANY FUEL-NJECTOR or GNTON COL
Parking Lights: BROWN/YELLOW (-) AT HEADLGHT SWTCH
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: The ECM is located on the FRONT PASSENGER side of the ENGNE. This vehicle
uses a 1-Wire Door Locking System the Resistor values are not known at this time, you can
check these values by cutting the wire and metering the switch side of this wire by holding the
switch to get the values. The DRVERS DOOR is a GREEN to GREY (-) at Pin A12, the
PASSENGER DOOR is a GREEN to ORANGE/BLUE (-) Pin A11, the DRVERS REAR DOOR is
a PURPLE to BROWN/ORANGE (-) Pin A10, the PASSENGER REAR DOOR is a PURPLE to
WHTE (-) Pin A9. When connecting to an alarm system use all 4 wires and DODE SOLATE.
For DOMELGHT SUPERVSON use the DRVERS DOOR GREEN to GREY (-) at Pin A12. The
BCM is part of the FUSEBOX under the DRVERS SDE of the DASH. The COLUMN
NTEGRATON MODULE is located in the Steering Column.
Saab 9-3 2003-2004
FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE (+) GNTON SWTCH HARNESS
OEM Alarm Disarm: DSARMS with
FACTORY REMOTE
ONLY
Dome
Lights/Superv:
SEE NOTE BELOW
OEM Horn: BLUE/WHTE (-) COLUMN NTEGRATON MODULE
Power Lock: COLUMN
NTEGRATON MODULE
CENTRAL LOCK SWTCH N DRVERS
DOOR
Power Unlock: Same wire
Trunk Release: GREEN/WHTE to
BROWN/RED (-)
BCM Pin B58
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 23
Alarm nput Wire: TRANSPONDER,
REQURES BYPASS
and EXTRA GNTON
KEY
NOTES: The ECM is located on the FRONT PASSENGER side of the ENGNE. This vehicle
uses a 1-Wire Door Locking System the Resistor values are not known at this time, you can
check these values by cutting the wire and metering the switch side of this wire by holding the
switch to get the values. The DRVERS DOOR is a GREEN to GREY (-) at Pin A12, the
PASSENGER DOOR is a GREEN to ORANGE/BLUE (-) Pin A11, the DRVERS REAR DOOR is
a PURPLE to BROWN/ORANGE (-) Pin A10, the PASSENGER REAR DOOR is a PURPLE to
WHTE (-) Pin A9. When connecting to an alarm system use all 4 wires and DODE SOLATE.
For DOMELGHT SUPERVSON use the DRVERS DOOR GREEN to GREY (-) at Pin A12. The
BCM is part of the FUSEBOX under the DRVERS SDE of the DASH. The COLUMN
NTEGRATON MODULE is located in the Steering Column.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 23
Saab 9-3 ConvertibIe 2003-2004
FUNCTON COLOR LOCATON
Start: BLACK GNTON SWTCH HARNESS*
gnition #1: GREEN/RED GNTON SWTCH HARNESS
gnition #2: BROWN/GRAY GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: GREEN/RED GNTON SWTCH HARNESS
Brake Light: VOLET ( + ) Brake Pedal Switch
Tach Signal: GRAY/RED At gnition Coil
Parking Lights: GRAY/RED ( + ) At Light Switch
Headlights: RED ( + ) At Light Switch
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: *This vehicle may be equipped with a Transponder Anti-Theft System. Use a universal
alarm bypass module.
Saab 9-3 ConvertibIe 2003-2004
FUNCTON COLOR LOCATON
Constant +12 Volts: RED ( + ) gnition Switch Harness
OEM Alarm Disarm:
Dome
Lights/Superv:
RED/WHTE ( - ) DR. Kick Panel
OEM Horn:
Power Lock: YELLOW/BROWN ( - ) DR. Kick Panel ***
Power Unlock: YELLOW/GRAY ( - ) DR. Kick Panel ***
Trunk Release:
Alarm nput Wire: RED/WHTE ( - ) DR. Kick Panel
NOTES: *** See Note #201 Negative Trigger Door Locks
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 23
Make: Model: Year:
Saab 9-5 1998-2003
FUNCTON COLOR LOCATON
Start: BLUE GNTON SWTCH HARNESS *
gnition #1: BLUE/RED GNTON SWTCH HARNESS
gnition #2: GREEN GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: PURPLE GNTON SWTCH HARNESS
Brake Light:
Tach Signal: YELLOW/BLUE
ABOVE DRECT GNTON MODULE (15
PN)
Parking Lights: BLUE/RED (+) BEHND FUSE PANEL BETWEEN FUSE 3 &
4
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Vehicle s Equipped With Transponder Type Engine mmobilizer. See nstallation Note
#144 - Bypassing Transponder Theft Systems.
Saab 9-5 1998-2003
FUNCTON COLOR LOCATON
Constant +12 Volts:
OEM Alarm Disarm: BLUE/YELLOW (-) DRVER'S KCK PANEL (UNLOCKS DR.
DOOR)
Dome
Lights/Superv:
OEM Horn:
Power Lock: BLACK/WHTE (-) DRVER'S KCK PANEL *
Power Unlock: BLUE/YELLOW (-) DRVER'S KCK PANEL ***
Trunk Release: YELLOW (-) DRVER'S KCK PANEL
Alarm nput Wire:
NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram. *** A Single Pulse Disarms
Alarm And Unlocks Driver's Door, Double Pulse Unlocks All Doors. Program unit for Double
Pulse Unlock or See Note #231
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 23
Make: Model: Year:
Saab 9-5 2003-2006
FUNCTON COLOR LOCATON
Start: YELLOW (+) gnition Switch Harness**
gnition #1: RED/BLUE (+) gnition Switch Harness
gnition #2: GREEN (+) gnition Switch Harness
gnition #3: N/A
Accessory: PURPLE (+) gnition Switch Harness
Brake Light: Green/Gray (+) At Brake Switch
Tach Signal: Blue/Red Left Side of Engine
Parking Lights: RED/GREEN (+) At Headlight Switch
Headlights: N/A At Headlight Switch
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: **This vehicle may be equipped with a Transponder Anti-Theft System. Use a universal
alarm bypass module.*1st pulse disarms alarm. Second Pulse will unlock doors. f installing
keyless into a vehicle with OEM alarm program keyless for double-pulse locks and connect
keyless unlock wire to disarm wire.
Saab 9-5 2003-2006
FUNCTON COLOR LOCATON
Constant +12 Volts: Red gnition Switch Harness
OEM Alarm Disarm: Blue/Yellow Drivers Kick Panel*
Dome
Lights/Superv:
RED/GREEN (+) DCE Control Module Pin 23
OEM Horn: Brown/Orange (-) n steering Column Harness**
Power Lock: Blue/Red Drivers Kick Panel - SEE NOTES
Power Unlock: Blue/Red SEE NOTES BELOW! **** & *****
Trunk Release: YELLOW (-) TWCE Module Pin 11
Alarm nput Wire: Black Driver Kick Panel
NOTES: *f installing keyless into a vehicle with OEM alarm, program keyless for double-pulse
locks and connect keyless unlock wire to disarm wire - See above. **USE CAUTON- Harness
may contain air-bags wires! To avoide injury or vehicle damage, use only a digital meter set for
DC volts when making your measurement! The correct horn wire will show 12 volts when you are
NOT pressing the horn, 0 volts when the horn is sounding. **** 2003 vehicle Lock wire is
BLUE/RED (-)& UNLOCK is BLUE/WHTE (-)*****Drivers-Blue/Red. Passenger front-Green/Blue.
Rear- Yellow/White. Diode isolate the three wires using 1N4001 diodes to unlock all doors at
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 23
once. The end of the 3 diodes with the band will connect to the keyless unlock wire from the
module. The end of each diode without the band will connect to the vehicles unlock wire. DCE
Module is located above the Main relay board under the drivers side of dash. TWCE Module
(theft module) is located UNDER the DRVERS SEAT. When testing the Lock and Unlock wires,
you must test while turning the key in the drivers door key cylinder.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 23
9-7 2005 - 2006
KEY
T-
HARNE
SS
MMOBLZER
N/A N/A GM'S PASSKEY 3 TRANSPONDER ANT-THEFT SYSTEM, and Extra gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to Battery only!!
STARTER YELLOW (+) @ GNTON HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) @ GNTON HARNESS
GNTON 2 WHTE (+) @ GNTON HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) @ GNTON HARNESS
ACCESSORY/HEATER
BLOWER 2
BROWN (+) @ GNTON HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ HEADLGHT SWTCH or
BCM, TAN Plug, Pin E5, See
NOTE *1
PARKNG LGHTS ( + ) BROWN (+)
@ FUSEBOX under LEFT
REAR SEAT
POWER LOCK See NOTE *2
POWER UNLOCK See NOTE *2
DOOR TRGGER
Use DOME LGHT
SUPERVSON wire
DOMELGHT SUPERVSON GRAY/BLACK (+)
@ FUSEBOX under LEFT
REAR SEAT
TRUNK RELEASE N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saab - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 23